填埋场HDPE膜漏洞靶向电动修补技术影响因素

朱铭珠; 姚光远; 刘玉强; 徐亚; 刘景财; 黄启飞; 杨延梅

PDF(633 KB)

中国环境科学 ›› 2022, Vol. 42 ›› Issue (10) : 4696-4703.

固体废物

填埋场HDPE膜漏洞靶向电动修补技术影响因素

朱铭珠^1,2, 姚光远¹, 刘玉强¹, 徐亚¹, 刘景财¹, 黄启飞¹, 杨延梅²

作者信息 +

The influencing factors of targeted electric repair technology for HDPE membrane leakage in landfill

ZHU Ming-zhu^1,2, YAO Guang-yuan¹, LIU Yu-qiang¹, XU Ya¹, LIU Jing-cai¹, HUANG Qi-fei¹, YANG Yan-mei²

Author information +

文章历史 +

摘要

为突破当前HDPE膜漏洞修补技术操作复杂、成本高，且具有安全隐患的难题，探究靶向电动修补技术的工艺参数对修补效果的影响规律，开展了电极类型、电压大小、运行时间、膨润土浓度与分散剂/膨润土投加比例等单因素实验，并探索达到修补效果的最低工艺条件.结果表明，漏洞直径为5mm时，选用石墨电极、电压大小为50V、运行时间为2d、膨润土浓度为10g/L、分散剂/膨润土比例为30%时，修复后HDPE膜漏洞处的渗透系数达到9.41×10^-6cm/s，具有较好的修补效果；此外，通过建立修补溶液体系的Zeta电位与电动修补后漏洞处渗透系数的数学表征模型，为实际场景下的应用提供依据，当渗透系数达到1×10^-6cm/s所对应修补溶液的Zeta电位至少应为-42.11mV.

Abstract

The timely repair of HDPE membrane leakage in landfill is an important means of environmental risk control, which is of great significance to prevent leachate from polluting groundwater and soil environment. In order to solve the problems of complex operation, high cost and security risks during the operation period and after closure of landfill, the single factor experiments on the main influencing factors such as electrode type, voltage, operation time, bentonite concentration and dispersant/bentonite dosage ratio were carried out so as to analyze their impacts on repair effect and explore the best technological. The results showed that the accumulation at the leakage (5mm diameter) possessed good repair effect with the permeability coefficient of 9.41×10^-6 cm/s, when graphite electrode adopted, the control voltage was 50V, the shortest operation time was 2days, the optimal bentonite concentration was 10g/L, and dispersant/bentonite ratio was 30%. In addition, the mathematical characterization model between the Zeta potential of solution system and the permeability coefficient of accumulation at the leakage were established, which can provide basis for the application in practical scenarios. In order to meet the impermeability requirements, the permeability coefficient needs to reach1×10^-6cm/s, the Zeta potential of the corresponding repair solution should be at least -42.11mV.

导出引用

朱铭珠, 姚光远, 刘玉强, 徐亚, 刘景财, 黄启飞, 杨延梅. 填埋场HDPE膜漏洞靶向电动修补技术影响因素[J]. 中国环境科学. 2022, 42(10): 4696-4703

ZHU Ming-zhu, YAO Guang-yuan, LIU Yu-qiang, XU Ya, LIU Jing-cai, HUANG Qi-fei, YANG Yan-mei. The influencing factors of targeted electric repair technology for HDPE membrane leakage in landfill[J]. China Environmental Science. 2022, 42(10): 4696-4703

中图分类号： X705

参考文献

[1] 刘晓民.危险废物填埋场渗滤液对地下水环境的影响[J].环境工程, 2014,32(12):5-9,13.Liu X M.Effect of hazardous waste landfill site leachate on groundwater environment[J].Environmental Engineering, 2014,32(12):5-9,13.
[2] 姜必亮,蓝崇钰,王伯荪.垃圾填埋场渗滤液灌溉后重金属的生态效应[J].中国环境科学, 2001,21(1):18-23.Jiang B L, Lan C Y, Wang B S.Heavy metals ecological effects of irrigation with landfill site leachate[J].China Environmental Science, 2001,21(1):18-23.
[3] 王宝,陈彬,窦桐桐,等.干湿循环与垃圾渗滤液耦合作用下GCL防渗性能[J].中国环境科学, 2020,40(2):701-707.Wang B, Chen B, Dou T T, et al.Hydraulic performance of GCL under wet-dry cycling concurrent with municipal solid waste leachate permeation[J].China Environmental Science, 2020,40(2):701-707.
[4] 刘建国,聂永丰,王洪涛,等.填埋场不同防渗配置下渗滤液及污染物泄漏[J].清华大学学报(自然科学版), 2004,44(12):1684-1687.Liu J G, Nie Y f, Wang H T, et al.Leachate and contaminant leakage in various types of landfill liners[J].Journal of Tsinghua University (Science and Technology), 2004,44(12):1684-1687.
[5] 周炼,安达,杨延梅,等.危险废物填埋场复合衬层渗漏分析与污染物运移预测[J].环境科学学报, 2017,37(6):2210-2217.Zhou L, An D, Yang Y M, et al.Predicting leakage and contaminant transport through composite liners in hazardous waste landfill[J].Acta Scientiae Circumstantiae, 2017,37(6):2210-2217.
[6] 徐亚,能昌信,刘玉强,等.垃圾填埋场HDPE膜漏洞密度及其影响因素的统计分析[J].环境工程学报, 2015,9(9):4558-4564.Xu Y, Nai C X, Liu Y Q, et al.Statistical analysis on density of accidental-hole in landfill liner system[J].Chinese Journal of Environmental Engineering, 2015,9(9):4558-4564.
[7] 李玲,王颋军,唐跃刚,等.封场垃圾填埋场的治理与城市土地可持续利用[J].环境卫生工程, 2013,21(3):20-22,25.Li L, Wang J J, Tang Y G, et al.Remediation of closed waste landfill sites and sustainable utiliZation of urban land[J].Environmental Sanitation Engineering, 2013,21(3):20-22,25.
[8] 刘玉强,能昌信,黄启飞,等.填埋场防渗层HDPE膜漏洞修补装置[P].北京:CN201933518U, 2011-08-17.Liu Y Q, Nai C X, Huang Q F, et al.Leakage repair device of HDPE membrane in landfill impervious layer[P].Beijing:CN20933518U, 2011-08-17.
[9] 吴倩芳.垃圾填埋场自封自修粘土防渗层改性研究[D].长春:吉林大学, 2008.Wu Q F.Study on Self-sealing/Self-healing capacity of modified landfill clay liner[D].Changchun:Jilin University, 2008.
[10] Cote P L, Sloot H.Method for sealing of a mass of waste[P].US:US5502268A.1996-03-26.
[11] 金朝娣,能昌信,王振翀,等.基于STFT填埋场衬层修补技术中振动信号分析[J].计算机仿真, 2011,28(7):277-280.Jin C D, Neng C X, Wang Z Z, et al.Vibration signal analysis of STFT to technology of landfill medium layer'S leaks repair[J].Computer Simulation, 2011,28(7):277-280.
[12] Darilek G T, Corapcioglu M Y, Yeung A T Sealing leaks in geomembrane liners using electrophoresis[J].Journal of Environmental Engineering, 1996,122(6):540-544.
[13] Kambham K, Tuncay K, Corapcioglu M Y.A Semi-analytical analysis of compressible electrophoretic cake formation[J].Water Resources Research, 1995,31(5):1421-1428.
[14] Corapcioglu M Y, Kambham K, Tuncay K.Electrophoretic repair of impoundment leaks:Analysis and verification with experimental data[J].Environmental Science & Technology, 1998,32(23):3778-3784.
[15] Han S J, Kim J Y, Kim B I, et al.The 3-D simulation of electrophoresis method in leachate system for repairing of leaks in waste landfill geomembrane liner[J].Journal of the Korean Society of Civil Engineers C, 2010,30(1C):17-25.
[16] 孙志明,于健,郑水林,等.离子种类及浓度对土工合成黏土垫用膨润土保水性能的影响[J].硅酸盐学报, 2010,38(9):1826-1831.Sun Z M, Yu J, Zheng S L, et al.Effect of ion-type and concentration on water-retention capacity of bentonite used in geosynthetic clay liner[J].Journal of the Chinese Ceramic Society, 2010,38(9):1826-1831.
[17] 高子瑞,陈涛,徐永福.盐溶液对膨润土膨胀性的影响[J].岩土力学, 2018,39(1):249-253.Gao Z R, Chen Tao, Xu Y F.Effect of salt solution on swelling characteristics of bentonite[J].Rock and Soil Mechanics, 2018, 39(1):249-253.
[18] 向锐.危险废物填埋场导排层淤堵机理研究[D].武汉:武汉科技大学, 2019.Xiang R.Research on the mechanism of clogging inthe leachate drainage system of hazardouswaste landfill[D].Wuhan:Wuhan University of Science and Technology, 2019.
[19] 刘玉强,徐亚,刘景财,等.危险废物填埋场环境安全防护评价技术[M].北京:化学工业出版社, 2020:7-28.Liu Y Q, Xu Y, Liu J C, et al.Evaluation of environmental safety protection for hazardous waster landfill[M].Beijing:Chermical lndustry Press, 2020:7-28.
[20] Jo H Y, Katsumi T, Benson C H, et al.Hydraulic conductivity and swelling of nonprehydrated GCLs permeated with single-species salt solutions[J].Journal of Geotechnical & Geoenvironmental Engineering, 2001,127(7):557-567.
[21] 叶超,杜楠,赵晴,等.不锈钢点蚀行为及研究方法的进展[J].腐蚀与防护, 2014,35(3):271-276.Ye C, Du N, Zhao Q, et al.Progress in research of pitting corrosion behavior and research methods of stainless steels[J].Corrosion and Protection, 2014,35(3):271-276.
[22] 臧俊超.污染地基土电渗加固和电动修复理论与试验研究[D].杭州:浙江大学, 2020.Zang, J C.Theoretical and experimental research on electro-osmotic reinforcement and electro-remediation of contaminated foundation soils[D].Hangzhou:Zhejiang University, 2020.
[23] Shang J Q, Dunlap W A.Improvement of soft clays by high electrokinetics[J].Journal of Geotechnical and Geoenvironmental, 1996,122(4):274-280.
[24] 李天玉,陈咏梅,刘永康,等.Fe-Si/Mg-Al滤料电化学催化降解饮用水中氯仿的研究[J].中国环境科学, 2008,28(6):527-530.Li T Y, Chen Y M, Liu Y K, et al.Studies on degradation of disinfection by product chloroform in drinking water electrochemically catalysised by Fe-Si/Mg-Al filter material[J].China Environmental Science, 2008,28(6):527-530.
[25] 梁励芬.电泳迁移率的简便计算方法[J].大学物理, 1996,15(5):5-6,34.Liang L F.A brief calculation method of electrophoresis mobility[J].College Physics, 1996,15(5):5-6,34.
[26] Olphen H V.Surface conductance of various ion forms of bentonite in water and the electrical double layer[J].Journal of Physical Chemistry, 2002,61(10):1276-1280.
[27] 吴辉.软土地基电渗加固方法研究[D].北京:清华大学, 2015.Wuhui.Soft soil improvement by electro-osmosis techniques[D].Beijing:Tsinghua University, 2015.
[28] Casagrande I L.Electro-Osmosis in Soils[J].Géotechnique, 1949, 1(3):159-177.
[29] 胡岳华,邱冠周,王淀佐.细粒浮选体系中扩展的DLVO理论及应用[J].中南矿冶学院学报, 1994,25(3):310-314.Hu Y H, Qiu G Z, Wang D Z.Extended DLVO theory and its application in flotation of fine particles[J].Journal of Central South University of mining and metallurgy, 1994,25(3):310-314.
[30] 万江,王晓焕,刘志勇.膨润土-水悬浮体系的Zeta电位研究[J].非金属矿, 2017,40(4):23-25.Wan J, Wang X H, Liu Z Y.Study on zeta potential of bentonite-water suspension system[J].Non-Metallic Mines, 2017,40(4):23-25.
[31] 杨宗义,刘文礼,焦小淼,等.蒙脱石分散体系中用Zeta电位修正静电作用能的计算[J].煤炭学报, 2017,42(6):7.Yang Z Y, Liu W L, Jiao X M, et al.Calculation of electrostatic interaction energy by using Zeta potential in montmorillonite dis-persion system[J].Journal of China Coal Society, 2017,42(6):1572-1578.
[32] 刘晓光,李国军,仝建峰,等.氧化锆水系料浆稳定性研究[J].材料工程, 2003,31(9):30-32,29.Liu X G, Li G J, Tong J F, et al.Study on stability of zirconia aqueous slurries[J].Journal of Materials Engineering, 2003,31(9):30-32,29.
[33] 杨铁笙,熊祥忠,詹秀玲,等.粘性泥沙悬浮液中颗粒表面滑动层厚度的计算[J].水利学报, 2002,33(5):20-26.Yang T S, Xiong X Z, Zhan X L, et al.The Study on slipping water layers of cohesive sediment particles[J].Journal of Hydraulic Engineering, 2002,33(5):20-26.
[34] 杨玉玲.六偏磷酸钠改良钙基膨润土系竖向隔离墙防渗控污性能研究[D].南京:东南大学, 2017.Yang Y L.Contaminat containment performances of soil-phosphate amended calcium bentonite vertical cutoff walls[D].Nanjing:Southeast University, 2017.
[35] 王毓华,陈兴华,胡业民.碳酸钠对细粒铝硅酸盐矿物分散行为的影响[J].中国矿业大学学报, 2007,36(3):292-297.Wang Y H, Chen X H, Hu Y M.Effects of sodium carbonate on the dispersion of fine alumin-silicate minerals[J].Journal of China University of Mining & Technology, 2007,36(3):292-297.
[36] 张文杰,陈云敏,詹良通.垃圾填埋场渗滤液穿过垂直防渗帷幕的渗漏分析[J].环境科学学报, 2008,28(5):925-929.Zhang W J, Chen Y M, Zhan L T.Transport of leachate through vertical curtain grouting in landfills[J].Acta Scientiae Circumstantiae, 2008,28(5):925-929.
[37] Chai J C, Miura N, Hayashi S.Large-scale tests for leachate flow through composite liner due to geomembrane defects[J].Geosynthetics International, 2005,12(3):134-144.