|
|
Effects of rhamnolipid on organic carbon sources in waste activated sludge digestion by autothermal thermophilic micro-aerobic digestion |
XING Yi-yan, GAO Chun-di, LIU Yi-wei, BI Hao-hua, OU Jia-li, PENG Yong-zhen |
National Engineering Laboratory for Advanced Municipal Wastewater Treatment and Reuse Technology, Faculty of Environment and Life, Beijing University of Technology, Beijing 100124, China |
|
|
Abstract The VFA (Volatile Fatty Acid) produced during the digestion of surplus sludge can be used as an additional carbon source for nitrogen and phosphorus removal in waste water treatment process. In order to evaluate effects of surfactants on the effective carbon source in the Autothermal Thermophilic Micro-Aerobic Digestion system (ATMAD) and promote the development of internal carbon sources by using RL (Rhamnolipid) as a typical biosurfactant. The results show that the amount of VFA significantly increased with an appropriate amount of RL, and the main indexes such as SCOD, VFA, protein and polysaccharide in the supernatant were highly improved. The sludge dissolution effect significantly increased with an addition of RL by 0.02~0.07g/gTSS. The release of soluble organic matter and accumulation of VFA in the reaction system increased and be up to the highest and fastest when the RL dosage was 0.07g/g TSS. In addition, increasing the concentration of bacteria related to acid production fermentation (such as Bacteroides and Clostridium) could effectively promote the accumulation of volatile fatty acids. Evidently, an appropriate dosage of rhamnolipid can lead to a high feasibility and practicability for developing high-quality external carbon sources ATMAD system.
|
Received: 24 May 2023
|
|
|
|
|
[1] |
Luo J, Zhang Q, Zhao Z N, et al.Potential influences of exogenous pollutants occurred in waste activated sludge on anaerobic digestion:A review [J].Journal of Hazardous Materials, 2020,383:121176.
|
[2] |
刘丽娅,刘丹丹,莫华荣,等.城镇污水生物脱氮除磷研究进展[J].净水技术, 2023,42(3):49-59.Liu L Y, Liu D D, Mo H R, et al.Research progress of biological nitrogen and phosphorus removal from urban sewage [J].Water Purification Technology, 2023,42(3):49-59.
|
[3] |
朱晓宇,陈银广.资源化利用污水厂剩余污泥产生的短链脂肪酸的研究进展[J].水处理技术, 2010,36(10):1-4.Zhu X Y, Chen Y G.Research progress on the utilization of short-chain fatty acids from residual sludge of sewage treatment plant [J].Technology of Water Treatment, 2010,36(10):1-4.
|
[4] |
Li H J, Chen Y G, Gu G W, et al.The effect of propionic to acetic acid ratio on anaerobic-aerobic (low dissolved oxygen) biological phosphorus and nitrogen removal [J].Bioresource Technology, 2008, 99(10):4400-4407.
|
[5] |
朱亮.自热高温好氧消化技术处理剩余污泥的强化方法研究[D].广州:华南理工大学, 2016.Zhu L.Study on strengthening method of self-heating and high temperature aerobic digestion technology to treat residual sludge [D].Guangzhou:South China University of Technology, 2016.
|
[6] |
Skjelhaugen O J.Thermophilic aerobic reactor for processing organic liquid wastes [J].Water research, 1999,33(7):1593-1602.
|
[7] |
Pembroke J T, Ryan M P.Autothermal thermophilic aerobic digestion (ATAD) for heat, gas, and production of a class A biosolids with fertilizer potential [J].Microorganisms, 2019,7(8):215.
|
[8] |
陈和谦.自热式高温好氧消化工艺处理城市污泥[J].中国给水排水, 2012,28(15):6-18.Chen H Q.Treatment of municipal sludge by self-heating high temperature aerobic digestion process [J].China Water & Wastewater, 2012,28(15):6-18.
|
[9] |
徐昌文,朱南文,寿宗奇,等.污泥返混对自热高温好氧消化效果的影响研究[J].环境污染与防治, 2013,35(8):23-27.Xu C W, Zhu N W, Shou Z Q, et al.Study on the effect of sludge backmixing on self-heating high temperature aerobic digestion [J].Environmental Pollution & Control, 2013,35(8):23-27.
|
[10] |
Zhang P, Chen Y G, Zhou Q.Waste activated sludge hydrolysis and short-chain fatty acids accumulation under mesophilic and thermophilic conditions:effect of pH [J].Water research, 2009,43(15):3735-3742.
|
[11] |
Jiang S, Chen Y G, Zhou Q.Effect of sodium dodecyl sulfate on waste activated sludge hydrolysis and acidification [J].Chemical Engineering Journal, 2007,132(1-3):311-317.
|
[12] |
Pavlostathis S G, Gossett J M.A kinetic model for anaerobic digestion of biological sludge [J].Biotechnology and Bioengineering, 1986, 28(10):1519-1530.
|
[13] |
Huang X F, Shen C M, Liu J, et al.Improved volatile fatty acid production during waste activated sludge anaerobic fermentation by different bio-surfactants [J].Chemical Engineering Journal, 2015,264:280-290.
|
[14] |
Luo K,Yang Q I, Yu J, et al.Combined effect of sodium dodecyl sulfate and enzyme on waste activated sludge hydrolysis and acidification [J].Bioresource technology, 2011,102(14):7103-7110.
|
[15] |
Lee B S, Kim E K.Characteristics of microbial biosurfactant as an antifungal agent against plant pathogenic fungus [J].Journal of microbiology and biotechnology, 2005,15(6):1164-1169.
|
[16] |
Morisue T, Moroi Y, and Shibata O.Solubilization of benzene, naphthalene, anthracene, and pyrene in dodecylammonium trifluoroacetate micelles [J].The Journal of Physical Chemistry, 1994,98(49):12995-13000.
|
[17] |
郑兰健,臧颖,林潼,等.高产生物表面活性剂鼠李糖脂的制备及性能研究[J].日用化学工业, 2022,52(9):937-944.Zheng L J, Zang Y, Lin T, et al.Preparation and properties of high yield biosurfactant rhamnoolipid [J].China Surfactant Detergent & Cosmetics, 2022,52(9):937-944.
|
[18] |
Shanableh A, Jones S.Production and transformation of volatile fatty acids from sludge subjected to hydrothermal treatment [J].Water Science and Technology, 2001,44(10):129-135.
|
[19] |
Mukherjee S, Das P, Sen R.Towards commercial production of microbial surfactants [J].Trends in Biotechnology, 2006,24(11):509-515.
|
[20] |
Yi X, Luo K, Yang Q, et al.Enhanced hydrolysis and acidification of waste activated sludge by biosurfactant rhamnolipid [J].Applied biochemistry and biotechnology, 2013,171:1416-1428.
|
[21] |
Zhou A J, Yang C X, Guo Z C, et al.Volatile fatty acids accumulation and rhamnolipid generation in situ from waste activated sludge fermentation stimulated by external rhamnolipid addition [J].Biochemical Engineering Journal, 2013,77:240-245.
|
[22] |
Liu W Z, Huang S H, Zhou A J, et al.Hydrogen generation in microbial electrolysis cell feeding with fermentation liquid of waste activated sludge [J].International Journal of Hydrogen Energy, 2012,37(18):13859-13864.
|
[23] |
Salsabil M R, Prorot A, Casellas M, et al.Pre-treatment of activated sludge:Effect of sonication on aerobic and anaerobic digestibility [J].Chemical Engineering Journal, 2009,148(2):327-335.
|
[24] |
Cadoret A, Conrad A, Block J.Availability of low and high molecular weight substrates to extracellular enzymes in whole and dispersed activated sludges [J].Enzyme and Microbial Technology, 2002,31(1/2):179-186.
|
[25] |
赵鹏鹤,鼠李糖脂碱热强化剩余污泥的溶出特征及产酸规律研究[D].西安:西安理工大学, 2021.Zhao P H, Study on dissolution characteristics and acid production of rhamnose-lipid-alkali heat enhanced residual sludge [D].Xi'an:Xi'an University of Technology, 2021.
|
[26] |
Yan Y Y, Feng L Y, Zhang C J, et al.Ultrasonic enhancement of waste activated sludge hydrolysis and volatile fatty acids accumulation at pH 10.0[J].Water Research, 2010,44(11):3329-3336.
|
[27] |
Xie W M, Zhang S S, Ruan L, et al.Evaluating soil dissolved organic matter extraction using three-dimensional excitation-emission matrix fluorescence spectroscopy [J].Pedosphere, 2017,27(5):968-973.
|
[28] |
赵志军,郜燕燕,刘延波,等.采用高通量测序技术分析宝丰清香型白酒大曲的真菌多样性[J].现代牧业, 2022,6(2):45-52.Zhao Z J, Gao Y Y, Liu Y B, et al.The fungal diversity of Baofeng white liquor Daqu was analyzed by high-throughput sequencing technology [J].Modern Animal Husbandry, 2022,6(2):45-52.
|
[29] |
朱东喜,邓洁莹,王志琦,等.应用高通量测序分析常温贮藏吴山贡鹅的细菌多样性[J].肉类研究, 2021,35(4):30-36.Zhu D X, Deng J Y, Wang Z Q, et al.Bacterial diversity of Wushangong geese stored at room temperature was analyzed by high-throughput sequencing [J].Meat Research, 2021,35(4):30-36.
|
[30] |
海洋所发现并培养出一种能进行光合作用的深海绿弯菌新类群[J].高科技与产业化, 2022,28(3):81.A new group of photosynthesizing deep-sea chlorocurved bacteria was discovered and cultured in the ocean [J].High-Technology & Commercialization, 2022,28(3):81.
|
[31] |
Ping Q, Zheng M, Dai X H, et al.Metagenomic characterization of the enhanced performance of anaerobic fermentation of waste activated sludge with CaO2 addition at ambient temperature:fatty acid biosynthesis metabolic pathway and CAZymes [J].Water Research, 2020,170:115309.
|
[32] |
Zhang Q, Wu Y, Luo J Y, et al.Enhanced volatile fatty acids production from waste activated sludge with synchronous phosphorus fixation and pathogens inactivation by calcium hypochlorite stimulation [J].Science of the Total Environment, 2020,712:136500.
|
[33] |
Wong M T, Zhang D, Li J, et al.Towards a metagenomic understanding on enhanced biomethane production from waste activated sludge after pH 10pretreatment [J].Biotechnology for Biofuels, 2013,6(1):1-14.
|
[34] |
Lee B, Park J G, Shin W B, et al.Microbial communities change in an anaerobic digestion after application of microbial electrolysis cells [J].Bioresource Technology, 2017,234:273-280.
|
[35] |
Tan H P, Li T T, Zhu C, et al.Parabacteroides chartae sp.nov., an obligately anaerobic species from wastewater of a paper mill [J].International Journal of Systematic and Evolutionary Microbiology, 2012,62(Pt_11):2613-2617.
|
[36] |
何荣.环氧丙烷皂化废水活性污泥中微生物群落分析及利用剩余污泥合成聚羟基脂肪酸酯(PHA) [D].济南:济南大学, 2017.He R.Analysis of microbial community in Activated sludge from propylene oxide saponification Wastewater and Synthesis of polyhydroxyfatty acid ester (PHA) from Residual sludge [D].Jinan:Jinan University, 2017.
|
|
|
|