|
|
Effects of EGR components on particle of coal liquefied diesel |
WANG Zhong1, YANG Jia-hui1, LI Rui-na1, LIU Shuai1, ZHAO Huai-bei1, CHEN Pei-hong2 |
1. School of Automotive and Traffic Engineering, Jiangsu University, Zhenjiang 212013, China;
2. Nantong Shipping College, Nantong 226010, China |
|
|
Abstract The aim of this study is to evaluate the effects of exhaust gas recirculation (EGR) on particle size distribution, microscopic morphology, compositional elements, and oxidation characteristics of particles from coal liquefied fuel engine. Particles from the engine fueled with coal liquefied fuel were collected under different EGR ratio (0% EGR, 15% EGR) and exhaust gas composition (15% N2, 15% CO2 and 30% CO2). The micro structure and oxidation characteristics of the particles were analyzed by means of scanning electron microscopy (SEM), transmission electron microscopy (TEM) and thermogravimetric analyzer. The results showed that when the EGR rate is less than 15%, the particle size shows a single peak normal distribution. The peak diameters of particle size distribution were 60.4, 60.4, 69.8 and 52.3 nm in the condition of different EGR ratio of 0% and 15%,different composition of 15% N2 and 15% CO2 respectively. When 30% CO2 was introduced, the particle size showed a bimodal normal distribution with particle sizes of 14.3 nm and 52.3 nm respectively. After the introduction of EGR and N2, the particle group becomes compact and was not easily oxidized. After the introduction of CO2, the particle group became loose and easily oxidized. Without EGR, the particle structure was mainly chain-like, and introducing 15% EGR and 15% N2, the particle structure was mainly clustered.
|
Received: 03 April 2018
|
|
|
|
|
[1] |
《煤炭深加工产业示范"十三五"规划》[J]. 中国煤炭, 2017, 43(3):144.
|
[2] |
Gowdagiri S, Cesari X M, Huang M, et al. A diesel engine study of conventional and alternative diesel and jet fuels:Ignition and emissions characteristics[J]. Fuel, 2014,136(10):253-260.
|
[3] |
Nishigai H, Kondo K, Yamaguchi T, et al. MD1-1 Morphology of JIS#2and Fischer-Tropsch Diesel (FTD) Soot in Spray Flames via Transmission Electron Microscopy (TEM) (MD:Measurement and Diagnostics,General Session Papers)[J]. 2017,2012.8:464-469.
|
[4] |
赵昌普,李小毡,张军,等.EGR的热效应和稀释效应对柴油机燃烧和排放的影响[J]. 燃烧科学与技术, 2014,(1):31-37.
|
[5] |
Bermúdez V, Lujan J M, Pla B, et al. Effects of low pressure exhaust gas recirculation on regulated and unregulated gaseous emissions during NEDC in a light-duty diesel engine[J]. Energy, 2011,36(9):5655-5665.
|
[6] |
张军.进气条件对柴油机低温燃烧过程影响的数值模拟研究[D]. 天津大学, 2012.
|
[7] |
Ladommatos N. The dilution, chemical, and thermal effects of exhaust gas recirculation on diesel engine emissions. Part 2:Effects of carbon dioxide[J]. Fuel & Energy Abstracts, 1998,38(3):186-186.
|
[8] |
Müller J O, Su D S, Jentoft R E, et al. Morphology-controlled reactivity of carbonaceous materials towards oxidation[J]. Catalysis Today, 2005,102(2005):259-265.
|
[9] |
张全长,雒婧,尧命发,等.进气成分对柴油机低温燃烧影响的试验和数值模拟[J]. 内燃机学报, 2011,(6):481-488.
|
[10] |
王凤滨,高俊华,景晓军.高压共轨柴油机燃用F-T柴油的性能与排放特性试验研究[J]. 汽车工程, 2014,36(4):421-425.
|
[11] |
Nishigai H, Kondo K, Yamaguchi T, et al. MD1-1 Morphology of JIS#2and Fischer-Tropsch Diesel (FTD) Soot in Spray Flames via Transmission Electron Microscopy (TEM) (MD:Measurement and Diagnostics, General Session Papers)[J]. 2017,2012.8:464-469.
|
[12] |
杨芳玲,王忠,赵洋,等.柴油燃烧颗粒碰撞凝并过程[J]. 内燃机学报, 2015,(6):496-501.
|
[13] |
楼狄明,耿小雨,谭丕强,等.公交车燃用不同比例生物柴油的颗粒物组分特性研究[J]. 中国环境科学, 2017,37(9):3285-3291.
|
[14] |
王刚,郎建垒,程水源,等.重型柴油车PM2.5和碳氢化合物的排放特征[J]. 中国环境科学, 2015,35(12):3581-3587.
|
[15] |
田晶,蔡忆昔,濮晓宇,等.掺混聚甲氧基二甲醚对柴油机排放的影响[J]. 中国环境科学, 2018,38(1):73-82.
|
[16] |
胡志远,章昊晨,谭丕强,等.国V公交车燃用生物柴油的颗粒物碳质组分排放特性[J]. 中国环境科学, 2018,38(8):2921-2926.
|
[17] |
李莉,王建昕,肖建华,等.车用柴油机燃用棕榈生物柴油的颗粒物排放特性研究[J]. 中国环境科学, 2014,34(10):2458-2465.
|
[18] |
谭丕强,张晓锋,胡志远,等.DOC+CDPF对生物柴油燃烧颗粒排放特性的影响[J]. 中国环境科学, 2015,35(10):2978-2984.
|
[19] |
楼狄明,万鹏,谭丕强,等.DOC+CDPF配方对柴油公交车颗粒物排放特性影响[J]. 中国环境科学, 2016,36(11):3280-3286.
|
[20] |
刘志华,葛蕴珊,丁焰,等.柴油机和LNG发动机排放颗粒物粒径分布特性研究[J]. 内燃机学报, 2009,27(6):518-522.
|
[21] |
杨帅,李秀元,应启戛,等. EGR率对柴油机排放特性影响的试验[J]. 农业机械学报, 2006,37(5):29-33.
|
[22] |
楼狄明,任洪娟,谭丕强,等.发动机燃用乳化柴油的颗粒粒径分布特性[J]. 同济大学学报(自然科学版), 2012,40(7):1083-1088.
|
[23] |
Ladommatos N. The dilution, chemical, and thermal effects of exhaust gas recirculation on diesel engine emissions. Part 2:Effects of carbon dioxide[J]. Fuel & Energy Abstracts, 1998,38(3):186-186.
|
[24] |
张全长,尧命发,郑尊清,等.废气再循环对柴油机氮氧化物和颗粒排放影响的试验研究[J]. 内燃机学报, 2012,(4):310-315.
|
[25] |
尹必峰,徐振伟,刘胜吉,等.EGR对高压共轨柴油机小负荷工况燃烧过程及排放性能的影响[J]. 车用发动机, 2010,(4):74-78.
|
[26] |
Akihama K, Takatori Y, Inagaki K, et al. Mechanism of the Smokeless Rich Diesel Combustion by Reducing Temperature[C]//2001.
|
[27] |
张韦,吴伟,陈贵升,等.EGR中主要组分对正庚烷燃烧与排放影响的化学动力学研究[J]. 内燃机学报, 2015,(2):154-162.
|
[28] |
张永俊,王嘉骏,顾雪萍,等.黏性颗粒流态化的气固流动模型研究进展[J]. 过程工程学报, 2014,14(3):535-540.
|
[29] |
苏吉,朱庆山.声场流化床中超细颗粒聚团受力与尺寸[J]. 过程工程学报, 2010,10(3):431-437.
|
[30] |
杨书申,邵龙义. MATLAB环境下图像分形维数的计算[J]. 中国矿业大学学报, 2006,35(4):478-482.
|
[31] |
Neeft J P A, Nijhuis T X, Smakman E, et al. Kinetics of the oxidation of diesel soot[J]. Fuel, 1997,76(76):1129-1136.
|
[32] |
杜家益,周仁双,张登攀,等.DOC对燃用调合生物柴油发动机PM排放的影响[J]. 中国环境科学, 2017,37(2):497-502.
|
[33] |
汪家全,孙平,梅德清,等.乙醇柴油发动机的颗粒排放及其热解动力学分析[J]. 农业工程学报, 2011,27(s2):110-113.
|
[34] |
瞿磊,王忠,李铭迪,等.正丁醇/柴油燃烧颗粒的碳官能团及氧化活性研究[J]. 中国电机工程学报, 2016,36(16):4484-4489.
|
[35] |
陈林,王忠,瞿磊,等.正丁醇/柴油混合燃料EGR氛围下排气颗粒热重分析[J]. 江苏大学学报(自然科学版), 2017,38(3):254-259.
|
|
|
|