鼓泡和鼓泡-搅拌SBR好氧污泥颗粒化能耗分析

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (2396 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract The mean diameter, fractal dimension and microorganism characteristics during aerobic sludge granulation were investigated under bubble SBR with height-diameter ratio of 20 and bubble-stirring SBR with height-diameter ratio of 1.2. A computational fluid dynamics model was established to compare and analyze the energy consumption of conventional activated sludge and aerobic granular sludge in different reactors. The reasons for the differences in the characteristics of the two reactors were analyzed. The aerobic granular sludge with a mean diameter of 0.604mm. an average sedimentation rate of (24±5.8)m/h, a SVI of 36.33mL/g, a MLSS of about 4500mg/L and a smooth surface was formed under the condition of superficial gas velocity of 2.0cm/s in the bubble SBR. Under the conditions of stirring speed of 300r/min and superficial gas velocity of 1.05cm/s, the aerobic granular sludge were successfully formed with filamentous bacteria entangling on the surface of granules in the bubble-stirring SBR. The mean sludge diameter was up to 1.123mm, the average sedimentation rate of sludge was (19.6±5.1)m/h, SVI was 41.33mL/g, and MLSS was about 3300mg/L. The comparative analysis of energy consumption conventional between activated sludge and aerobic granular sludge showed that the turbulent kinetic energy of the bubble-stirring SBR was about 100times that of the bubble SBR at the activated sludge stage due to the addition of agitation. However, after the formation of aerobic granules, the turbulent kinetic energy in the upper part of the bubble SBR increased significantly, and the magnitude of the turbulent kinetic energy was larger than that of the bubble-stirring SBR. In comparison, the bubble SBR was relatively energy efficient.

Key words： aerobic granular sludge SBR energy consumption computational fluid dynamic

Received: 05 December 2020

PACS:

X703.5

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	FAN Wen-wen
	YUAN Lin-Jiang
	MA Yuan-Zheng
	HUANG-Hao

Cite this article:

FAN Wen-wen,YUAN Lin-Jiang,MA Yuan-Zheng等. The energy consumption analysis of bubble SBR and bubble-stirring SBR for aerobic sludge granulation[J]. CHINA ENVIRONMENTAL SCIENCECE, 2021, 41(7): 3229-3237.

URL:

http://www.zghjkx.com.cn/EN/ OR http://www.zghjkx.com.cn/EN/Y2021/V41/I7/3229

[1]	Van L M C M V, Brdjanovic D. Anticipating the next century of wastewater treatment[J]. Science, 2014,344(6191):1452-1453.
[2]	Liu Z, Liu Y, Zhang A, et al. Study on the process of aerobic granule sludge rapid formation by using the poly aluminum chloride (PAC)[J]. Chemical Engineering Journal, 2014,250:319-325.
[3]	Liu Y Q, Tay J H. Fast formation of aerobic granules by combining strong hydraulic selection pressure with overstressed organic loading rate[J]. Water Research, 2015,80(sep.1):256-266.
[4]	Dahalan F A, Abdullah N, Yuzir A, et al. A proposed aerobic granules size development scheme for aerobic granulation process[J]. Bioresource Technology, 2015,181:291-296.
[5]	Liu J, Li J, Wang X D, et al. Rapid aerobic granulation in an SBR treating piggery wastewater by seeding sludge from a municipal WWTP[J]. Journal of Environmental Science, 2017,51(1):332-341.
[6]	Tay J H, Liu Q S, Liu Y. The effects of shear force on the formation, structure and metabolism of aerobic granules[J]. Applied Microbiology & Biotechnology, 2001,57(1/2):227-233.
[7]	Beun J J, Hendriks A, Loosdrecht M C M V, et al. Aerobic granulation in a sequencing batch reactor[J]. Water Research, 2002,36(3):702-12.
[8]	吴昌永,王然登,彭永臻.污水处理颗粒污泥技术原理与应用[M]. 北京:中国建筑工业出版社, 2011. Wu C Y, Wang R D, Peng Y Z. Granular sludge technology of wastewater treatment:principles and applications[M]. Beijing:China Architecture and Building Press, 2011.
[9]	Caluwé M, Dobbeleers T, D'aes J, et al. Formation of aerobic granular sludge during the treatment of petrochemical wastewater[J]. Bioresource Technology, 2017,238(1):559-567.
[10]	吴昌永,周岳溪.厌氧/好氧运行方式对颗粒污泥形成的影响[J]. 中国环境科学, 2013,33(7):1237-1243. Wu C Y, Zhou Y X. Effect of anaerobic/aerobic alternative operating strategy on the formation of granular sludge in a sequencing batch reactor[J]. China Environmental Science, 2013,33(7):1237-1243.
[11]	隗启源.好氧颗粒污泥处理低浓度生活污水同步脱氮除磷的研究[D]. 武汉:华中科技大学, 2013. Wei Q Y. Study on simultaneous nitrogen and phosphorus removal by aerobic granular sludge process in treating low strength domestic sewage[D]. Wuhan:Huazhong University of Science and Technology, 2013.
[12]	高景峰,郭建秋,陈冉妮,等.SBR反应器排水高度与直径比对污泥好氧颗粒化的影响[J]. 中国环境科学, 2008,28(6):512-516. Gao J F, Guo J Q, Chen R N. Influence of SBR drainage height and diameter ratio on aerobic sludge granulation[J]. China Environmental Science, 2008,28(6):512-516.
[13]	李浩,袁林江.好氧SBR反应器中污泥颗粒化过程的成核研究[J]. 中国给水排水, 2008,24(13):42-45. Li H, Yuan L J. Research on nucleation of granular sludge in Aerobic SBR[J]. China Water and Wastewater, 2008,24(13):42-45.
[14]	Awang N A, Shaaban M G. Effect of reactor height/diameter ratio and organic loading rate on formation of aerobic granular sludge in sewage treatment[J]. International Biodeterioration & Biodegradation, 2016,112(1):1-11.
[15]	曲新月,范文雯,袁林江,等.水平搅拌下低高径比SBR中好氧活性污泥的颗粒化[J]. 中国环境科学, 2018,38(9):3358-3366. Qu X Y, Fan W W, Yuan L J, et al. Aerobic sludge granulation under horizontal mechanical agitation in a SBR with lower ratio of height to diameter[J]. China Environmental Science, 2018,38(9):3358-3366.
[16]	李永林,范文雯,袁林江,等.气升流速变化对SBR污泥颗粒化的作用及机理[J]. 环境科学学报, 2017,37(10):3642-3648. Li Y L, Fan W W, Yuan L J, et al. Effect and mechanism of variation of superficial gas upflow velocity on sludge granulation in SBRs[J]. Acta Scientiae Circumstantiae, 2017,37(10):3642-3648.
[17]	李永林.气升流速变化对SBR污泥颗粒化的作用及机理[D]. 西安:西安建筑科技大学, 2017. Li Y L. The effect and mechanism of variation of superficial gas upflow velocity on sludge granulation in SBRs[D]. Xi'an:Xi'an University of Architecture and Technology, 2017.
[18]	Gresch M, Bruegger R, Meykr A, et al. Compartmental Models for Continuous Flow Reactors Derived from CFD Simulations[J]. Environmental Science and Technology, 2009,43(7):2381-2387.
[19]	Wang X, Ding J, Guo W Q, et al. A hydrodynamics-reaction kinetics coupled model for evaluating bioreactors derived from CFD simulation[J]. Bioresource Technology, 2010,101(24):9749-9757.
[20]	APHA. Standard methods for examination of water and wastewater[M]. 20th ed. Washington, D C, USA:American Public Health Association, 1998.
[21]	范文雯.网板式SBR反应器快速稳定培养好氧颗粒污泥试验研究[D]. 兰州:兰州理工大学, 2012. Fan W W. Experimental Study on Activated Sludge to Aerobic Granular Sludge rapidly and stably in Pore Plate of Plastic SBR[D]. Lanzhou:Lanzhou University of Technology, 2012.
[22]	张鸿雁,张志政,王元.流体力学[M]. 2版.北京:科学出版社, 2014. Zhang H Y, Zhang Z Z, Wang Y. Fluid Mechanics[M]. 2nd. Beijing:Science Press, 2014.
[23]	Fan W W, Yuan L J, Li Y L. CFD simulation of flow pattern in a bubble column reactor for forming aerobic granules and its development[J]. Environmental Technology, 2019,40(27):3652-3667.
[24]	Fan W W, Yuan L J, Qu X Y. CFD simulation of hydrodynamic behaviors and aerobic sludge granulation in a stirred tank with lower ratio of height to diameter[J]. Biochemical Engineering Journal, 2018,137:78-94.
[25]	范文雯,袁林江.气泡直径对气-液-污泥流态及污泥颗粒化的影响[J]. 中国环境科学, 2020,40(9):3859-3870. Fan W W, Yuan L J. The effect of bubble sizes on air-liquid-sludge flow pattern and aerobic sludge granulation in bubble column reactors[J]. China Environmental Science, 2020,40(9):3859-3870.
[26]	Serra T, Casamitjana X. Structure of the aggregates during the process of aggregation and breakup under a shear flow[J]. Journal of Colloid and Interface Science, 1998,206(2):505-511.
[27]	Mishima K, Nakamura M. Self-immobilization of aerobic activated sludge-a pilot study of the aerobic upflow sludge blanket process in municipal sewage treatment[J]. Water Science Technology, 1991,23:981-990.
[28]	Tay J H, Liu Q S, Liu Y. Microscopic observation of aerobic granulation in sequential aerobic sludge blanket reactor[J]. Journal of Applied Microbiology, 2001,91(1):168-175.
[29]	Gao D W, Liu L, Liang H, et al. Aerobic granular sludge:characterization, mechanism of granulation and application to wastewater treatment[J]. Critical Reviews in Biotechnology, 2011, 31(2):137-152.
[30]	Li X Y, Yuan Y. Setting velocities and permeabilities of microbial aggregates[J]. Water Research, 2002,36:3110-3120.