碳纳米管界面改性超滤膜的抗污机理解析

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (1075 KB) HTML (0 KB)
Export: BibTeX | EndNote (RIS)

Abstract Carbon nanotubes (CNTs) as the core modification material was spray-coated on polyether sulfone (PES) ultrafiltration membrane towards enhanced anti-fouling property. The permeability of the modified membrane decreased slightly and the hydrophilicity increased obviously, and the layer of woven CNT fibre also increased the membrane roughness. In the presence of bovine serum albumin (BSA) of 20mg/L, the CNT-10membrane exhibited a high flux recovery rate up to 95.7% with the reversible fouling ratio nearly 60%. Then, applying electrical impedance spectroscopy (EIS) to measure membrane fouling extents provided the membrane real- imaginary impedance, conductance and capacitance. The Nyquist curve of CNT-10exhibited less horizontal shift (real impedance increases) towards the right side, and the radius of the curve was not significantly expanded after contamination test, in consistent with the slightly decreased conductance and relatively stable capacitance. It was concluded that the modified membrane has less foulant adhesion, agreeing with the flux variation. The discussion on frequency division of frequency-conductance diagram showed that BSA contaminated the entire surface and membrane of PES-V, but did not pollute the entire surface and membrane of CNT-10. The free energy analysis of the interfacial interaction between CNT modified layer and BSA was only half that for the control, indicating small membrane-foulant attraction, which explained the excellent anti-fouling performance of the CNT modified membrane by thermodynamics.

Key words： ultrafiltration carbon nanotubes membrane fouling electrochemical impedance method (EIS) XDLVO theory

Received: 26 September 2021

PACS:

X703.1

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	WANG Die
	WANG Xiao-yang
	CHEN Xi
	HAN Min-yuan
	WANG Yu-ting
	XIANG Wen-yu
	YAO Jing-mei
	HAN Le

Cite this article:

WANG Die,WANG Xiao-yang,CHEN Xi等. Anti-fouling mechanism for ultrafiltration membrane of modified surface by carbon nanotubes[J]. CHINA ENVIRONMENTAL SCIENCECE, 2022, 42(4): 1618-1624.

URL:

http://www.zghjkx.com.cn/EN/ OR http://www.zghjkx.com.cn/EN/Y2022/V42/I4/1618

[1]	Nayak K, Kumar A, Das P, et al. Amphiphilic antifouling membranes by polydopamine mediated molecular grafting for water purification and oil/water separation[J]. Journal of Membrane Science, 2021, 630:14.
[2]	Feng H, Liu J, Mu Y F, et al. Hybrid ultrafiltration membranes based on PES and MOFs@carbon quantum dots for improving anti-fouling performance[J]. Separation and Purification Technology, 2021,266:9.
[3]	Feng H, Liu J, Mu Y, et al. Hybrid ultrafiltration membranes based on PES and MOFs@carbon quantum dots for improving anti-fouling performance[J]. Separation and Purification Technology, 2021,266.
[4]	Cheng K, Zhang N, Yang N, et al. Rapid and robust modification of PVDF ultrafiltration membranes with enhanced permselectivity, antifouling and antibacterial performance[J]. Separation and Purification Technology, 2021,262:10.
[5]	Yin J L, Tang H, Xu Z Z, et al. Enhanced mechanical strength and performance of sulfonated polysulfone/Troger's base polymer blend ultrafiltration membrane[J]. Journal of Membrane Science, 2021, 625:10.
[6]	高原.聚苯硫醚分离膜界面改性、结构调控与过滤分离性能的研究[D]. 天津工业大学, 2020. Gao Y. Study on interface modification, structure regulation and filtration separation performance of polyphenylene sulfide separation membrane[D]. Tianjin Polytechnic University, 2020.
[7]	张彤.超滤/纳滤膜的制备及抗油污染改性研究[D]. 北京:中国石油大学(北京), 2018. Zhang T. Studies on Preparation, and modification and properties of anti-foulding ultrafiltration and nanofiltration membranes[D]. Beijing:China University of Petroleum (Beijing), 2018.
[8]	Wang Y, Han M, Liu L, et al. Beneficial CNT intermediate layer for membrane fluorination toward robust superhydrophobicity and wetting resistance in membrane distillation[J]. Acs Applied Materials & Interfaces, 2020,12(18):20942-20954.
[9]	Han M Y, Dong T, Hou D Y, et al. Carbon nanotube based Janus composite membrane of oil fouling resistance for direct contact membrane distillation[J]. Journal of Membrane Science, 2020,607:11.
[10]	Lee J-G, Lee E-J, Jeong S, et al. Theoretical modeling and experimental validation of transport and separation properties of carbon nanotube electrospun membrane distillation[J]. Journal of Membrane Science, 2017,526:395-408.
[11]	Celik E, Park H, Choi H, et al. Carbon nanotube blended polyethersulfone membranes for fouling control in water treatment[J]. Water Research, 2011,45(1):274-282.
[12]	Son M, Park H, Liu L, et al. Thin-film nanocomposite membrane with CNT positioning in support layer for energy harvesting from saline water[J]. Chemical Engineering Journal, 2016,284:68-77.
[13]	Yuan X-T, Xu C-X, Geng H-Z, et al. Multifunctional PVDF/CNT/GO mixed matrix membranes for ultrafiltration and fouling detection[J]. Journal of Hazardous Materials, 2020,384.
[14]	Mao H, Qiu M, Zhang T, et al. Robust CNT-based conductive ultrafiltration membrane with tunable surface potential for in situ fouling mitigation[J]. Applied Surface Science, 2019,497.
[15]	Zhang Q, Liu Y, Su Y, et al. Fabrication and characterization of antifouling carbon nanotube/polyethersulfone ultrafiltration membranes[J]. Rsc Advances, 2016,6(42):35532-35538.
[16]	Xiang W, Han M, Dong T, et al. Fouling dynamics of anion polyacrylamide on anion exchange membrane in electrodialysis[J]. Desalination, 2021,507.
[17]	Sim L N, Wang Z J, Gu J, et al. Detection of reverse osmosis membrane fouling with silica, bovine serum albumin and their mixture using in-situ electrical impedance spectroscopy[J]. Journal of Membrane Science, 2013,443:45-53.
[18]	Jiang W, Lin L, Xu X, et al. Physicochemical and electrochemical characterization of cation-exchange membranes modified with polyethyleneimine for elucidating enhanced monovalent permselectivity of electrodialysis[J]. Journal of Membrane Science, 2019,572:545-556.
[19]	Han M, Dong T, Hou D, et al. Carbon nanotube based Janus composite membrane of oil fouling resistance for direct contact membrane distillation[J]. Journal of Membrane Science, 2020, 607.
[20]	De Lannoy C F, Jassby D, Davis D D, et al. A highly electrically conductive polymer-multiwalled carbon nanotube nanocomposite membrane[J]. Journal of Membrane Science, 2012,415:718-724.
[21]	Li D L, Sun X H, Gao C L, et al. Improved water flux and antifouling properties of cardo poly(aryl ether ketone) ultrafiltration membrane by novel sulfobetaine polyimides additive[J]. Separation and Purification Technology, 2020,251:8.
[22]	唐和礼,张冰,黄冬梅等.XDLVO理论在膜污染解析中的应用研究[J] 化工学报, 2021,72(3):1230-1241. Tang H L, Zhang B, Huang D M, et al. Application in membrane fouling analysis based on XDLVO theory[J]. Chemical Industry Journal, 2021,72(3):1230-1241.
[23]	Yu X F, Lin T, Xu H, et al. Ultrafiltration of up-flow biological activated carbon effluent:Extracellular polymer biofouling mechanism and mitigation using pre-ozonation with H2O2 backwashing[J]. Water Research, 2020,186:13.
[24]	Yuan X T, Wu L, Geng H Z, et al. Polyaniline/polysulfone ultrafiltration membranes with improved permeability and anti-fouling behavior[J]. Journal of Water Process Engineering, 2021,40:11.
[25]	袁雪爽.导电聚砜超滤膜的制备性能研究及应用[D]. 天津工业大学, 2019. Yuan X S. Preparation and application of conductive polysulfone ultrafiltration membrane[D]. Tianjin Polytechnic University, 2019.
[26]	Manorma, Ferreira I, Alves P, et al. Lignin separation from black liquor by mixed matrix polysulfone nanofiltration membrane filled with multiwalled carbon nanotubes[J]. Separation and Purification Technology, 2021,260.
[27]	Wang W, Zhu L, Shan B, et al. Preparation and characterization of SLS-CNT/PES ultrafiltration membrane with antifouling and antibacterial properties[J]. Journal of Membrane Science, 2018,548:459-469.
[28]	Peng W H, Escobar I C, White D B.Effects of water chemistries and properties of membrane on the performance and fouling-a model development study[J]. Journal of Membrane Science, 2004,238(1/2):33-46.