等离子体热解气化有机废弃物制氢的关键技术分析

Abstract
Figure/Table
References (60)
Related Citation (15)

Download: PDF (530 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract

Plasma pyrolysis and gasification of organic solid waste to produce hydrogen is an advanced and efficient technology for waste treatment and resource utilization. Firstly, the mechanism of the plasma pyrolysis and gasification technology for solid waste treatment was described, the types and characteristics of the plasma generator was also summarized. Then, the influence factors of plasma treatment of solid waste were analyzed, the input power and the carrier gas type were the main factors influencing the plasma treatment. At last, the application status and prospect of using plasma technology to treat medical waste, agriculture and forestry biomass, sludge etc. were introduced and analyzed in details, points out that the plasma pyrolysis and gasification of solid waste technology is a potential method for hydrogen production.

Key words： plasma pyrolysis gasification organic solid waste hydrogen generation

Received: 15 March 2016

PACS:

X705

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Chang-ming
	WU Jiao
	HUANG Ya-ni

Cite this article:

Chang-ming,WU Jiao,HUANG Ya-ni. Analysis of critical technology for hydrogen production in plasma pyrolysis and gasification of organic waste[J]. CHINA ENVIRONMENTAL SCIENCECE, 2016, 36(11): 3429-3440.

URL:

http://manu36.magtech.com.cn/Jweb_zghjkx/EN/ OR http://manu36.magtech.com.cn/Jweb_zghjkx/EN/Y2016/V36/I11/3429

[1]	Nguyen SCVT. Hydrogen production in a radio-frequency plasma source operating on water vapor[D]. University of Michigan, 2009.
[2]	Du C M, Mo J M, Li H X. Renewable hydrogen production by alcohols reforming using plasma and plasma-Catalytic technologies:challenges and opportunities[J]. Chem. Rev., 2014, 115(3):1503-1542.
[3]	Nzihou A. Waste and Biomass Valorization[M]. Waste & Biomass Valorization, 2010.
[4]	罗婕,刘志国.生物质利用技术研究进展[J]. 株洲师范高等专科学校学报, 2006,11(2):48-51.
[5]	Du C M, Wu J, Ma D Y, et al. Gasification of corn cob using non-thermal arc plasma[J]. International Journal of Hydrogen Energy, 2015,40(37):12634-12649.
[6]	Tendler M, Rutberg P, Oost G V. Plasma based waste treatment and energy production[J]. Plasma Physics & Controlled Fusion, 2005,47(5A):A219-A230.
[7]	邓文义,于伟超,苏亚欣,等.生物质热解和气化制取富氢气体的研究现状[J]. 化工进展, 2013,32(7):1534-1541.
[8]	杨海平.油棕废弃物热解的实验及机理研究[D]. 武汉:华中科技大学, 2005.
[9]	吴玉萍,赵之骏,张建良,等.介质阻挡放电降解苯乙烯的研究[J]. 中国环境科学, 2003,23(6):94-97.
[10]	刘亚纳,严建华,李晓东,等.气液两相滑动弧等离子体处理甲基紫[J]. 中国环境科学, 2007,27(6):786-791.
[11]	李胜利,李劲,王泽文,等.用高压脉冲放电等离子体处理印染废水的研究[J]. 中国环境科学, 1996,16(1):73-76.
[12]	唐兰,黄海涛,赵增立,等.废聚丙烯塑料等离子体热解研究——水蒸气的加入对改善气体品质的影响[J]. 燃料化学学报, 2003,31(5):476-479.
[13]	唐兰,黄海涛.生物质在高频耦合等离子体中的热解气化研究[J]. 可再生能源, 2005,3:24-27.
[14]	Fabry F D, Rehmet C, Rohani V, et al. Waste gasification by thermal plasma:areview[J]. Waste &Biomass Valorization, 2013, 4(3):421-439.
[15]	Zhang Q, Dor L, Biswas A K, et al. Modeling of steam plasma gasification for municipal solid waste[J]. Fuel Processing Technology, 2013,106(2):546-554.
[16]	Demirbas A. Hydrogen production from biomass by the gasification process[J]. Energy Sources, 2002,24(1):59-68.
[17]	Shie J L, Tsou F J, Lin K L, et al. Bioenergy and products from thermal pyrolysis of rice straw using plasma torch[J]. Bioresource Techonology, 2010,101(101):761-768.
[18]	Kim S C, Lim M S, Chun Y N. Hydrogen-rich gas production from a biomass pyrolysis by using a plasmatron[J]. International Journal of Hydrogen Energy, 2013,38(34):14458-14466.
[19]	Attri P, Arora B, Choi E H. Utility of plasma:a new road from physics to chemistry[J]. Rsc Advances, 2013,3(31):12540-12567.
[20]	Locke B R, Sato M, Sunka P, et al. Electrohydraulic discharge and nonthermal plasma for water treatment[J]. Industrial & Engineering Chemistry Research, 2006,45(3):882-905.
[21]	Bonizzoni G, Vassallo E. Plasma physics and technology:industrial applications[J]. Vacuum, 2002,64(3):327-336.
[22]	Tang L, Huang H, Hao H, et al. Development of plasma pyrolysis/gasification systems for energy efficient and environmentally sound waste disposal[J]. Journal of Electrostatics, 2013,71(5):839-847.
[23]	Gomez E, Rani D A, Cheeseman C R, et al. Thermal plasma technology for the treatment of wastes:a critical review[J]. Journal of Hazardous Materials, 2009,161(s2/3):614-626.
[24]	Ruj B, Ghosh S. Technological aspects for thermal plasma treatment of municipal solid waste-A review[J]. Fuel Processing Technology, 2014,126(5):298-308.
[25]	Fauchais P, Vardelle A. Pending problems in thermal plasmas and actual development[J]. Plasma Physics and Controlled Fusion, 2000,42(12):365-383.
[26]	Auciello O, Flamm D L. Plasma diagnostics:discharge parameters and chemistry[J]. Plasma Diagnostics Discharge Parameters and Chemistry, 1989,1:447-456.
[27]	Boulos M I. New frontiers in thermal plasma processing[J]. Pure and Applied Chemistry, 1996,68(5):1007-1010.
[28]	Shie J L, Chang CY, Tu WK, et al. Major Products Obtained from Plasma Torch Pyrolysis of Sunflower-Oil Cake[J]. Energy & Fuels, 2007,22(1):75-82.
[29]	Vaidyanathan A, Mulholland J, Ryu J, et al. Characterization of fuel gas products from the treatment of solid waste streams with a plasma arc torch[J]. Journal of Environmental Management, 2007,82(1):77-82.
[30]	Rutberg P G. Plasma pyrolysis of toxic waste[J]. Plasma Physics and Controlled Fusion, 2003,45(6):957-969.
[31]	Rutberg P G, Kuznetsov V A, Serba E O, et al. Novel three-phase steam-air plasma torch for gasification of high-caloric waste[J]. Applied Energy, 2013,108(8):505-514.
[32]	Snapkauskien? V, Valatkevi?ius P. Water vapor plasma technology for biomass conversion to synthetic gas[J]. Catalysis Today, 2011,167(1):135-140.
[33]	Murphy A B. Plasma destruction of gaseous and liquid wastes[J]. Annals of the New York Academy of Sciences, 2006,891(1):106-123.
[34]	Tang L, Huang H. Biomass gasification usingcapacitively coupled RF plasma technology[J]. Fuel, 2005,84(16):2055-2063.
[35]	Sang J Y, Lee J G. Syngas production from coal through microwave plasma:influence of oxygen, steam, and coal particle size[J]. Energy & Fuels, 2011,26(1):524-529.
[36]	Lin Y C, Wu T Y, Liu W Y, et al. Production of hydrogen from rice straw usingmicrowave-induced pyrolysis[J]. Fuel, 2014, 119(3):21-26.
[37]	Huang H, Tang L. Treatment of organic waste using thermal plasma pyrolysistechnology[J]. Energy Conversion and Management, 2007,48(4):1331-1337.
[38]	Tang L, Huang H. Thermal plasma pyrolysis of used tires for carbon black recovery[J]. Journal of Materials Science, 2005, 40(14):3817-3819.
[39]	Khacef A, Luche J, Aubry O, et al. Bio-oil treatment by non thermal plasma[C]//Meeting on Combustion of the Italian Section of the Combustion Institute. 2008.
[40]	Nishikawa H, Ibe M, Tanaka M, et al. A treatment of carbonaceous wastes using thermal plasma with steam[J]. Vacuum, 2004,73(s3/4):589-593.
[41]	Ivan B G, Boris I M. Some general conclusions from the results of studies on solid fuel steam plasma gasification[J]. Fuel, 1992, 71(8):895-901.
[42]	Oost G V, Hrabovsky M, Kopecky V, et al. Pyrolysis of waste using a hybrid argon-water stabilized torch[J]. Vacuum, 2006, 80(s11/12):1132-1137.
[43]	Guddeti R R, Knight R, Grossmann E D. Depolymerization of polypropylene in an induction-coupled plasma (ICP) reactor[J]. Industrial & Engineering Chemistry Research, 2000,39(5):1171-1176.
[44]	Tang L, Huang H, Zhao Z L, et al. Pyrolysis of polypropylene in a nitrogen plasma reactor[J]. Industrial & Engineering Chemistry Research, 2003,42(6):1145-1150.
[45]	Tu W K, Shie J L, Chang C Y, et al. Pyrolysis of rice straw using radio-frequency plasma[J]. Energy & Fuels, 2007,22(1):24-30.
[46]	Liu B, Kikuchi M, Li H, et al. Dual torch plasma arc furnace for medical waste treatment[J]. Journal of Dental Research, 2007, 86(6):709-712.
[47]	Jimenez M, Rincon R, Marinas A, et al. Hydrogen production from ethanol decomposition by amicrowave plasma:influence of the plasma gas flow[J]. International Journal of Hydrogen Energy, 2013,38(21):8708-8719.
[48]	McKendry P. Energy production from biomass (part1):overview of biomass[J]. BioresourceTechnology, 2002,83(1):37-46.
[49]	赵增立,李海滨,吴创之,等.生物质等离子体气化研究[J]. 太阳能学报, 2005,26(4):468-472.
[50]	Arabi K, Aubry O, Khacef A, et al. From wood to syngas by non thermal arc[J]. Power, 1970.
[51]	吴昂山,聂勇,孙艳朋,等.纤维素在等离子体射流水平床内热解气化特性[J]. 化学工程, 2010,12:80-84.
[52]	Prieto G, Okumoto M, Shimano K, et al. Reforming of heavy oil using nonthermal plasma[J]. IEEE Transactions on Industry Applications, 2001,37(5):1464-1467.
[53]	Diaz G, Quiros E L, Smith R A, et al. Syngas generation from organic waste with plasma steam reforming[C]. Journal of Physics:Conference Series, 2014,511(1):222-226.
[54]	Byun Y, Cho M, Chun J W, et al. Hydrogen recovery from the thermal plasma gasification of solid waste[J]. Journal of Hazardous Materials, 2011,190(1-3):317-323.
[55]	Huang J J, Guo W K, Xu P. Thermodynamic study of water-steam plasma pyrolysis of medical waste for recovery of CO and H2[J]. Plasma Science& Technology, 2006,7(6):3148-3150.
[56]	Chernets O V, Korzhyk V M, Marynsky G S, et al. Electric arc steam plasma conversion of medicine waste and carbon containing materials[C]. International Conference on Gas Discharges, 2008:465-468.
[57]	Huang H, Tang L. Pyrolysis treatment of waste tire powder in a capacitively coupled RF plasma reactor[J]. Energy Conversion and Management, 2009,50(3):611-617.
[58]	Mohsenian S, Esmaili M S, Shokri B, et al. Physical characteristics of twin DC thermal plasma torch applied to polymer waste treatment[J]. Journal of Electrostatics, 2015,76:231-237.
[59]	Janetta B. Plasma chemical gasification of sewage sludge[J]. Waste Management &Research, 2003,21(21):38-41.
[60]	Rafiq M H, Hustad J E.Biosyngas production by autothermal reforming of wastecookingoil with propane using a plasma-assisted gliding arc reactor[J]. International Journal of Hydrogen Energy, 2011,36(14):8221-8233.