鸡粪与麦秸混合厌氧发酵产沼气特性

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (701 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract In order to evaluate effects of anaerobic fermentation on biogas production of crop straw, four different levels of wheat straw and their mixtures with chicken manure were generated to make anaerobic fermentation; then, the gas production, pH value, EC, TVFAs, NH₄⁺-N, and alkalinity contents of the digestive juice were analyzed during the experiment. The results showed that the biogas yields of wheat straw fermented alone were low, and the indicators of digestive juice in the mono-fermentation of different forms of wheat straw tended to be highly similar. In general, the values of indicators of the raw wheat straw were higher than those of the fermented wheat straw. The indicators' values of the extruded wheat straw were higher than those of the unextruded wheat straw. In addition, the biogas yield, the pH value, EC, and the TVFAs, NH₄⁺-N, and alkalinity contents of chicken manure were much higher than those of all wheat straw fermented treatments alone. The biogas production rate and gas peak of wheat straw were improved by fermenting with chicken manure, while the peak occurrence time and the time to reach 80% of the total biogas production were also shorten. However, not all forms of wheat straw were available to the fermentation with chicken manure to improve the biogas production of wheat straw. After deducting the biogas production of chicken manure, the TS biogas yields of the fermentation treatments of chicken manure with raw wheat straw, extruded wheat straw, fermented wheat straw, and extruded fermented wheat straw increased by -12.19%, 10.54%, 13.01%, and -12.21%, respectively, compared with the corresponding wheat straw fermented alone. There were no significant differences in indicators' values between treatments (P>0.05). The values of those indicators in fermentation treatments were in between those of the treatments of chicken manure and wheat straw fermented alone. The changes in biogas production and each index were more moderate, and the anaerobic fermentation process was more stable. Therefore, a higher gas yield can be obtained by mixing chicken manure with extruded straw or primarily fermented wheat straw.

Key words： co-digestion chicken manure crop straw biogas lignocellulose

Received: 18 September 2022

PACS:	X712
	X705

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	CHEN Guang-yin
	ZHENG Jia-wei
	CAO Hai-nan
	WANG En-hui
	WU Pei

Cite this article:

CHEN Guang-yin,ZHENG Jia-wei,CAO Hai-nan等. Biogas production characteristics of anaerobic fermentation by mixing chicken manure with crop straw[J]. CHINA ENVIRONMENTAL SCIENCECE, 2023, 43(5): 2373-2380.

URL:

http://www.zghjkx.com.cn/EN/ OR http://www.zghjkx.com.cn/EN/Y2023/V43/I5/2373

[1]	金书秦,韩冬梅,吴娜伟.中国畜禽养殖污染防治政策评估[J].农业经济问题, 2018,3:119-126. Jin S Q, Han D M, Wu N W. Evaluation on prevention policies for livestock and poultry pollution in China[J]. Issues in Agricultural Economy, 2018,3:119-126.
[2]	李自林.我国农业面源污染现状及其对策研究[J].干旱地区农业研究, 2013,31(5):207-212. Li Z L. Review of the current situation and control counter measures in agricultural non-point source pollution control in China[J]. Agricultural Research in the Arid Areas, 2013,31(5):207-212.
[3]	Li H, Dai M, Dai S, et al. Current status and environment impact of direct straw return in China's cropland-A review[J]. Ecotoxicology and Environmental Safety, 2018,159:293-300.
[4]	Zhao W Y, Deng J B, Chi S L, et al. Sustainability assessment of topsoil ecology in Chongqing, China based on the application of livestock and poultry manure[J]. Journal of Cleaner Production, 2022, 358:131969.
[5]	Kiyasudeen S K, Ibrahim M H, Quaik S, et al. Prospects of organic waste management and the significance of earthworms[M]. Cham:Springer International Publishing Switzerland, 2016:23-42.
[6]	Hao X D, Liu R B, Huang X. Evaluation of the potential for operating carbon neutral WWTPs in China[J]. Water Research, 2015,87:424-431.
[7]	Maragkaki A, Vasileiadis I, Fountoulakis M, et al. Improving biogas production from anaerobic co-digestion of sewage sludge with a thermal dried mixture of food waste, cheese whey and olive mill wastewater[J]. Waste Management, 2018,71:644-651.
[8]	Lee J, Hong J, Jeong S, et al. Interactions between substrate characteristics and microbial communities on biogas production yield and rate[J]. Bioresource Technology, 2020,303:122934.
[9]	Chen G Y, Zheng Z, Yang S G, et al. Experimental co-digestion of corn stalk and vermicompost to improve biogas production[J]. Waste Management, 2010,30(10):1834-1840.
[10]	Kunatsa T, Xia X. A review on anaerobic digestion with focus on the role of biomass co-digestion, modelling and optimisation on biogas production and enhancement[J]. Bioresource Technology, 2022,344:126311.
[11]	Hegde S, Trabold T A. Anaerobic digestion of food waste with unconventional co-substrates for stable biogas production at high organic loading rates[J]. Sustainability, 2019,11:3875.
[12]	宋籽霖,郭燕,杨改河,等.鸡粪与玉米秸秆混合发酵沼气产量影响因子研究[J].农业环境科学学报, 2012,31(8):1624-1629. Song Z L, Guo Y, Yang G H, et al. Factors affecting biogas yields of manure-straw mixture[J]. Journal of Agro-Environment Science, 2012,31(8):1624-1629.
[13]	赵玲,王聪,田萌萌,等.秸秆与畜禽粪便混合厌氧发酵产沼气特性研究[J].中国沼气, 2015,33(5):32-37. Zhao L, Wang C, Tian M M, et al. Characteristics of anaerobic fermentation of mixed livestock manure and straw[J]. China Biogas, 2015,33(5):32-37.
[14]	乔玮,尹冬敏,刘月玲,等.HRT对餐厨垃圾与秸秆混合高温厌氧发酵的影响[J].中国环境科学, 2017,37(12):4596-4604. Qiao W, Yin D M, Liu Y L, et al. Effect of hydraulic retention time on thermophilic anaerobic co-digestion of food waste and straw[J]. China Environmental Science, 2017,37(12):4596-4604.
[15]	宋籽霖,李轶冰,杨改河,等.温度及总固体浓度对粪秆混合发酵产气特性的影响[J].农业工程学报, 2010,26(7):260-265. Song Z L, Li Y B,Yang G H, et al. Effects of total solid concentration and temperature on biogas yields of mixture of chicken manure and corn straw[J]. Transactions of the CSAE, 2010,26(7):260-265.
[16]	Chen G Y, Zheng Z, Yang S G, et al. Improving conversion of Spartina alterniflora into biogas by co-digestion with cow feces[J]. Fuel Processing Technology, 2010,91(11):1416-1421.
[17]	鲍士旦.土壤农化分析[M].(第三版).北京:中国农业出版社, 2000:30-110. Bao S D. Soil agricultural chemistry analysis[M].(3rd edition). Beijing:China Agriculture Press, 2000:30-110.
[18]	国家环境保护总局.水和废水监测分析方法(第四版)[M].北京:中国环境科学出版社, 2002:254-284. State Environmental Protection Administration. Methods for monitoring and analysis of water and wastewater[M]. 4th Edition. Beijing:China Environmental Science Press, 2002:254-284.
[19]	Zou S Z, Wang X J, Chen Y L, et al. Enhancement of biogas production in anaerobic co-digestion by ultrasonic pretreatment[J]. Energy Conversion and Management, 2016,112:226-235.
[20]	国家环境保护总局.水和废水监测分析方法(第四版)[M].北京:中国环境科学社, 2002,120. State Environmental Protection Administration. Methods for monitoring and analysis of water and wastewater[M]. 4th Edition. Beijing:China Environmental Science Press, 2002:120.
[21]	Yong Z H, Dong Y L, Zhang X, et al. Anaerobic co-digestion of food waste and straw for biogas production[J]. Renewable Energy, 2015,78:527-530.
[22]	Jing N, Zhou M D, Pan X F, et al. Simultaneous biogas and biogas slurry production from co-digestion of pig manure and corn straw:Performance optimization and microbial community shift[J]. Bioresource Technology, 2019,282:37-47.
[23]	李东,叶景清,甄峰,等.稻草与鸡粪配比对混合厌氧消化产气率的影响[J].农业工程学报, 2013,29(2):232-238. Li D, Ye J Q, Zhen F, et al. Effects of anaerobic co-digestion of different proportions between rice straw and chicken manure on biogas yield rate[J]. Transactions of the Chinese Society of Agricultural Engineering, 2013,29(2):232-238.
[24]	Kiros H, Zong J P, Li D X, et al. Anaerobic co-digestion process for biogas production:Progress, challenges and perspectives[J]. Renewable and Sustainable Energy Reviews, 2017,76:1485-1496.
[25]	Siddique M N I, Wahid Z A. Achievements and perspectives of anaerobic co-digestion:A review[J]. Journal of Cleaner Production, 2018,194:359-371.
[26]	陈广银,郑正,邹星星,等.牛粪对互花米草混合厌氧消化过程的影响研究[J].环境科学, 2009,30(7):2130-2135. Chen G Y, Zheng Z, Zou X X, et al. Effect of cow feces on anaerobic digestion process of Spartina alterniflora[J]. Environmental Science, 2009,30(7):2130-2135.
[27]	陈广银,常志州,叶小梅,等.鸡粪与互花米草沼渣的混合发酵产甲烷的研究[J].环境科学, 2012,33(1):203-207. Chen G Y, Chang Z Z, Ye X M, et al. Methane production by anaerobic co-digestion of chicken manure and Spartina alterniflora residue after producing methane[J]. Environmental Science, 2012, 33(1):203-207.
[28]	Bayrakdar A, Molaey R, Sürmeli RÖ, et al. Biogas production from chicken manure:Co-digestion with spent poppy straw[J]. International Biodeterioration & Biodegradation, 2017,119:205-210.
[29]	Li Y Q, Zhang R H, Liu X Y, et al. Evaluating methane production from anaerobic mono-and co-digestion of kitchen waste, corn stover, and chicken manure[J]. Energy & Fuels, 2013,27(4):2085-2091.
[30]	Kayhanian M. Ammonia inhibition in high-solids biogasification:an overview and practical solutions[J]. Environmental Technology, 1999, 20(4):355-365.
[31]	Christou M L, Vasileiadis S, Kalamaras S D, et al. Ammonia-induced inhibition of manure-based continuous biomethanation process under different organic loading rates and associated microbial community dynamics[J]. Bioresource Technology, 2021,320:124323.
[32]	Czatzkowska M, Harnisz M, Korzeniewska E, et al. Inhibitors of the methane fermentation process with particular emphasis on the microbiological aspect:A review[J]. Energy Science & Engineering, 2020,8:1880-1897.
[33]	Jiang Y, Mcadam E, Zhang Y, et al. Ammonia inhibition and toxicity in anaerobic digestion:a critical review[J]. Journal of Water Process Engineering, 2019,32:100899.
[34]	Sung S, Liu T. Ammonia inhibition on thermophilic anaerobic digestion[J]. Chemosphere, 2003,53(1):43-52.