混合外源菌强化剩余污泥微氧水解产酸

Abstract
Figure/Table
References (33)
Related Citation (11)

Download: PDF (827 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract

This study focused on the optimal concentration of yeast mixed with acetic bacteria to promote sludge hydrolysis and acidification. The concentrations of orthophosphate, ammonia nitrogen and soluble COD released from sludge were investigated. The changes of protein and polysaccharide in extracellular polymeric substances (EPS) at different layers were also studied. At yeast and acetic acid bacteria dosage of 10 and 20g/L, the highest short chain fatty acids (SCFAs) production of 719mgCOD/gVSS was achieved on the fifth day of fermentation, in which the acetic acid was 328.78mgCOD/gVSS, accounting for 45.72% of the total SCFAs. Adding exogenous bacteria significantly promoted the hydrolysis of excess sludge to produce SCFAs with acetic acid as the main component. The addition of exogenous bacteria promoted the release of ammonia nitrogen and orthophosphate during hydrolysis acidification. The maximum release of ammonia nitrogen and orthophosphate was 80.66mg/gVSS and 22.38mg/gVSS under the optimal conditions, respectively, which was conducive to the recovery of nitrogen and phosphorus from excess sludge. The release of proteins and polysaccharides from the inner layer to the outer layer of EPS was improved, providing substrates for acid production. Exogenous addition of yeast and acetic acid bacteria was an effective means to promote hydrolysis and acidification of excess sludge.

Key words： excess activated sludge micro-aerobic hydrolysis yeast acetic acid bacteria SCFAs

Received: 13 May 2019

PACS:

X703

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	WANG Chun-yan
	ZENG Wei
	XU Huan-huan
	LI Ning
	PENG Yong-zhen

Cite this article:

WANG Chun-yan,ZENG Wei,XU Huan-huan等. Effect of mixed yeast of acetic bacteria on acid production from micro-aerobic hydrolysis of excess sludge[J]. CHINA ENVIRONMENTAL SCIENCECE, 2020, 40(1): 252-260.

URL:

http://www.zghjkx.com.cn/EN/ OR http://www.zghjkx.com.cn/EN/Y2020/V40/I1/252

[1]	戴晓虎.城镇污水处理厂污泥稳定化处理的必要性和迫切性的思考[J]. 给水排水, 2017,53(12):1-5. Dai X. Necessity and urgency of sludge stabilization treatment in urban sewage treatment plant[J]. Water ﹠Wastewater Engineering, 2017,53(12):1-5.
[2]	Liu J, Yuan Y, Li B, et al. Enhanced nitrogen and phosphorus removal from municipal wastewater in an anaerobic-aerobic-anoxic sequencing batch reactor with sludge fermentation products as carbon source[M]. Bioresource Technology, 2017,244(1):1158-1165.
[3]	Yan Y, Feng L, Zhang C, et al. Ultrasonic enhancement of waste activated sludge hydrolysis and volatile fatty acids accumulation at pH 10.0[J]. Water Research, 2010,44(11):3329-3336.
[4]	Zubrowska-Sudol M, Podedworna J, Sytek-Szmeichel K, et al. The effects of mechanical sludge disintegration to enhance full-scale anaerobic digestion of municipal sludge[J]. Thermal Science and Engineering Progress, 2018,5:289-295.
[5]	Yu L, Zhang W, Liu H, et al. Evaluation of volatile fatty acids production and dewaterability of waste activated sludge with different thermo-chemical pretreatments[J]. International Biodeterioration & Biodegradation, 2018,129:170-178.
[6]	Ma H, Chen X, Liu H, et al. Improved volatile fatty acids anaerobic production from waste activated sludge by pH regulation:Alkaline or neutral pH?[J]. Waste Management, 2016,48:397-403.
[7]	He J, Xin X, Qiu W, et al. Performance of the lysozyme for promoting the waste activated sludge biodegradability[J]. Bioresource Technology, 2014,170:108-114.
[8]	Xin X, He J, Li L, et al. Enzymes catalyzing pre-hydrolysis facilitated the anaerobic fermentation of waste activated sludge with acidogenic and microbiological perspectives[J]. Bioresource Technology, 2018, 250:69-78.
[9]	杨春雪.嗜热菌强化剩余污泥水解及短链脂肪酸积累规律研究[D]. 哈尔滨,哈尔滨工业大学, 2015. Yang C, Enhenced effects of thermophlies on waste activated sludge hydrolysis and short-chain fatty acids production[D]. Harbin, Harbin Institute of Technology, 2015.
[10]	Romano R T, Zhang R, Teter S, et al. The effect of enzyme addition on anaerobic digestion of Jose Tall Wheat Grass[J]. Bioresource Technology, 2009,100(20):4564-4571.
[11]	Rai A K, Pandey A, Sahoo D, Biotechnological potential of yeasts in functional food industry[J]. Trends in Food Science & Technology, 2019,83:129-137.
[12]	覃莉,王志,陈雄,等.酵母菌醋酸菌混菌发酵高产醋酸工艺研究[J]. 中国酿造, 2012,(1):144-147. Tan L, Wang Z, Chen X, et al. High-yield production of acetic acid by mixed fermentation with yeast and acetic acid bacteria[J]. China Brewing, 2012,(1):144-147.
[13]	Montalvo S, Huilinir, et al. Microaerobic pretreatment of sewage sludge:Effect of air flow rate, pretreatment time and temperature on the aerobic process and methane generation[J]. International Biodeterioration & Biodegradation, 2016,110:1-7.
[14]	李宗翰,李小伟,戴晓虎,等.温度对微好氧消化处理高含固厌氧消化污泥的影响[J]. 环境工程, 2017,35(1):113-118. Li Z, Li X, Dai X, et al. Temperature's effect on treatment of high-solid anaerobically digested sludge using micro-aerobic digestion[J]. Environmental Engineering, 2017,35(1):113-118.
[15]	张苗,宋秀兰,黄庆涛.以污泥微氧水解发酵液为碳源处理低C/N城市污水[J]. 工业水处理, 2018,15(11):61-65. Zhang M, Song X, Huang Q, et al. Research on the sludge micro-oxygen hydrolysis fermentation liquid as the carbon source for the treatment of urban sewage with low C/N ratio[J]. Industrial Water Treatment, 2018,15(11):61-65.
[16]	Chen Y, Jiang S, Yuan H, et al. Hydrolysis and acidification of waste activated sludge at different pHs[J]. Water Research, 2007,41(3):683-689.
[17]	孙万儒.酵母菌[J]. 生物学通报, 2007,42(11):5-10. Sun W R. Yeast[J]. Bulletin of biology, 2007,42(11):5-10.
[18]	Mamlouk D, Gullo M, Acetic acid bacteria:Physiology and carbon sources oxidation[J]. Indian Journal of Microbiology, 2013,53(4):377-384.
[19]	Fang H H P, Yu H, Mesophilic acidification of gelatinaceous wastewater[J]. Journal of Biotechnology, 2002,93(2):99-108.
[20]	Zhao J, Gui L, Wang Q, et al. Aged refuse enhances anaerobic digestion of waste activated sludge[J]. Water Research, 2017,123:724-733.
[21]	Wu Q, Guo W, Zheng H, et al. Enhancement of volatile fatty acid production by co-fermentation of food waste and excess sludge without pH control:The mechanism and microbial community analyses[J]. Bioresource Technology, 2016,216:653-660.
[22]	张月阳.酵子中醋酸菌的特性及其对馒头面团发酵的影响[D]. 郑州:河南工业大学, 2018. Zhang Y, Charateristics of acetic acid bacteria in the Jiaozi and influence on sourdough fermentation for Chinese steamed bread-making[D]. Zheng Zhou, Henan University of Technology, 2018.
[23]	任南琪,赵丹,陈晓蕾,等.厌氧生物处理丙酸产生和积累的原因及控制对策[J]. 中国科学(B辑化学), 2002,(1):83-89. Ren N, Zhao D, Chen X, et al. Causes and control measures of propionic acid production and accumulation in anaerobic biological treatment[J]. Sciencein China (Series B), 2002,(1):83-89.
[24]	桂肖山,徐闯,王泽茜,等.CaO2投加量及投加方式对剩余污泥厌氧发酵产生短链脂肪酸的影响[J]. 中国环境科学, 2018,38(5):1785-1791. Gui X, Xu C, Wang Z, et al. Effects of the dosage and dosing methods of CaO2 on the production of short-chain fatty acids produced during anaerobic fermentation of waste activated sludge[J]. China Environmental Science, 2018,38(5):1785-1791.
[25]	毋海燕.碱性条件下温度对初沉污泥水解及产酸的影响[J]. 净水技术, 2018,37(6):29-35. Wu H, Influence of temperature on hydrolysis and acidification of primary sludge under alkaline condition[J]. Water Purification Technology, 2018,37(6):29-35.
[26]	Li Y, Wang J, Zhang A, et al. Enhancing the quantity and quality of short-chain fatty acids production from waste activated sludge using CaO2 as an additive[J]. Water Research, 2015,83:84-93.
[27]	解竞,段旭,冯雷雨,等.温度对超声波与碱促进污泥厌氧产酸的影响[J]. 环境科学与技术, 2018,41(4):139-145. Xie J, Duan X, Feng L, et al. Effects of temperature on ultrasonic-alkaline augmentation of volatile fatty acids production in anaerobic fermentation of wastewater Sludge[J]. Environmental Science & Technology, 2018,41(4):139-145.
[28]	殷方亮,王忠明,夏晶,等.高铁酸钾预处理对城市剩余污泥厌氧发酵的影响[J]. 中国给水排水, 2017,33(19):110-114. Yin F, Wang Z, Xia J, et al. Influence of potassium ferrate pretreatment on anaerobic fermentation of urban sewage sludge[J]. China Water & Wastewater, 2017,33(19):110-114.
[29]	Liu Y, Zhao J, Li X, et al. Synergistic effect of free nitrite acid integrated with biosurfactant alkyl polyglucose on sludge anaerobic fermentation[J]. Waste Management, 2018,78:310-317.
[30]	Li X, Peng Y, Ren N, et al. Effect of temperature on short chain fatty acids (SCFAs) accumulation and microbiological transformation in sludge alkaline fermentation with Ca(OH)2 adjustment[J]. Water Research, 2014,61:34-45.
[31]	Xie J, Duan X, Feng L, et al. Influence of sulfadiazine on anaerobic fermentation of waste activated sludge for volatile fatty acids production:Focusing on microbial responses[J]. Chemosphere, 2019, 219:305-312.
[32]	He Z, Liu W, Wang L, et al. Role of extracellular polymeric substances in enhancement of phosphorus release from waste activated sludge by rhamnolipid addition[J]. Bioresource Technology, 2016,202:59-66.
[33]	张松,刘敏,陈滢.酸化冲击对低pH厌氧发酵系统性能的影响[J]. 环境工程学报, 2017,11(5):2646-2653. Zhang S, Liu M, Chen Y, et al. Effect of acidification shock on performance of anaerobic fermentation system at low pH[J]. Chinese Journal of Environmental Engineering, 2017,11(5):2646-2653.