BioDopp中试系统强化脱氮除磷及微生物菌群分析

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (523 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract In order to demonstrate the feasibility of simultaneously upgrading and capacity expanding of existing municipal sewage treatment plants, taking a low C/N domestic sewage in Beijing as the treatment object, a pilot test system was constructed using IFAS combined with micro oxygen A/O technology based on BioDopp process. The removal efficiency of organic matter, nitrogen and phosphorus, and the characteristics of microbial community were investigated, and the economic benefits were calculated as well. The results show that the startup strategy of increasing the load by gradually increasing the treated water volume is feasible in view of the low pollutant concentration of the sewage. After only 8days of startup, the operation became stable and the effluent COD, NH₃-N, TN and TP concentration reached 18.9, 0.4, 8.3 and 0.7mg/L respectively. The results of high-throughput sequencing showed that the tested process enhanced the enrichment of functional bacteria, especially denitrifying phosphorus accumulating bacteria, and its total relative abundance reached 7.6%, which was 23.6times of that of the activated sludge inoculated. The HRT of the pilot system is 16.6h, which is only 61.0% of the original process (HRT~27.2h) of the sewage treatment plant. It can be seen that this process has significant advantages in land saving, high biological phosphorus removal efficiency, saving reagent cost, and greatly reducing the energy consumption of aeration and reflux by micro oxygen controlling and air lift reflux. Consequently, BioDopp process can be used for the construction of compact sewage treatment plant, which is an efficient energy-saving and carbon reduction tool for sewage treatment plant.

Key words： BioDopp process denitrifying phosphorus removal low C/N municipal wastewater energy saving and carbon reduction

Received: 24 May 2022

PACS:

X703.5

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	PAN Jian-tong
	YU Cheng
	WANG Kai-jun
	LIU Fang
	YANG Ping

Cite this article:

PAN Jian-tong,YU Cheng,WANG Kai-jun等. Enhanced nitrogen and phosphorus removal and microbial analysis of BioDopp process in pilot scale[J]. CHINA ENVIRONMENTAL SCIENCECE, 2022, 42(12): 5633-5642.

URL:

http://www.zghjkx.com.cn/EN/ OR http://www.zghjkx.com.cn/EN/Y2022/V42/I12/5633

[1]	中华人民共和国住房和城乡建设部.中国城市建设统计年鉴[Z]. 北京:中国计划出版社, 2021. Ministry of Housing and Urban-Rural Construction of the People's Republic of China. China urban construction statistical yearbook[Z]. Beijing:China Planning Press, 2021.
[2]	Wang D, Tao J, Fan F, et al. A novel pilot-scale IFAS-MBR system with low aeration for municipal wastewater treatment:Linkages between nutrient removal and core functional microbiota[J]. Sci Total Environ, 2021,776:145858.
[3]	Regmi P, Thomas W, Schafran G, et al. Nitrogen removal assessment through nitrification rates and media biofilm accumulation in an IFAS process demonstration study[J]. Water Research, 2011,45(20):6699-6708.
[4]	Yang S, Xu S N, Mohammed A, et al. Improving nitrogen removal in an IFAS nitritation-anammox reactor treating lagoon supernatant by manipulating biocarrier filling ratio and hydraulic retention time[J]. Biochemical Engineering Journal, 2019,152:107365-107365.
[5]	Xu X, Liu G H, Li Q, et al. Optimization nutrient removal at different volume ratio of anoxic-to-aerobic zone in integrated fixed-film activated sludge (IFAS) system[J]. Science of The Total Environment, 2021,795(16):148824.
[6]	Murray K J, Parker W J, Bragg L M, et al. Fate of selected pharmaceutically active compounds in the integrated fixed film activated sludge process[J]. Water Science & Technology, 2017:2680-2691.
[7]	Drewnowski J, Remiszewska-Skwarek A, Duda S, et al. Aeration process in bioreactors as the main energy consumer in a wastewater treatment plant. Review of solutions and methods of process optimization[J]. Processes, 2019,7(5):311.
[8]	Mccarty P L, Bae J, Kim J. Domestic wastewater treatment as a net energy producer——can this be achieved[J]. Environmental Science & Technology, 2011,45(17):7100-7106.
[9]	尹娟娟,宋伟冬,尹传海.城镇污水处理厂节能技术及对策研究[J]. 节能与环保, 2019:76-77. Yin J J, Song W D, Yin C H. Study on energy-serving technology and countermeasure of urban sewage treatment plant[J]. E nergy Conservation & Environmental Protection, 2019:76-77.
[10]	北京市市政工程设计研究总院.给水排水设计手册[M]. 2版.北京:中国建筑工业出版社, 2004:313. Beijing Municipal Engineering Design and Research Institute. Water supply and drainage design manual[M]. 2rd edition. Beijing:China Archiecture Publishing & Media Co. Ltd., 2004:313.
[11]	吴春雷.基于分区供氧调控的同步短程硝化-反硝化关键技术研究[D]. 西安:西安建筑科技大学, 2020. Wu C L. Research on pivotal techniques of simultaneous shortcut nitrification-denitrification based on zoned oxygen[D]. Xi`an:Xi'an University of Architecture and Technology, 2020.
[12]	曹特特,王林,李咏梅.AAO工艺低氧条件下的运行及其模拟[J]. 环境科学, 2018,39(1):219-226. Cao T T, Wang L, Li Y M. Operation of the AAO process under low dissolved oxygen conditions and its simulation[J]. Environmental Science, 2018,39(1):219-226.
[13]	Miao Y Y, Zhang L, Yang Y D, et al. Start-up of single-stage partial nitrification-anammox process treating low-strength swage and its restoration from nitrate accumulation[J]. Bioresource Technology, 2016,218:771-779.
[14]	张芸蓓,马明,宫玲,等.A/A/O污水处理工艺脱氮效果模拟及优化[J]. 中国给水排水, 2022,38(1):88-94. Zhang Y B, Ma M, Gong L, et al. Simulation of denitrification of A/A/O process and its optimization[J]. China Water & Wastewater, 2022,38(1):88-94.
[15]	Keene N A, Reusser S R, Scarborough M J, et al. Pilot plant demonstration of stable and efficient high rate biological nutrient removal with low dissolved oxygen conditions[J]. Water Research, 2017,121:72-85.
[16]	陈洪斌,唐贤春,何群彪,等.倒置AAO工艺聚磷微生物的吸磷行为[J]. 中国环境科学, 2007,27(1):5. Chen H B, Tang X C, Chun Q B, et al. Phosphorus uptaking behavior of phosphorus accumulating organisms in reversed AAO process[J]. China Environmental Science, 2007,27(1):5.
[17]	李冬,李悦,李雨朦,等.好氧颗粒污泥同步硝化内源反硝化脱氮除磷[J]. 中国环境科学, 2022,42(3):7. Li D, Li Y, Li Y M, et al. Simultaneous nitrification and denitrification of aerobic granular slugde for nitrogen and phosphorus removal[J]. China Environmental Science, 2022,42(3):7.
[18]	张建华,王淑莹,张淼,等.不同反应时间内碳源转化对反硝化除磷的影响[J]. 中国环境科学, 2017,37(3):9. Zhang J H, Wang S Y, Zhang M, et al. Effect of conversion of internal carbon source on denitrifying phosphorus removal under different reaction time[J]. China Environmental Science, 2017,37(3):9.
[19]	姜鸣,张静慧,宫飞蓬,等.生物反硝化除磷技术研究进展[J]. 净水技术, 2011,30(6):5. Jiang M, Zhang J H, Gong F P, et al. Advances in research of phosphorus removal technology for biological denitrification process[J]. Water Purification Technology, 2011,30(6):5.
[20]	孙晓,江婕,王强,等.大型污水厂中填料对A2O系统微生物种群的影响[J]. 中国给水排水, 2022,38(7):63-68. Kong X, Jiang J, Wang Q, et al. Effect of Suspended carrier on microbial community in A2O systyem in a full-scale wastewater treatment plant[J]. China Water & Wastewater, 2022,38(7):63-68.
[21]	Zou J, Tao Y, Li J, et al. Cultivating aerobic granular sludge in a developed continuous-flow reactor with two-zone sedimentation tank treating real and low-strength wastewater[J]. Bioresource Technology, 2018,247:776-783.
[22]	Li S, Li D, Ye X S, et al. Effect of different operational modes on the performance of granular sludge in continuous-flow systems and the successions of microbial communities[J]. Bioresource Technology, 2020,299:122573.
[23]	Lee D J, Chen Y Y, Show K Y, et al. Advances in aerobic granule formation and granule stability in the course of storage and reactor operation[J]. Biotechnology Advances, 2010,28(6):919-934.
[24]	Wei S P, Stensel H D, Bao N Q, et al. Flocs in disguise? High granule abundance found in continuous-flow activated sludge treatment plants[J]. Water Research, 2020,179:115865.
[25]	Lee D J, Chen Y Y. Magnesium carbonate precipitate strengthened aerobic granules[J]. Bioresource Technology, 2015,183:136-140.
[26]	Xu D, Li J, Liu J, et al. Rapid aerobic sludge granulation in an integrated oxidation ditch with two-zone clarifiers[J]. Water Research, 2020,175(15):115704.1-115704.11.
[27]	熊英,向斯,程凯,等. N. europaea/Nc. mobilis谱系在垃圾渗滤液处理中的脱氮贡献[J]. 中国环境科学, 2021,41(6):2602-2609. Xiong Y, Xiang S, Cheng K, et al. The contribution of Nitrosomonas europaea/Nitrosococcus mobilis lineage to the deamination in full-scale landfill leachate treatment systems[J]. China Environmental Science, 2021,41(6):2602-2609.
[28]	刘春,王聪聪,刘颖,等.生物膜反应器-单宁酸铁处理低C/N废水的脱氮性能[J]. 中国环境科学, 2019,39(5):1993-1999. Liu C, Wang C C, Liu Y, et al. Nitrogen removal process in low C/N ratio wastewater treatment using a biofilm reactor coupled with embedded ferric tannate[J]. China Environmental Science, 2019, 39(5):1993-1999.
[29]	文菲.泥膜复合强化污水生物脱氮技术应用及其机理研究[D]. 青岛:青岛理工大学, 2017. Wen F. Study on application of biological nitrogen removal technology of hybrid biofilm-activated sludge process and its mechanism[D]. Qingdao:Qingdao University of Technology, 2017.
[30]	张树松.菌株Diaphorobacter polyhydroxybutyrativorans SL-205强化固相反硝化脱氮的效能与机理[D]. 哈尔滨:东北林业大学, 2018. Zhang S S. Performance and mechanisms for bioaugmentation of solid-phase denitrification using Diaphorobacter polyhydroxybutyrativorans SL-205[D]. Harbin:Northeast Forestry University, 2018.
[31]	赵丹,于德爽,李津,等.菌株ZD8的分离鉴定及其异养硝化和缺氧/好氧反硝化特性研究[J]. 环境科学学报, 2013,33(11):3007-3016. Zhao D, Yu D S, Li J, et al. Isolation and identification of a bicterial strain ZD8 and its characteristics of heterotrophic nitrification and anoxic/oxic denitrification[J]. Acta Scientiae Circumstantiae, 2013, 33(11):3007-3016.
[32]	Su J F, Li G Q, Huang T L, et al. The mixotrophic denitrification characteristics of Zoogloea sp. L2 accelerated by the redox mediator of 2-hydroxy-1,4-naphthoquinone[J]. Bioresource Technology, 2021, 340:125690.