Effect of thermal hydrolysis pretreatment on mesophilic anaerobic digestion of excess sludge
GUO Si-yu, PENG Yong-zhen, LI Xi-yao, HE Yue-lan, GAO Yao-yuan, LI Lu-kai
National Engineering Laboratory for Advanced Municipal Wastewater Treatment and Reuse Technology, Engineering Research Center of Beijing, Beijing 100124, China
The waste activated sludge produced by the treatment of actual domestic sewage was subjected to thermal pretreatment at different time (0~100min) at 70℃, and the effects of different pretreatment time and different solid residence times (20d and 30d) were studied by batch test on the anaerobic digestion of waste activated sludge at 35℃. The results showed that after anaerobic digestion, the average removal rate of total chemical oxygen demand was 55.76% under the conditions that SRT was 20d and pretreatment time was 100min.when the pretreatment time was 100min,the average capillary suction time decreased by 26%(20d) and 37%(30d) comparing with the control group. And the average yield of methane was 10.83mL/d under the condition that SRT was 20d and pretreatment time was 60min. Economic analysis showed that the anaerobic digestion of waste activated sludge can reduce the cost of 50.9~499.5yuan/ton dry sludge after 70℃ pretreatment. Therefore, the best SRT was 20d and the best pretreatment time was 60min for the thermal pretreatment.
Abe N, Tang Y, Iwamura M, et al. Pretreatment followed by anaerobic digestion of secondary sludge for reduction of sewage sludge volume[J]. Water Science and Technology, 2013,67(11):2527-2533.
[2]
Donosobravo A, Perezelvira S, Aymerich E, et al. Assessment of the influence of thermal pre-treatment time on the macromolecular composition and anaerobic biodegradability of sewage sludge[J]. BioresourceTechnology, 2011,102(2):660-666.
[3]
Tiehm A, Nickel K, Zellhorn M, et al. Ultrasonic waste activated sludge disintegration for improving anaerobic stabilization[J]. Water Research, 2001,35(8):2003-2009.
Duan N, Dong B, Wu B, et al. High-solid anaerobic digestion of sewage sludge under mesophilic conditions:Feasibility study[J]. Bioresource Technology, 2012,104:150-156.
[11]
Neyens E, Baeyens J. A review of thermal sludge pre-treatment processes to improve dewaterability[J]. Journal Of Hazardous Materials, 2003,98(3):51-67.
[12]
Appels L, Degreve J, Van der Bruggen B, et al. Influence of low temperature thermal pre-treatment on sludge solubilisation, heavy metal release and anaerobic digestion[J]. Bioresource Technology, 2010,101(15):5743-5748.
[13]
Liao X, Li H, Zhang Y, et al. Accelerated high-solids anaerobic digestion of sewage sludge using low-temperature thermal pretreatment[J]. International Biodeterioration & Biodegradation, 2016,106:141-149.
[14]
Ferrer I, Ponsa S, Vazquez F, et al. Increasing biogas production by thermal (70℃) sludge pre-treatment prior to thermophilic anaerobic digestion[J]. Biochemical Engineering Journal, 2008, 42(2):186-192.
[15]
Zupancic G D, Ros M. Heat and energy requirements in thermophilic anaerobic sludge digestion[J]. Renewable Energy, 2003,28(14):2255-2267.
[16]
Dhar B R, Nakhla G, Ray M B. Techno-economic evaluation of ultrasound and thermal pretreatments for enhanced anaerobic digestion of municipal waste activated sludge[J]. Waste Management, 2012,32(3):542-549.
[17]
Elbeshbishy E, Nakevski A, Hafez H, et al. Simulation of the impact of SRT on anaerobic digestability of ultrasonicated hog manure[J]. Energies, 2010,3(5):974-988.
[18]
王治军,王伟.剩余污泥的热水解试验[J]. 中国环境科学, 2005,25(S1):56-60.
[19]
Valo A, Carrere H, Delgenes J P. Thermal, chemical and thermo-chemical pre-treatment of waste activated sludge for anaerobic digestion[J]. Journal of Chemical Technology and Biotechnology, 2004,79(11):1197-1203.
Appels L, Baeyens J, Degreve J, et al. Principles and potential of the anaerobic digestion of waste-activated sludge[J]. Progress in Energy and Combustion Science, 2008,34(6):755-781.
[23]
Xue Y, Liu H, Chen S, et al. Effects of thermal hydrolysis on organic matter solubilization and anaerobic digestion of high solid sludge[J]. Chemical Engineering Journal, 2015,264:174-180.
[24]
Vlyssides A G, Karlis P K. Thermal-alkaline solubilization of waste activated sludge as a pre-treatment stage for anaerobic digestion[J]. BioresourceTechnology, 2004,91(2):201-206.
[25]
Odegaard H. Sludge minimization technologies-an overview[J]. Water Science and Technology, 2004,49(10):31-40.