硝化微颗粒污泥的快速培养及其对硫化物的响应特性

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (1657 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract The dewatered sludge of municipal wastewater treatment plant was inoculated in a continuous flow gas lift internal circulation reactor, and the rapid culture of nitrified granular sludge and its response to sulfides were investigated. The results showed that under the condition of high inoculation sludge concentration (19.3g/L), sludge granulation was basically achieved within 30 days by gradually shortening HRT (7h to 2h) and increasing influent ammonia nitrogen load (0.5kg/(m³·d) to 3.1kg/(m³·d)). The SVI₃=SVI₃₀ was (16.8±0.3)mL/g, and the average particle size of granular sludge was 266 μm. The high concentration nitrification granular sludge[(11.9±0.2)g/L] ensured the high load operation of the system (ammonia nitrogen removal load (2.4±0.3)kg/(m³·d)). Sulfides in the influent significantly inhibited ammonia-oxidizing bacteria (AOB) and nitrite-oxidizing bacteria (NOB) in granular sludge, but the recovery of AOB activity was faster than that of NOB, so nitrifying micro-granular sludge achieved the function of nitrification. When the sulfide concentration increased to 10mg/L, the nitrification rate reached about 80%. However, when the sulfide concentration was further increased to 20mg/L, the nitrification rate did not increase significantly. The batch experiments on the 82nd day showed that AOB activity decreased with the increase of initial sulfide concentration, while NOB activity increased, which was closely related to the stratified distribution of AOB (outer layer) and NOB (inner layer) in granular sludge. In addition, the effect of sulfides on nitrifying granular sludge with small particle size (<0.3mm) was more significant.

Key words： nitrifying microgranular sludge sulfide continuous flow nitrogen removal performance

Received: 15 September 2022

PACS:

X703

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	WANG Cai-xia
	CHEN Jie
	WANG Qian
	SHEN Yao-liang
	LIU Wen-ru

Cite this article:

WANG Cai-xia,CHEN Jie,WANG Qian等. Rapid cultivation of nitrifying microgranular sludge and its response to sulfides[J]. CHINA ENVIRONMENTAL SCIENCECE, 2023, 43(5): 2277-2285.

URL:

http://www.zghjkx.com.cn/EN/ OR http://www.zghjkx.com.cn/EN/Y2023/V43/I5/2277

[1]	蒋玲燕,周振,王英俊,等.硫化物对污水处理厂硝化菌活性的抑制作用[J].环境工程学报, 2012,6(11):4065-4068. Jiang L Y, Zhou Z, Wang Y J, et al. Inhibitory effect of sulfide on nitrifying biomass activity in wastewater treatment plants[J]. Chinese Journal of Environmental Engineering, 2012,6(11):4065-4068.
[2]	Sears K, Alleman J, Barnard J, et al. Impacts of reduced sulfur components on active and resting ammonia oxidizers[J]. 2004,31(8):369-378.
[3]	吴爽,薛宇,杨少林,等.硫化物对亚硝化污泥的活性抑制研究[J].环境科学学报, 2018,38(9):3546-3551. Wu S, Xue Y, Yang S L, et al. Study on the inhibition of sulfide on activated sludge activity for nitritation[J]. Acta Scientiae Circumstantiae, 2018,38(9):3546-3551.
[4]	Hen E T, Nico B, Erguder V S, et al. Partial nitrification achieved by pulse sulfide doses in a sequential batch reactor[J]. Environmental science & technology, 2008,42(23):8715-8720.
[5]	Hassan M O, Gani K M, Kumari S, et al. Start-up of partial nitrification by intermittent aeration, pH shocks and sulfide addition in a sequential batch reactor[J]. Journal of Chemical Technology & Biotechnology, 2022,97(8):2186-2195.
[6]	Bejarano Ortiz D I, Thalasso F, Cuervo López F d M, et al. Inhibitory effect of sulfide on the nitrifying respiratory process[J]. Journal of Chemical Technology & Biotechnology, 2013,88(7):1344-1349.
[7]	Kreuk M K d, Kishida N, Loosdrecht M C M v. Aerobic granular sludge-state of the art[J]. Water Science and Technology, 2007,55(8/9):75-81.
[8]	李冬,李悦,李雨朦,等.好氧颗粒污泥同步硝化内源反硝化脱氮除磷[J].中国环境科学, 2022,42(3):1113-1119. Li D, Li Y, Li Y M, et al. Simultaneous nitrification and denitrification of aerobic granular sludge for nitrogen and phosphorus removal[J]. China Environmental Science, 2022,42(3):1113-1119.
[9]	宋志伟,宁婷婷,王秋旭.好氧硝化颗粒污泥的培养及其性能[J].环境工程学报, 2015,9(1):200-206. Song Z W, Ning T T, Wang Q X. Cultivation and characteristics of aerobic nitrifying granules[J]. Chinese Journal of Environmental Engineering, 2015,9(1):200-206.
[10]	李冬,杨敬畏,李悦,等.连续流好氧颗粒污泥系统的稳定运行——通过调控回流比及有机负荷[J].中国环境科学, 2021,41(9):4149-4156. Li D, Yang J W, Li Y, et al. Stable operation of aerobic granular sludge continuous flow system——by controlling reflux ratio and organic load[J]. China Environmental Science, 2021,41(9):4149-4156.
[11]	付香云,余诚,王凯军,等.连续流培养好氧颗粒污泥研究进展[J].中国环境科学, 2022,42(4):1726-1736. Fu X Y, Yu C, Wang K J, et al. Research advances on continuous flow aerobic granular sludge cultivation[J]. China Environmental Science, 2022,42(4):1726-1736.
[12]	Coma M, Verawaty M, Pijuan M, et al. Enhancing aerobic granulation for biological nutrient removal from domestic wastewater[J]. Bioresource Technology, 2012,103(1):101-108.
[13]	Long B, Yang C Z, Pu W H, et al. Rapid cultivation of aerobic granular sludge in a pilot scale sequencing batch reactor[J]. Bioresource Technology, 2014,166(4):57-63.
[14]	Hu L L,Wang J L, Wen X H, et al. The formation and characteristics of aerobic granules in sequencing batch reactor (SBR) by seeding anaerobic granules[J]. Process Biochemistry, 2005,40(1):5-11.
[15]	王良杰,湛含辉,孙璨.以脱水污泥为接种污泥促进好氧污泥颗粒化[J].中国环境科学, 2016,36(11):3405-3411. Wang L J, Zhan H H, Sun C. Enhancing aerobic granulation by seeding dewatered sludge[J]. China Environmental Science, 2016,36(11):3405-3411.
[16]	刘丽,任婷婷,徐得潜,等.高强度好氧颗粒污泥的培养及特性研究[J].中国环境科学, 2008,28(4):360-364. Liu L, Ren T T, Xu D T, et al. Cultivation and characteristics of the high strength aerobic granular sludge[J]. China Environmental Science, 2008,28(4):360-364.
[17]	鲁文娟,陈希,袁林江.连续流传统活性污泥系统中好氧颗粒污泥的培养[J].环境工程学报, 2013,7(6):2069-2073. Lu W J, Chen X, Yuan L J. Aerobic granular sludge cultivated in a conventional continuous flow activated sludge system[J]. Chinese Journal of Environmental Engineering, 2013,7(6):2069-2073.
[18]	Van de Graaf A A, de Bruijn P, Robertson L A, et al. Autotrophic growth of anaerobic ammonium-oxidizing micro-organisms in a fluidized bed reactor[J]. Microbiology, 1996,142(8):2187-2196.
[19]	国家环境保护局.水和废水监测分析方法(第四版)[M].北京:中国环境科学出版社, 2002. State Environmental Protection Administration. Water and wastewater monitoring and analysis methods-4th edition[M]. Beijing:China Environmental Science Press, 2002.
[20]	Kent T R, Bott C B, Wang Z W. State of the art of aerobic granulation in continuous flow bioreactors[J]. Biotechnology advances, 2018, 36(4):1139-1166.
[21]	Kishida N, Kono A, Yamashita Y, et al.Formation of aerobic granular sludge in a continuous-flow reactor-control strategy for the selection of well-settling granular sludge[J]. Water environment & technology, 2010,8(3):251-258.
[22]	Tsuneda S, Nagano T, Hoshino T, et al. Characterization of nitrifying granules produced in an aerobic upflow fluidized bed reactor[J]. Water Research, 2003,37(20):4965-4973.
[23]	鲁文娟,陈希,袁林江.连续流传统活性污泥系统中好氧颗粒污泥的培养[J].环境工程学报, 2013,7(6):2069-2073. Lu W J, Chen X, Yuan L J. Aerobic granular sludge cultivated in a conventional continuous flow activated sludge system[J]. Chinese Journal of Environmental Engineering, 2013,7(6):2069-2073.
[24]	Jin R-C, Zheng P, Mahmood Q, et al. Performance of a nitrifying airlift reactor using granular sludge[J]. Separation and Purification Technology, 2008,63(3):670-675.
[25]	贺向峰,袁林江,陈希,等.新型好氧连续流反应器对活性污泥颗粒化的研究[J].环境科学与技术, 2022,45(7):112-120. He X F, Yuan L J, Chen X, et al. Study on granulation of activated sludge with a novel aerobic continuous flow reactor[J]. Environmental Science & Technology, 2022,45(7):112-120.
[26]	Guiot S, Pauss A, Costerton J. A structured model of the anaerobic granule consortium[J]. Water science and technology, 1992,25(7):1-10.
[27]	Tang C-J, Zheng P, Wang C-H, et al. Performance of high-loaded ANAMMOX UASB reactors containing granular sludge[J]. Water Research, 2011,45(1):135-144.
[28]	De Bruin L, De Kreuk M, Van Der Roest H, et al. Aerobic granular sludge technology:an alternative to activated sludge[J]. Water Science and Technology, 2004,49(11/12):1-7.
[29]	金宝华,宁靓,王千红.曝气充氧对污水中硫化物去除效果的研究[J].环境科学与管理, 2011,36(1):100-103. Jin B H, Ning L, Wang Q H. Study on the impact of aeration to sulfide removal[J]. Environmental Science and Management, 2011,36(1):100-103.
[30]	梁宏宝,韩东,陈洪涛,等.吹脱法处理油田集输系统污水中H2S小型工艺试验[J].油气田地面工程, 2017,36(9):24-28. Liang H B, Han D, Chen H T, et al. Small Scale Process Experiment on H2S Removal by the Blow-off Method from Sewage in the Oilfield Gathering and Transportation System[J]. Oil-Gas Field Surface Engineering, 2017,36(9):24-28.
[31]	de Graaff D R, van Loosdrecht M C, Pronk M J W R. Stable granulation of seawater-adapted aerobic granular sludge with filamentous Thiothrix bacteria[J]. Water Research, 2020,175:115683.
[32]	Æsoy A,Ødegaard H, Bentzen G. The effect of sulphide and organic matter on the nitrification activity in a biofilm process[J]. Water Science and Technology, 1998,37(1):115-122.
[33]	常赜,孙宁,李召旭,等.硫化物抑制亚硝酸氧化菌推动短程硝化反硝化生物脱氮技术[J].环境工程学报, 2018,12(5):1416-1423. Chang Z, Sun N, Li Z X, et al. Sulfide-driven and nitrite-oxidizing bacteria (NOB) inhibition shortcut nitrification and denitrification biological nitrogen removal technology[J]. Chinese Journal of Environmental Engineering, 2018,12(5):1416-1423.
[34]	Kouba V, Proksova E, Wiesinger H, et al. Good servant, bad master:sulfide influence on partial nitritation of sewage[J]. Water Science and Technology, 2017,76(12):3258-3268.
[35]	Vela J D, Dick G J, Love N G. Sulfide inhibition of nitrite oxidation in activated sludge depends on microbial community composition[J]. Water Research, 2018,138:241-249.
[36]	Chen Y, Cheng J J, Creamer K S. Inhibition of anaerobic digestion process:a review[J]. Bioresource technology, 2008,99(10):4044-4064.
[37]	Winkler M K, Kleerebezem R, Kuenen J G, et al. Segregation of biomass in cyclic anaerobic/aerobic granular sludge allows the enrichment of anaerobic ammonium oxidizing bacteria at low temperatures[J]. Environmental science & technology, 2011,45(17):7330-7337.
[38]	Kouba V, Proksova E, Wiesinger H, et al. Good servant, bad master:sulfide influence on partial nitritation of sewage[J]. Water science and technology, 2017,76(11/12):3258-3268.
[39]	Nguyen Quoc B, Wei S, Armenta M, et al. Aerobic granular sludge:Impact of size distribution on nitrification capacity[J]. Water Research, 2021,188:116445.