Field tests were conducted to research the emission characteristics and environmental risks of polycyclic aromatic hydrocarbons (PAHs) during co-processing of coal liquefaction residue (CLR) in Texaco coal-water slurry gasifier. Comparing the differences between blank condition (without mixing CLR in the slurry) and test condition (15% CLR were mixed into the slurry), the changes of temperature, pressure and syngas composition in the gasifier were recorded, the toxicity equivalent concentration of 16 kinds of PAHs in all the solid, liquid and gas emissions were analyzed to evaluate the feasibility and environmental risks during the co-processing of CLR in Texaco coal-water slurry gasifier. Results showed that during the co-processing process, there had little impact on the pressure and syngas output of the gasifier, but made an increase of 5~11℃ of the temperature and promoted the formation of H2 and CO; the concentration of PAHs in part of the gas emission and liquid emission increased a little, but the toxicity equivalent concentration was still far lower than the standard limitation, has low environmental risk; the concentration of PAHs in solid emission products increased significantly, but the total toxicity equivalent concentration was also low, the environmental risk was in the acceptable range.
李雪冰, 李丽, 黄泽春, 闫大海, 于泓锦, 王宁. 水煤浆气化炉协同处置煤液化残渣的PAHs排放特征[J]. 中国环境科学, 2017, 37(10): 3845-3852.
LI Xue-bing, LI Li, HUANG Ze-chun, YAN Da-hai, YU Hong-jin, WANG Ning. Emission characteristics of polycyclic aromatic hydrocarbons during co-processing of coal liquefaction residue in coal-water slurry gasifier. CHINA ENVIRONMENTAL SCIENCECE, 2017, 37(10): 3845-3852.
Menzie C, Potocki B, Santodonato J. Exposure to carcinogenic PAHs in the environment[J]. Environmental Science Technology, 1992,26(7):1278-1284.
[2]
Wilson S, Jones K. Bioremediation of soil contaminated with polynuclear aromatic hydrocarbons (PAHs):A review[J]. Environmental Pollution, 1992,81(3):229-249.
[3]
Yan J, Wang L, Fu P, et al. Photomutagenicity of 16 polycyclic aromatic hydrocarbons from the US EPA priority pollutant list[J]. Mutation Research/genetic Toxicology & Environmental Mutagenesis, 2004,557(1):99-108.
Liu X, Zhou Z, Hu Q, et al. Experimental study on cogasification of coal liquefaction residue and petroleum coke[J]. Energy & Fuels, 2011,25(8):3377-3381.
[6]
Xu L, Tang M, Duan L, et al. Pyrolysis characteristics and kinetics of residue from China Shenhua industrial direct coal liquefaction plant[J]. ThermochimicaActa, 2014,589(10):1-10.
Child C A, Robin A M. Gasification of residual materails from coal liquefaction[R]. USERDA, 1977.
[11]
Robin A M. Gasification of coal liquefaction residues from the Wilsonville SRC pilot plant using the Texaco coal gasification process[R]. USERDA, 1984.
[12]
Yan D, Peng Z, Karstensen K H, et al. Destruction of DDT wastes in two preheater/precalciner cement kilns in China[J]. Science of the Total Environment, 2014,s 476-477:250-257.
[13]
Yan D, Peng Z, Ding Q, et al. Distribution of Hg, As and Se in material and flue gas streams from preheater-precalciner cement kilns and vertical shaft cement kilns in China[J]. Journal of the Air & Waste Management Association, 2015,65(8):1002-1010.
Du Y, Jiang X, Ma X, et al. Cogasification of biofermenting residue in a coal-water slurry gasifier[J]. Energy & Fuels, 2014,28(3):2054-2058.
[16]
Choi Y, Li X, Park T, et al. Numerical study on the coal gasification characteristics in an entrained flow coal gasifier[J]. Fuel, 2001,80(15):2193-2201.
[17]
Al-Salem S M, Lettieri P, Baeyens J. Recycling and recovery routes of plastic solid waste (PSW):A review[J]. Waste Management, 2009,29(10):2625-2643.
[18]
Cao C, Zhang Y, Yu T, et al. A novel 3-layer mixed cultural evolutionary optimization framework for optimal operation of syngas production in a Texaco coal-water slurry gasifier[J]. Chinese Journal of Chemical Engineering, 2015,23(9):1484-1501.
[19]
梁建红.循环流化床锅炉神华煤液化渣掺烧试验[J]. 热力发电, 2015,44(9):61-65.
[20]
Bae J, Lee D, Park S, et al. High pressure gasification of coal water ethanol slurry in an entrained flow gasifier for bioethanol application[J]. Energy & Fuel, 2012,140(1):451-460.
