3DBER系统功能强化与协同作用机制研究

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (1513 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract The effluent from the secondary biological treatment of sewage plant usually has a low C/N ratio and low biodegradability, additional carbon sources should be added in its deep denitrification process. To address this problem and meet the sewage recycling technology demand for the deep removal of total nitrogen (TN), total phosphorus (TP), and micro-pollutants in the secondary treatment effluent, a multifunctional composite denitrification system based on three-dimensional biofilm electrode reactor process (3DBER) was developed in this study by changing the composition of filler materials in the traditional 3DBER. This new system could achieve enhanced denitrification and simultaneous removal of phosphorus and micro-pollutants (dibutyl phthalate (DBP) and o-benzene Dicarboxylic acid (2-ethylhexyl) ester (DEHP), which were represented by PAEs). The technical approaches of the multifunctional 3DBER process and the corresponding micro-action mechanisms for pollutant removal were examined from the perspectives of process performance and microbial population distribution. The results showed that the sulfur/iron composite functional filler was a key factor for achieving deep denitrification and simultaneous removal of phosphorus and micro pollutants for the secondary biological treatment effluent with a low C/N ratio. The denitrification efficiency of the multifunctional composite system increased by about 20% compared with the traditional 3DBER process, the simultaneous TP removal rate reached 80% and the PAEs removal rate were above 90%. The analysis from chemometrics and molecular biology technologies showed that there was a synergistic promotion effect among microbial ecology, electron donor compensation, and pH balance in the process of denitrification and phosphorus removal. The function of nitrogen removal was due to the joint action of heterotrophic and various autotrophic denitrification, and the key to phosphorus removal was the continuous corrosion of sponge iron. The removal of PAEs was the result of the synergistic effect of adsorption, electrochemical oxidation, and biodegradation. The results can provide theoretical and technical guidance for developing advanced treatment processes for the simultaneous denitrification, phosphorus removal, and micro pollutant removal from secondary biological treatment effluent.

Key words： three-dimensional biofilm electrode reactor heterotrophic denitrification autotrophic denitrification nitrogen and phosphorus removal micro pollutants

Received: 29 September 2020

PACS:

X703

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	WU Xu-yuan
	LI Jia-wen
	HAO Rui-xia
	ZHENG Xiao-ying

Cite this article:

WU Xu-yuan,LI Jia-wen,HAO Rui-xia等. Performance enhancement and synergy mechanism in a 3DBER multifunctional system[J]. CHINA ENVIRONMENTAL SCIENCECE, 2021, 41(6): 2610-2621.

URL:

http://www.zghjkx.com.cn/EN/ OR http://www.zghjkx.com.cn/EN/Y2021/V41/I6/2610

[1]	甄建园,于德爽,王晓霞,等.低C/N(
[2]	杨伟强,王冬波,李小明,等.低碳源条件下改良双污泥系统脱氮除磷优化研究[J]. 环境科学, 2016,37(4):1492-1498. Yang W Q, Wang D B, Li X M, et al. Optimization study on the nitrogen and phosphorus removal of modified two-sludge system under the condition of low carbon source[J]. Environmental Science, 2016,37(4):1492-1498.
[3]	Kampas P, Parsons S A, Pearce P, et al. An internal carbon source for improving biological nutrient removal[J]. Bioresource Technology, 2009,100(1):149-154.
[4]	李俊成.三维电极生物膜反应器深度处理含氮污水的实验研究[D]. 青岛:青岛理工大学, 2018. Li J C. Experimental study on advanced treatment of nitrogen containing wastewater by three dimensional biofilm electrode reactor[D]. Qingdao:Qingdao University of Technology, 2018.
[5]	Zhao Y, Feng C, Wang Q, et al. Nitrate removal from groundwater by cooperating heterotrophic with autotrophic denitrification in a biofilm-electrode reactor[J]. Journal of Hazardous Materials, 2011, 192(3):1033-1039.
[6]	Ghafari S, Hasan M, Aroua M K. Bio-electrochemical removal of nitrate from water and wastewater-A review[J]. Bioresource Technology, 2008,99(10):3965-3974.
[7]	Zhou M, Fu W, Gu H, et al. Nitrate removal from groundwater by a novel three-dimensional electrode biofilm reactor[J]. Electrochimica Acta, 2007,52(19):6052-6059.
[8]	Ghafari S, Hasan M, Aroua M K. Nitrate remediation in a novel upflow bio-electrochemical reactor (UBER) using palm shell activated carbon as cathode material[J]. Electrochimica Acta, 2009,54(17):4164-4171.
[9]	王建超,郝瑞霞,周彦卿.电流对MEC-3DBER-S脱氮除磷效果的影响及机理分析[J]. 中国环境科学, 2016,36(8):2388-2394. Wang J C, Hao R X, Zhou Y Q. Influence of electric current for enhancing nitrogen and phosphorus removal efficiency and mechanism analysis on micro electrocoagulation combined 3-dimensional-biofilm-electrode with sulfur autotrophic denitrification technology[J]. China Environmental Science, 2016,36(8):2388-2394.
[10]	李素梅,郝瑞霞,孟成成.三维电极生物膜反应器低温启动试验研究[J]. 中国给水排水, 2013,29(5):101-105. Li S M, Hao R X, Meng C C. Start-up of three-dimensional electrode biofilm reactor at low temperature[J]. China Water & Wastewater, 2013,29(5):101-105.
[11]	Han F, Zhang M, Shang H, et al. Microbial community succession, species interactions and metabolic pathways of sulfur-based autotrophic denitrification system in organic-limited nitrate wastewater[J]. Bioresource Technology, 2020,315:123826.
[12]	Wan D, Liu H, Qu J, et al. Using the combined bioelectrochemical and sulfur autotrophic denitrification system for groundwater denitrification[J]. Bioresource Technology, 2009,100(1):142-148.
[13]	万琼,雷茹,王信,等.海绵铁填料对城市内河污染物质去除[J]. 环境化学, 2019,38(9):2128-2140. Wan Q, Lei R, Wang X, et al. Effect of sponge-iron filler on removal of pollutants in urban rivers[J]. Environmental Chemistry, 2019, 38(9):2128-2140.
[14]	邓冬莉,吴明珠,李应,等.用于邻苯二甲酸酯类物质电催化氧化的阳极材料研究进展[J]. 化工新型材料, 2020. Deng D L, Wu M Z, Li Y, et al. Advances in research on anode materials for electrocatalytic oxidation of phthalate esters[J]. New Chemical Materials, 2020.
[15]	Wu D, Zheng P, Mahmood Q, et al. Isolation and characteristics of Arthrobacter sp strain CW-1for biodegradation of PAEs[J]. Journal of Zhejiang University-Science A, 2007,8(9):1469-1474.
[16]	陈济安,舒为群,张学奎,等.邻苯二甲酸二(2-乙基己基)酯酶促降解研究[J]. 应用与环境生物学报, 2004,10(4):471-474. Chen J A, Shu W Q, Zhang X K, et al. Biodegradation of Di(2-ethylhexyl) phthlate (DEHP) by enzyme[J]. Chinese Journal of Applied and Environmental Biology, 2004,10(4):471-474.
[17]	徐鹏程,郝瑞霞,张娅,等.3BER-S工艺用于再生水深度脱氮同步去除PAEs的可行性[J]. 环境科学, 2016,37(2):662-667. Xu P C, Hao R X, Zhang Y, et al. Feasibility of 3BER-S process for the deep denitrification in synch with the removal of PAEs from reclaimed water[J]. Environmental Science, 2016,37(2):662-667.
[18]	张杰,历彦松,张富国.给水排水工程实用设计手册-排水工程[M]. 北京:中国建筑工业出版社, 2013:289. Zhang J, Li Y S, Zhang F G. Handbook for practical design of water supply and sewerage works-Drainage works[M]. Beijing:ChinaBuilding Industry Press, 2013:289.
[19]	任晓克,郝瑞霞,孟成成,等.新型三维电极生物膜反应器启动特性[J]. 环境工程学报, 2015,9(6):2717-2722. Ren X K, Hao R X, Meng C C, et al. Start-up performance of a new type three-dimensional electrode biofilm reactor[J]. Chinese Journal of Environmental Engineering, 2015,9(6):2717-2722.
[20]	Hao R X, Li S M, Li J B, et al. Water quality assessment for wastewater reclamation using principal component analysis[J]. Journal of Environmental Informatics, 2013,21(1):45-54.
[21]	牟晋铭.上海某污水处理厂提标改造工程案例[J]. 净水技术, 2020,39(3):48-52. Mu J M. Upgrading and reconstruction project of a wastewater treatment plant in shanghai[J]. Water Purification Technology, 2020, 39(3):48-52.
[22]	Hao R X, Meng C C, Li J B. An integrated process of three-dimensional biofilm-electrode with sulfur autotrophic denitrification (3DBER-SAD) for wastewater reclamation[J]. Applied Microbiology and Biotechnology, 2016,100(16):7339-7348.
[23]	Hao R X, Zhou Y Q, Li J B, et al. A 3DBER-S-EC process for simultaneous nitrogen and phosphorus removal from wastewater with low organic carbon content[J]. Journal of Environmental Management, 2018,209:57-64.
[24]	徐忠强,郝瑞霞,徐鹏程,等.硫铁填料和微电流强化再生水脱氮除磷的研究[J]. 中国环境科学, 2016,36(2):406-413. Xu Z Q, Hao R X, Xu P C, et al. Research on enhanced denitrification and phosphorus removal from reclaimed water by using sponge iron/sulfur composite fillers and low electrical current[J]. China Environmental Science, 2016,36(2):406-413.
[25]	Qambrani N A, Oh S. Influence of reactive media composition and chemical oxygen demand as methanol on autotrophic sulfur denitrification.[J]. Journal of Microbiology and Biotechnology, 2012, 22(8):1155-1160.
[26]	Batchelor B, Lawrence A W. Autotrophic denitrification using elemental sulfur[J]. Journal Water Pollution Control Federation, 1978, 50(8):1986-2001.
[27]	Liu B B, Mao Y J, Bergaust L, et al. Strains in the genus Thauera exhibit remarkably different denitrification regulatory phenotypes[J]. Environmental Microbiology, 2013,15(10):2816-2828.
[28]	Vasiliadou I A, Siozios S, Papadas I T, et al. Kinetics of pure cultures of hydrogen-oxidizing denitrifying bacteria and modeling of the interactions among them in mixed cultures[J]. Biotechnology and Bioengineering, 2006,95(3):513-525.
[29]	Watanabe T, Kojima H, Fukui M. Draft genome sequence of a psychrotolerant sulfur-oxidizing bacterium, sulfuricella denitrificans skB26, and proteomic insights into cold adaptation[J]. Applied and Environmental Microbiology, 2012,78(18):6545-6549.
[30]	Mousavi S, Ibrahim S, Aroua M K, et al. Development of nitrate elimination by autohydrogenotrophic bacteria in bio-electrochemical reactors-A review[J]. Biochemical Engineering Journal, 2012,67:251-264.
[31]	张宁博.铁基质自养生物反硝化工艺条件研究[D]. 苏州:苏州科技大学, 2017. Zhang N B. Reasearch on the conditions of iron matrix autotrophic biological denitrification process[D]. Suzhou:Suzhou University of Science and Technology, 2017.
[32]	王建超,郝瑞霞,孟成成.海绵铁/活性炭复合填料强化3DBER脱氮除磷特性[J]. 中国给水排水, 2014,30(11):19-23. Wang J C, Hao R X, Meng C C. Enhanced removal of nitrogen and phosphorus in 3DBER filled with sponge iron and activated carbon[J]. China Water & Wastewater, 2014,30(11):19-23.
[33]	Moussa D T, El-Naas M H, Nasser M, et al. A comprehensive review of electrocoagulation for water treatment:Potentials and challenges[J]. Journal of Environmental Management, 2017,186(1):24-41.
[34]	Attour A, Touati M, Thin M, et al. Influence of operating parameters on phosphate removal from water by electrocoagulation using aluminum electrodes[J]. Separation and Purification Technology, 2014, 123(26):124-129.
[35]	Chen S, Shi Y, Wang W, et al. Phosphorus removal from continuous phosphate-contaminated water by electrocoagulation using aluminum and iron plates alternately as electrodes[J]. Separation Science and Technology, 2014,49(6):939-945.
[36]	Watanabe T, Kojima H, Fukui M. Draft genome sequence of a psychrotolerant sulfur-oxidizing bacterium, Sulfuricella denitrificans skB26, and proteomic insights into cold adaptation[J]. Applied Environmental Microbiology, 2012,78(18):6545-6549.
[37]	李圭白,张杰.水质工程学(第二版)[M]. 北京:中国建筑工业出版社, 2013:421. Li G B, Zhang J. Water quality engineering (second edition)[M]. Beijing:China Building Industry Press, 2013:421.
[38]	常玉梅,杨琦,郝春博,等.城市污水厂活性污泥强化自养反硝化菌研究[J]. 环境科学, 2011,32(4):1210-1216. Chang Y M, Yang Q, Hao C B, et al. Experimental study of autotrophic denitrification bacteria through bioaugmentation of activated sludge from municipal wastewater plant[J]. Environmental Science, 2011,32(4):1210-1216.
[39]	姜澜慧.垃圾填埋场渗滤液处理系统中邻苯二甲酸酯的归趋[D]. 杭州:浙江浙江科技学院, 2019. Jiang L H. The fate of phthalates in landfill leachate treatment systems[D]. Hangzhou:Zhejiang University of Science and Technology, 2019.
[40]	Huang J Y, Philip N,Li Y, et al. Chemical behavior of phthalates under abiotic conditions in landfills[J]. Reviews of Environmental Contamination and Toxicology, 2013,224:39-52.
[41]	曹龙.臭氧-活性炭-超滤工艺去除水源水邻苯二甲酸酯的效能研究[D]. 广州:广州大学, 2019. Cao L. Study on the efficiency of ozone-activated carbon-ultrafiltration process for removal of phthalate from source water[D]. Guangzhou:Guangzhou University, 2019.
[42]	张朝升,刘宏英,陈秋丽,等.生物活性炭滤池对水源水中邻苯二甲酸酯的降解性能[J]. 环境工程学报, 2017,11(4):2247-2254. Zhang C S, Liu H Y, Chen Q L, et al. Degradation characteristics of phthalate acid esters in water by biological activated carbon filter[J]. Chinese Journal of Environmental Engineering, 2017,11(4):2247-2254.
[43]	周翔,张玉,孙超越,等.脱氮硫杆菌利用FeS自养反硝化过程研究[J]. 大连理工大学学报, 2019,59(5):455-461. Zhou X, Zhang Y, Sun C Y, et al. Study of autotrophic denitrification process conducted by thiobacillus denitrificans utilizing FeS[J]. Journal of Dalian University of Technology, 2019,59(5):455-461.
[44]	Swiatczak P, Cydzik-Kwiatkowska A, Zielinska M. Treatment of liquid phase of digestate from agricultural biogas plant in a system with aerobic granules and ultrafiltration[J]. Water, 2019,11(1).104.
[45]	Burns A S, Padilla C C, Pratte Z A, et al. Broad phylogenetic diversity associated with nitrogen loss through sulfur oxidation in a large public marine aquarium[J]. Applied and Environmental Microbiology, 2018, 84(20):e01250-18.
[46]	Wang S, Liang P, Wu Z, et al. Mixed sulfur-iron particles packed reactor for simultaneous advanced removal of nitrogen and phosphorus from secondary effluent[J]. Environmental Science and Pollution Research., 2015,22(1):415-424.
[47]	余鸿婷,李敏.反硝化聚磷菌的脱氮除磷机制及其在废水处理中的应用[J]. 微生物学报, 2015,55(3):264-272. Yu H T, Li M. Denitrifying and phosphorus removal mechanisms of denitrifying phosphorus accumulating organisms (DPAOs) for wastewater treatment -A review[J]. Acta Microbiologica Sinica, 2015,55(3):264-272.
[48]	王亚超,南亚萍,袁林江,等.生物除磷系统启动及运行期的微生物种群结构变化[J]. 中国给水排水, 2018,34(13):104-109. Wang Y C, Nan Y P, Yuan L J, et al. Change of microbial communities structure in enhanced biological phosphorus removal process during start-up and operation period[J]. China Water & Wastewater, 2018, 34(13):104-109.
[49]	Enchao L, Xuewen J, Shuguang L. Microbial communities in biological denitrification system using methanol as carbon source for treatment of reverse osmosis concentrate from coking wastewater[J]. Journal of Water Reuse and Desalination, 2018,8(3):360-371.