PDF(996 KB)
PDF(996 KB)
PDF(996 KB)
远程氩等离子体对聚醚砜膜表面性能的改性
Surface properties modification of polyethersulfone membrane by remote argon plasma
采用双悬浮探针和电子自旋共振法定量对远程氩等离子体进行诊断，确定了电子、离子浓度和自由基浓度的分布，以预测表面改性的最佳区；利用远程氩等离子体对聚醚砜（PES）超滤膜进行表面改性，通过接触角测量、扫描电子显微镜和X射线光电子能谱分析改性前后膜表面结构和性能的变化，最后利用牛血清蛋白分离实验分析改性前后膜的分离性能和抗污染性能变化.结果表明，氩等离子体中电子、离子浓度沿轴向距离逐渐降低，在30cm后接近于0，而40cm处自由基浓度仍维持在90%以上，为可能的最佳表面改性区；在该区对PES超滤膜改性后，引入含氧基团和含氮基团，膜表面（O+N）/C原子比从0.18增大到0.46，增强膜表面极性；在最佳处理条件下，膜表面接触角从67°减小到18°，使膜表面亲水性能增强，抑制了电子、离子对膜的刻蚀作用；通过牛血清蛋白实验测定改性后膜污染率由70.3%减小到64.7%，抗污染性能提高.
In this paper, the concentration distribution of electrons, ions and free radicals in remote argon plasma was studied by using double suspension probe and electron spin resonance method to predict the optimal surface modification region. Then, PES membranes were placed in this region and modified by remote argon plasma. Water contact angle measurement, X-ray photoelectron spectroscopy and scanning electron microscope were used to characterize the surface structure and properties of PES membranes. Finally, the separation performance and anti-pollution performance of membranes before and after modification were analysed in bovine serum albumin separation experiment. The results showed the electron and ion concentrations in the argon plasma gradually decrease along the axial distance, close to 0 after 30cm, and the free radical concentration at 40cm still remains above 90%, which was the best possible surface modification region. In the remote region, oxygen-containing groups and nitrogen-containing groups were introduced in PES membranes surface, and the (O+N)/C atomic ratio of the membrane was increased from 0.18 to 0.46 to enhance the surface polarity of the membrane. The modified PES membranes in remote region obtained a higher hydrophilicity and the etching by electron and ions on PES membrane surface was prohibited. Under optimal processing conditions, the contact angle decreases from 67° to 18° and the membrane fouling rate after modification reduces from 70.3% to 64.7%.
表面改性 / 聚醚砜超滤膜(PES) / 亲水性能 / 氩等离子体
argon plasma / hydrophilic / polyethersulfone membrane (PES) / surface modification
[1] 许浩,顾凯锋,李韵浩,等.低截留分子量聚醚砜超滤膜[J]. 化工学报, 2019,70(5):1999-2006. Xu H, Gu K F, Li Y H, et al. Polyethersulfone ultrafiltration membrane with low molecular weight cut off[J]. CIESC Journal, 2019,70(5):1999-2006.
[2] Dasgupta J, Sikder J, Chakraborty S, et al. Remediation of textile effluents by membrane based treatment techniques:a state of the art review[J]. Journal of Environmental Management, 2015,147:55-72.
[3] Vincent-Vela M C, Álvarez-Blanco S, Lora-García J, et al. Application of several pretreatment technologies to a wastewater effluent of a petrochemical industry finally treated with reverse osmosis[J]. Desalination and Water Treatment, 2015,55(13):3653-3661.
[4] Loh C H, Wang R, Shi L, et al. Fabrication of high performance polyethersulfone UF hollow fiber membranes using amphiphilic Pluronic block copolymers as pore-forming additives[J]. Journal of Membrane Science, 2011,380(1/2):114-123.
[5] Lin Z, Hu C, Wu X, et al. Towards improved antifouling ability and separation performance of polyethersulfone ultrafiltration membranes through poly(ethylenimine) grafting[J]. Journal of Membrane Science, 2018,554:125-133.
[6] Ju J, Wang C, Wang T, et al. Preparation and characterization of pH-sensitive and antifouling poly(vinylidenefluoride) microfiltration membranes blended with poly(methylmethacrylate-2-hydroxyethyl methacrylate-acrylic acid)[J]. Colloid Interface Sci., 2014,434:175-180.
[7] Rana D, Matsuura T. Surface modifications for antifouling membranes[J]. Chem. Rev., 2010,110(4):2448-2471.
[8] Xu Z, Liao J, Tang H, et al. Antifouling polysulfone ultrafiltration membranes with pendent sulfonamide groups[J]. Journal of Membrane Science, 2018,548:481-489.
[9] Gao W, Liang H, Ma J, et al. Membrane fouling control in ultrafiltration technology for drinking water production:a review[J]. Desalination, 2011,272(1-3):1-8.
[10] Goosen M F A, Sablani S S, Al-Hinai, H, et al. Fouling of Reverse Osmosis and Ultrafiltration Membranes:A Critical Review[J]. Separation Science and Technology, 2005,39(10):2261-2297.
[11] Guo W S, Ngo H H, Li J X. A mini-review on membrane fouling[J]. Bioresource Technology, 2012,122:27-34.
[12] Moghimifar V, Raisi A, Aroujalian A. Surface modification of polyethersulfone ultrafiltration membranes by corona plasma-assisted coating TiO2 nanoparticles[J]. Journal of Membrane Science, 2014, 461:69-80.
[13] Irem D H, Haci A H. Fouling behavior of poly(ether)sulfone ultrafiltration membrane during concentration of whey proteins:Effect of hydrophilic modification using atmospheric pressure argon jet plasma[J]. Colloids and Surfaces B:Biointerfaces, 2017,160:510-519.
[14] 陈颖青,文越,吴志超,等.基于HBPs接枝的PVDF膜亲水改性及抗污染性能[J]. 中国环境科学, 2019,39(9):3736-3743. Chen Y Q, Wen Y, Wu Z C, et al. Hydrophilic modification of PVDF membrane based on HPBs and its antifouling properties[J]. Chinese Environmental Sciences, 2019,39(9):3736-3743.
[15] Liu X, Wang G, Liu J, et al. Influence of water addition on the modification of polyethylene surface by nitrogen atmospheric pressure plasma jet[J]. Journal of Applied Polymer Science, 2019:136.
[16] Bretagnol F, Tatoulian M, Arefi-Khonsari F, et al. Surface modification of polyethylene powder by nitrogen and ammonia low pressure plasma in a fluidized bed reactor[J]. Reactive and Functional Polymers, 2004,61(2):221-232.
[17] Jaleh B, Parvin P, Wanichapichart P, et al.Induced super hydrophilicity due to surface modification of polypropylene membrane treated by O2 plasma[J]. Applied Surface Science, 2010,257(5):1655-1659.
[18] Afkham S, Raisi A, Aroujalian A. Reducing fouling of polyethersulfone microfiltration membranes by corona air plasma[J]. Desalination and Water Treatment, 2016,57(56):26976-26992.
[19] Pegalajar-Jurado A, Mann M N, Maynard M R, et al. Hydrophilic modification of polysulfone ultrafiltration membranes by low temperature water vapor plasma treatment to enhance performance[J]. Plasma Processes and Polymers, 2015,13(6):598-610.
[20] Wei X, Zhao B, Li X M, et al. CF4plasma surface modification of asymmetric hydrophilic polyethersulfone membranes for direct contact membrane distillation[J]. Journal of Membrane Science, 2012,407-408:164-175.
[21] Bryjak M, Gancarz I, Po?niak G, et al. Modification of polysulfone membranes:4. Ammon. Plasma Treat.[J]. European Polymer Journal, 2002,38:717-726.
[22] Yamagishi H, Crivello J V, Belfort G. Development of a novel photochemical technique for modifying poly (arylsulfone) ultrafiltration membranes[J]. Journal of Membrane Science, 1995, 105(3):237-247.
[23] Goldman A, Amouroux J. Electrical breakdown and discharge in gases, macroscopic processess and discharge[M]. New York:Plenum, 1983:293-246.
[24] Li R, Chen J R. Studies on wettability of medical poly (vinyl chloride) by remote argon plasma[J]. Applied Surface Science, 2006,252(14):5076-5082.
[25] Oshima A, Seguchi T, Tabata Y. ESR study on free radicals trapped in crosslinked polytetrafluoroethylene (PTFE)[J]. Radidl. Phys. Chem, 1997,50(6):601-606.
[26] Chipara M, Romero J R, et al. ESR studies on laser beam irradiated polyethyleneterephtalate[J]. Nuclear Instruments and Methods in Physics Research, Section B, (Beam Interactions with Materials and Atoms), 2003,211(1):117-121.
[27] Li Y, Wang Q, Guo J L, et al. ESR studies on the interaction of calixarenes and free radicals[J]. Materials Science and Engineering C, 1999,10(1/2):25-28.
[28] Mamedov, Aktas S H V, Canturk B, et al. The ESR signals in silk fibroin and wool keratin under both the effect of UV-irradiation and without any external effects and the formation of free radicals[J]. Biomaterials, 2002,23(16):3405-3412.
[29] 杨保收,陈越,金久善,等.氧自由基检测方法在生物学和医学中的应用[J]. 动物科学与动物医学, 1999,16(3):17-19. Yang B X, Chen Y, Jin J S, et al. Application of oxygen free radical detection in biology and medicine[J]. Animal Science and Veterinary Medicine, 1999,16(3):17-19.
[30] 严建伟,阮积惠.生物体系中自由基检测方法评述[J]. 杭州大学学报(自然科学版), 1998,25(3):75-80. Yan J W, Ruan J H. Free radical detection in biological systems[J]. Journal of Hangzhou University (Natural Science), 1998,25(3):75-80.
[31] 韩鹤友,何治柯,曾云鹗.羟自由基的分析研究进展[J]. 分析科学学报, 2001,17(1):83-87. Han H Y, He Z K, Zeng Y E. Advances in the analysis of hydroxyl radicals in biological samples[J]. Journal of Analytical Science, 2001,17(1):83-87.
国家自然科学基金资助项目（11105102）
京公网安备 11010802030352号 /
| 〈 |
|
〉 |
