废铁屑缓解硫化物抑制厌氧氨氧化脱氮性能的研究

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (1759 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract The long-term inhibition of sulfide on anaerobic ammonia oxidation (Anammox) system and the effect of adding scrap iron on the system performance were studied in an up-flow anaerobic sludge bed reactor (UASB). Results showed that low concentration (<10mg/L) of sulfide had no significant effect on the system performance. When its concentration increased to 20, 30 and 40mg/L, the nitrogen removal rate (NRR) of the reactor decreased by 13%, 42% and 51%, respectively. The high concentration (40mg/L) of sulfide reduced the specific anaerobic ammonia oxidation activity (SAA) by 63%. Anammox biomass had adaptability to the sulfide inhibition. Moreover, the long-term operation with sulfides caused the deterioration of particle structure, sludge floating, and caking. The addition of iron scrap significantly alleviated the inhibition of sulfide, and quickly recovered the sludge settleability and the reactor nitrogen removal efficiency. After 19 days of iron scrap addition, the NRR increased by 20% (up to 4.43kg/(m³·d)) compared with the sulfur-free stage, and the SAA reduced only by 16.8%. The microbial community analysis showed that the increased sulfide concentrations caused the decrease of the relative abundance of Candidatus Kuenenia from 18.81% to 7.31%. The relative abundance of Candidatus Kuenenia at the bottom layer of the reactor was 15 times higher than that at the top layer after adaptation. At the same time, the denitrifying bacteria (Arenimonas and Thiobacillus) were enriched. After adding scrap iron, the abundance of Ca. Kuenenia decreased slightly, but the relative abundance of Ca. Kuenenia at the top layer was higher than that at the bottom layer. The relative abundance of Thiobacillus in the system increased by 3.36 times, and the relative abundance of denitrifying bacteria in the bottom layer also increased. This study provides a new idea for promoting the application of Anammox process in sulfide containing wastewater.

Key words： Anammox sulfide inhibition nitrogen removal scrap iron

Received: 10 August 2022

PACS:

X703

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	CHEN Jie
	WANG Cai-xia
	WANG Qian
	SHEN Yao-liang
	LIU Wen-ru

Cite this article:

CHEN Jie,WANG Cai-xia,WANG Qian等. Performance of iron scrap to alleviate the inhibition of sulfides on denitrification by anaerobic ammoxidation[J]. CHINA ENVIRONMENTAL SCIENCECE, 2023, 43(4): 1636-1645.

URL:

http://www.zghjkx.com.cn/EN/ OR http://www.zghjkx.com.cn/EN/Y2023/V43/I4/1636

[1]	李天皓,徐云翔,郭之晗,等.低温下废铁屑对厌氧氨氧化系统的影响[J]. 中国环境科学, 2022,42(4):1688-1695. Li T H, Xu Y X, Guo Z H, et al. Effect of iron scraps on anammox systems at low temperature[J]. China Environmental Science, 2022, 42(4):1688-1695.
[2]	Tang C J, Zheng P, Wang C H, et al. Performance of high-loaded ANAMMOX UASB reactors containing granular sludge[J]. Water Research, 2011,45(1):135-144.
[3]	Mulder A, Graaf A A V D, Robertson L A, et al. Anaerobic ammonium oxidation discovered in a denitrifying fluidized bed reactor[J]. FEMS Microbiology Ecology, 1995,16(3):177-184.
[4]	Jaroszynski L W, Cicek N, Sparling R, et al. Impact of free ammonia on anammox rates (anoxic ammonium oxidation) in a moving bed biofilm reactor[J]. Chemosphere, 2012,88(2):188-195.
[5]	De Almeida Fernandes L, Pereira A D, Leal C D, et al. Effect of temperature on microbial diversity and nitrogen removal performance of an anammox reactor treating anaerobically pretreated municipal wastewater[J]. Bioresource Technology, 2018,258:208-219.
[6]	Gani K M, Awolusi O O, Khan A A, et al. Potential strategies for the mainstream application of anammox in treatment of anaerobic effluents-A review[J]. Critical Reviews in Environmental Science and Technology, 2020,51(21):2567-2594.
[7]	Delgado Vela J, Stadler L B, Martin K J, et al. Prospects for biological nitrogen removal from anaerobic effluents during mainstream wastewater treatment[J]. Environmental Science & Technology Letters, 2015,2(9):234-244.
[8]	Huang S, Yu D, Chen G, et al. Realization of nitrite accumulation in a sulfide-driven autotrophic denitrification process:Simultaneous nitrate and sulfur removal[J]. Chemosphere, 2021,278:130413.
[9]	Pokorna D, Zabranska J. Sulfur-oxidizing bacteria in environmental technology[J]. Biotechnol Advances, 2015,33(6Pt 2):1246-1259.
[10]	Ruth P, Elddie R M, Juan L G. Hydrogen sulfide and hemeproteins:knowledge and mysteries[J]. Antioxidants & Redox Signaling, 2011, 15(2):393-404.
[11]	Kabil O, Banerjee R. Redox biochemistry of hydrogen sulfide[J]. Journal of Biological Chemistry, 2010,285(29):21903-21907.
[12]	Kartal B, Keltjens J T. Anammox biochemistry:a tale of heme c Proteins[J]. Trends In Biochemical Sciences, 2016,41(12):998-1011.
[13]	Wisniewski K, Di B A, Munz G, et al. Kinetic characterization of hydrogen sulfide inhibition of suspended anammox biomass from a membrane bioreactor[J]. Biochemical Engineering Journal, 2018,143:48-57.
[14]	Jin R C, Yang G F, Zhang Q Q, et al. The effect of sulfide inhibition on the Anammox process[J]. Water Research, 2013,47(3):1459-1469.
[15]	Xu L Z, Zhang Q, Fu J J, et al. Deciphering the microbial community and functional genes response of anammox sludge to sulfide stress[J]. Bioresource Technology, 2020,302:122885.
[16]	Wu C, Qin Y, Yang L, et al. Effects of loading rates and N/S ratios in the sulfide-dependent autotrophic denitrification (SDAD) and Anammox coupling system[J]. Bioresource Technology, 2020,316:123969.
[17]	Mai Y, Liang Y, Cheng M, et al. Coupling oxidation of acid volatile sulfide, ferrous iron, and ammonia nitrogen from black-odorous sediment via autotrophic denitrification-anammox by nitrate addition[J]. Science of the Total Environment, 2021,790:147972.
[18]	Deng Y F, Wu D, Huang H, et al. Exploration and verification of the feasibility of sulfide-driven partial denitrification coupled with anammox for wastewater treatment[J]. Water Research, 2021,193:116905.
[19]	Van Den Hove A, Baeten J E, Decru S O, et al. Potential of sulfide-based denitrification for municipal wastewater treatment[J]. Journal of Water Process Engineering, 2020,35:101206-101206.
[20]	Russ L, Speth D R, Jetten M S, et al. Interactions between anaerobic ammonium and sulfur-oxidizing bacteria in a laboratory scale model system[J]. Environmental Microbiology, 2014,16(11):3487-3498.
[21]	李甲国.硫化物、硝酸盐和氨氮同步去除效能及关键影响因素[D]. 青岛:中国石油大学(华东), 2015. Li J G. Simultaneous Biological removal of nitrate, sulfide and ammonia from wastewater and key influencing factors[D]. Qingdao:China University of Petroleum (East China), 2015.
[22]	Cui Y X, Biswal B K, Guo G, et al. Biological nitrogen removal from wastewater using sulphur-driven autotrophic denitrification[J]. Applied Microbiology and Biotechnology, 2019,103(15):6023-6039.
[23]	Ge H, Zhang L, Batstone D J, et al. Impact of iron salt dosage to sewers on downstream anaerobic sludge digesters:Sulfide control and methane production[J]. Journal of Environmental Engineering, 2013, 139:594-601.
[24]	Abbott T, Eskicioglu C. Effects of metal salt addition on odor and process stability during the anaerobic digestion of municipal waste sludge[J]. Waste Management, 2015,46:449-458.
[25]	Park C M, Novak J T. The effect of direct addition of iron(III) on anaerobic digestion efficiency and odor causing compounds[J]. Water Science and Technology, 2013,68(11):2391-2396.
[26]	Bi Z, Qiao S, Zhou J, et al. Fast start-up of Anammox process with appropriate ferrous iron concentration[J]. Bioresource Technology, 2014,170:506-512.
[27]	Feng L, Li J, Ma H, et al. Effect of Fe(II) on simultaneous marine anammox and Feammox treating nitrogen-laden saline wastewater under low temperature:Enhanced performance and kinetics[J]. Desalination, 2020,478:114287-114295.
[28]	Li J, Feng L, Biswal B K, et al. Bioaugmentation of marine anammox bacteria (MAB)-based anaerobic ammonia oxidation by adding Fe(III) in saline wastewater treatment under low temperature[J]. Bioresource Technology, 2020,295:122292.
[29]	Xie F, Ma X, Zhao B, et al. Promoting the nitrogen removal of anammox process by Fe-C micro-electrolysis[J]. Bioresource Technology, 2020,297:122429.
[30]	马娇,曾天续,宋珺,等.纳米单质铁对厌氧氨氧化脱氮性能的影响[J]. 中国环境科学, 2022,42(6):2619-2627. Ma J, Zeng T X, Song J, et al. Effect of nanoscale zero-valent iron on the denitrification performance anaerobic ammonia oxidation[J]. China Environmental Science, 2022,42(6):2619-2627.
[31]	陈翠忠,额热艾汗,刘洪光,等.铁对厌氧氨氧化过程及脱氮性能的影响[J]. 环境科学与技术, 2021,44(5):14-24. Chen C Z, Ereaihan,Liu H G, et al. Effect of iron on anammox process and nitrogen removal performance:a review[J]. Environmental Science & Technology, 2021,44(5):14-24.
[32]	汪倩,宋家俊,郭之晗,等.低基质浓度下生物膜亚硝化工艺的快速启动及其运行效能[J]. 环境工程学报, 2021,15(7):2512-2521. Wang Q, Song J G, Guo Z H, et al. Fast start-up of nitrosation biofilm process and its performance with low strength sewage[J]. Chinese Journal of Environmental Engineering, 2021,15(7):2512-2521.
[33]	陈重军,张海芹,汪瑶琪,等.基于高通量测序的ABR厌氧氨氧化反应器各隔室细菌群落特征分析[J]. 环境科学, 2016,37(7):2652-2658. Chen C G, Zhang H Q, Wang Y Q, et al. Characteristics of microbial community in each compartment of ABR ANAMMOX reactor based on high-throughput sequencing[J]. Environmental Science, 2016, 37(7):2652-2658.
[34]	Guibing Z, Yongzhen P, Baikun L, et al. Biological removal of nitrogen from wastewater[J]. Reviews of Environmental Contamination and Toxicology, 2008,192:159-195.
[35]	Di Capua F, Pirozzi F, Lens P N L, et al. Electron donors for autotrophic denitrification[J]. Chemical Engineering Journal, 2019, 362:922-937.
[36]	杨亚飞.Fe(Ⅱ)/Fe(Ⅲ)循环驱动的厌氧脱氨氮[D]. 大连:大连理工大学, 2020. Yang Y F. Anaerobic ammonium removal driven by Fe(Ⅱ)/Fe(Ⅲ) cycle[D]. Dalian:Dalian University of Technology, 2020.
[37]	Chamchoi N, Nitisoravut S. Anammox enrichment from different conventional sludges[J]. Chemosphere, 2007,66(11):2225-2232.
[38]	Mahmood Q, Zheng P, CAI J, et al. Anoxic sulfide biooxidation using nitrite as electron acceptor[J]. Journal of Hazardous Materials, 2007, 147(1/2):249-256.
[39]	Sheng G P, Yu H Q, Li X Y. Extracellular polymeric substances (EPS) of microbial aggregates in biological wastewater treatment systems:a review[J]. Biotechnol Adv, 2010,28(6):882-894.
[40]	Jia F, Peng Y, Li J, et al. Metagenomic prediction analysis of microbial aggregation in anammox-dominated community[J]. Water Environment Research, 2021,93(11):2549-2558.
[41]	Nsenga Kumwimba M, Lotti T, Senel E, et al. Anammox-based processes:How far have we come and what work remains? A review by bibliometric analysis[J]. Chemosphere, 2020,238:124627.
[42]	Lahav O, Massada I B, Yackoubov D, et al. Quantification of anammox activity in a denitrification reactor for a recirculating aquaculture system[J]. Aquaculture, 2009,288(1/2):76-82.
[43]	Wang Y, Shen L, Wu J, et al. Step-feeding ratios affect nitrogen removal and related microbial communities in multi-stage vertical flow constructed wetlands[J]. Science of the Total Environment, 2020, 721:137689.
[44]	Pelissari C, Avila C, Trein C M, et al. Nitrogen transforming bacteria within a full-scale partially saturated vertical subsurface flow constructed wetland treating urban wastewater[J]. Science of the Total Environment, 2017,574:390-399.
[45]	Xu D, Xiao E, Xu P, et al. Bacterial community and nitrate removal by simultaneous heterotrophic and autotrophic denitrification in a bioelectrochemically-assisted constructed wetland[J]. Bioresour Technol, 2017,245(Pt A):993-999.
[46]	Lyu W, Huang L, Xiao G, et al. Effects of carbon sources and COD/N ratio on N2O emissions in subsurface flow constructed wetlands[J]. Bioresource Technology, 2017,245(Pt A):171-181.
[47]	Wang L, Wei B, Chen Z, et al. Effect of inoculum and sulfide type on simultaneous hydrogen sulfide removal from biogas and nitrogen removal from swine slurry and microbial mechanism[J]. Applied Microbiology and Biotechnology, 2015,99(24):10793-10803.
[48]	Lu H, Sato Y, Fujimura R, et al. Limnobacter litoralis sp. nov., a thiosulfate-oxidizing, heterotrophic bacterium isolated from a volcanic deposit, and emended description of the genus Limnobacter[J]. International Journal of Systematic and Evolutionary Microbiology, 2011,61(Pt 2):404-407.