污泥基生物炭结构的共焦显微拉曼技术应用

Abstract
Figure/Table
References
Related Citation (7)

Download: PDF (468 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract Confocal Raman microscopy method was utilized to analyze the structure changes of sludge-based biochar prepared at different pyrolysis temperatures (500~900 ). The results showed that there was a strong correlation between the fluorescence ℃ interference of Raman signal and the physicochemical properties of biochar. The Raman drift coefficient decreased with the pyrolysis temperature increasing, which was consistent with the changing trend of the volatile content, H/C and O/C ratio of sludge-based biochar. The correlation indices of the drift coefficient with the volatile content and the H/C ratio were 0.97 and 0.94, respectively, which revealed that the change of drift coefficient could be utilized to evaluate the change of volatile content and H/C ratio of biochar. In addition, the ratio of characteristic peak of biochar (D/G ratio) in the Raman spectra enhanced with the pyrolysis temperature increasing, which could represent the increasing process of the disorder degree of sludge-based biochar. The ratio of the valley region (V) to the D peak (IV/ID ratio) decreased with the pyrolysis temperature increasing, indicating that the proportion of defective fused aromatic ring structures increased. In addition, the ratio of ID1/IG1obtained by peak fitting was unobvious, while ID2/IG2 showed an increasing trend. The trend confirmed that the defects and amorphous structures were formed by the depositing compounds on the surface of carbon from low molecule fracture of side chain group. The ratio of IG1/IG2 decreased with the pyrolysis temperature increasing, indicating that the ratio of order to disorder of bond angle decreased following the increasing pyrolysis temperature. Therefore, Raman spectroscopy could be applied to characterize the sludge-based biochar, and reflect the evolution of its microstructure.

Key words： pyrolysis temperature sludge-based biochar confocal Raman microscopy structure evolution characteristic peaks

Received: 15 December 2021

PACS:

X705

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	HUANG Ting
	ZHANG Shan
	SU Ming-xue
	LI Ning

Cite this article:

HUANG Ting,ZHANG Shan,SU Ming-xue等. Application of confocal Raman microscopy on the structure of sludge-based biochar[J]. CHINA ENVIRONMENTAL SCIENCECE, 2022, 42(7): 3378-3384.

URL:

http://www.zghjkx.com.cn/EN/ OR http://www.zghjkx.com.cn/EN/Y2022/V42/I7/3378

[1]	孙东晓,董志强,刘学明,等.污泥基生物炭的制备技术及环境应用与研究热点[J].净水技术, 2021,40(8):16-25. Sun D X, Dong Z Q, Liu X M, et al. Preparation technology, environmental application and research hotspots of sludge-based biochar[J]. Water Purification Technology, 2021,40(8):16-25.
[2]	王靖宜,王丽,张文龙,等.生物炭基复合材料制备及其对水体特征污染物的吸附性能[J].化工进展, 2019,38(8):3838-3851. Wang J Y, Wang L, Zhang w l, et al. Preparation of biochar-based composites and their adsorption performance for characteristic pollutants in water[J]. Progress in Chemical Industry, 2019,38(8):3838-3851.
[3]	李力,刘娅,陆宇超,等.生物炭的环境效应及其应用的研究进展[J].环境化学, 2011,30(8):1411-1421. Li L, Liu Y, Lu Y C, et al. Research progress on environmental effects and applications of biochar[J]. Environmental Chemistry, 2011,30(8):1411-1421.
[4]	肖欣.生物炭的多级结构特征、构效关系及其吸附作用研究[D].浙江:浙江大学, 2018. Xiao X. Multi-level structure characteristics, structure-activity relationship and adsorption of biochar[D]. Zhejiang:Zhejiang University, 2018.
[5]	王琦.低阶褐煤热解过程的原位红外及拉曼光谱研究[D].大连:大连理工大学, 2016. Wang Q. In situ infrared and Raman spectroscopy studies on the pyrolysis process of low-rank lignite[D]. Liaoning:Dalian University of Technology, 2016.
[6]	李金泽,王杰平,孙章.煤及其热解过程中微观结构的光谱学研究进展[J].燃料与化工, 2020,51(2):8-13. Li J Z, Wang J P, Sun Z. Spectroscopic research progress of coal and its microstructure during pyrolysis[J]. Fuels and Chemicals,2020,51(2):8-13.
[7]	方梦园,赵天慧,赵晓丽,等.碳纳米管对腐殖酸的吸附及其环境意义[J].环境化学, 2020,39(10):2897-2906. Fang M Y, Zhao T H, Zhao X L, et al. Adsorption of humic acid by carbon nanotubes and its environmental significance[J]. Environmental Chemistry, 2020,39(10):2897-2906.
[8]	Chen Y, Syed-Hassan S, Xiong Z, et al. Temporal and spatial evolution of biochar chemical structure during biomass pellet pyrolysis from the insights of micro-Raman spectroscopy[J]. Fuel Processing Technology, 2021,218:106839.
[9]	Choppala G K, Bolan N S, Megharaj M, et al. The influence of biochar and black carbon on reduction and bioavailability of chromate in soils[J]. Journal of Environmental Quality, 2012,41(4):1175-1184.
[10]	Mohanty P, Nanda S, Pant K K, et al. Evaluation of the physiochemical development of biochars obtained from pyrolysis of wheat straw, timothy grass and pinewood:Effects of heating rate[J]. Journal of Analytical&Applied Pyrolysis, 2013,104:485-493.
[11]	Smith M W, Dallmeyer I, Johnson T J, et al. Structural analysis of char by Raman spectroscopy:Improving band assignments through computational calculations from first principles[J]. Carbon, 2016,100:678-692.
[12]	顾博文,曹心德,赵玲,等.生物质内源矿物对热解过程及生物炭稳定性的影响[J].农业环境科学学报, 2017,36(3):591-597. Gu B W, Cao X D, Zhao L, et al. Effects of biomass endogenous minerals on pyrolysis process and biochar stability[J]. Journal of Agricultural and Environmental Sciences, 2017,36(3):591-597.
[13]	P Vítek, Ali E, Edwards H, et al. Evaluation of portable Raman spectrometer with 1064nm excitation for geological and forensic applications[J]. Spectrochimica Acta Part A Molecular&Biomolecular Spectroscopy, 2012,86:320-327.
[14]	Xiang J, Liu J, Xu J, et al. The fluorescence interference in Raman spectrum of raw coals and its application for evaluating coal property and combustion characteristics[J]. Proceedings of the Combustion Institute, 2019,37:3053-3060.
[15]	徐艳梅,潘志彦,胡浩权.利用拉曼光谱研究大柳塔煤热解焦结构及其燃烧性能[J].燃料化学学报, 2021,49(11):1656-1666. Xu Y M, Pan Z Y, Hu H Q. Using Raman spectroscopy to study the structure and combustion performance of Daliuta coal pyrolysis coke[J]. Journal of Fuel Chemistry, 2021,49(11):1656-1666.
[16]	Guizani, Haddad, Limousy, et al. New insights on the structural evolution of biomass char upon pyrolysis as revealed by the Raman spectroscopy and elemental analysis[J]. Carbon, 2017,119:519-521.
[17]	Shimodaira N, Masui A. Raman spectroscopic investigations of activated carbon materials[J]. Journal of Applied Physics, 2002, 92(2):902-909.
[18]	Alvarez J, Amutio M, Lopez G, et al. Sewage sludge valorization by flash pyrolysis in a conical spouted bed reactor[J]. Chemical Engineering Journal, 2015,273:173-183.
[19]	章鑫,徐俊,许凯,等.基于拉曼成像的煤岩组分化学结构原位研究[J].工程热物理学报, 2021,42(6):1614-1621. Zhang X, Xu J, Xu k, et al. In situ study of chemical structure of coal and rock components based on Raman imaging[J]. Journal of Engineering Thermophysics, 2021,42(6):1614-1621.
[20]	余力,刘钦甫,乔志川,等.煤系石墨微晶结构与其导电性能的关系研究[J].炭素技术, 2017,36(5):14-18. Xu L, Liu Q F, Qiao Z Z, et al. Study on the relationship between the microcrystalline structure of coal-based graphite and its electrical conductivity[J]. Carbon Technology, 2017,36(5):14-18.