汽车漆渣挥发性有机物释放特性及动力学研究

Abstract
Figure/Table
References (0)
Related Citation (15)

Download: PDF (1896 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract Automotive waste paint sludge (PS) is a hazardous waste produced in the process of automobile painting. PS has a high environmental pollution risk due to the presence of hazardous characteristics such as VOCs, substantial content of heavy metals and low flash point. However, the environmental risk of VOCs released from PS during storage has not been explored. VOCs release characteristics from four typical PS and the release kinetics of VOCs in PS were investigated with environmental test chamber. The results show that the internal diffusion mechanism of PS dominated the whole release period, the oxygen compounds in the released VOCs were more easily diffused from PS into the air than did the aromatic compounds, and the oil based wet paint sludge (OBWPS) had higher total volatile organic compounds (TVOC) and longer release time. Both cumulative emission mass flux of single VOCs and TVOC were fitted well by first-order kinetic equation with high squared correlation coefficients (R²>99%).

Key words： waste paint sludge(PS) volatile organic compounds(VOCs) emission characteristics kinetics

Received: 16 June 2023

PACS:

X701

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	YANG Rui-hao
	LI Bin
	LIU Yi
	YAN Yu-sen
	LIU Ze-wei
	HUANG Qi-fei
	HUANG Ze-chun
	LIU Ting-ting

Cite this article:

YANG Rui-hao,LI Bin,LIU Yi等. Characteristics of volatile organic compound release and kinetics of automotive waste paint sludge[J]. CHINA ENVIRONMENTAL SCIENCECE, 2024, 44(2): 903-910.

URL:

http://www.zghjkx.com.cn/EN/ OR http://www.zghjkx.com.cn/EN/Y2024/V44/I2/903

[1]	Ruffino B, Farina A, Dalmazzo D, et al. Cost analysis and environmental assessment of recycling paint sludge in asphalt pavements [J]. Environmental Science and Pollution Research Iinternational, 2021,28(19):24628-24638.
[2]	Salihoglu G, Salihoglu N K. A review on paint sludge from auto-motive industries:generation, characteristics and management [J]. Environmental Management, 2018,36(11):1023-1028.
[3]	Gautam S P, Bundela P S, Murumkar M, et al.Paint sludge waste coprocessing at the ACC Wadi Cement Works in Karnataka, India [J]. Waste Management, 2010,(3):57-66.
[4]	Kim B R.VOC emissions from automotive painting and their control:A review [J]. Environ Environmental Research, 2011,16(1):1-9.
[5]	Kim B R K, Adams J A. Integrated emissions management for automotive painting operations [J]. Pure and Applied Chemistry, 2001,73(8):1277-1280.
[6]	Khezri S M, Shariat S M, Tabibian S.Evaluation of extracting titanium dioxide from water-based paint sludge in automanufacturing industries and its application in paint production [J]. Industrial Health, 2013,29(8):697-703.
[7]	Zanetti M C, Ruffino B, Vercelli A, et al.Reuse of paint sludge in road pavements:technological and environmental issues [J]. Waste Management Research, 2018,36(11):1023-1028.
[8]	Nie E, Zheng G, Gao D, et al.Emission characteristics of VOCs and potential ozone formation from a full-scale sewage sludge composting plant [J]. Science of the Total Environment, 2019,659664-659672.
[9]	Sang K, Zang H, Yoon H, et al.Source apportionment of VOCs and their impact on air quality and health in the megacity of Seoul [J]. Environmental Pollution, 2019,(247):763-774.
[10]	Liu Z, Ye W, Little J C, et al. Predicting emissions of volatile and semivolatile organic compounds from building materials:A review [J]. Building and Environment, 2013,64(1):7-25.
[11]	Wei W, Xiong J, Zhao W, et al. A framework and experimental study of an improved VOC/formaldehyde emission reference for environmental chamber tests [J]. Atmospheric Environment, 2014,82:327-334.
[12]	Gao M, Liu W, Wang H, et al. Emission factor and characteristics of volatile organic compounds (VOCs) from adhesive application in indoor decoration in China [J]. Science of the Total Environme-nt, 2021,779(0):145169.
[13]	Xiong J, Yao Y, Zhang Y. C-history method:rapid measurement of the initial emittable concentration, diffusion and partition coefficients for formaldehyde and VOCs in building materials [J]. Environmental Science and Technology, 2011,45(8):3584-3590.
[14]	Yang Y M, Yan Y S, Liu Z W, et al. Characterization of gas-phase release of volatile organic compounds from automotive coating wastes [J]. Environmental Science Research, 2022,35(4):964-970.
[15]	Afshari A, Lundgren B, Ekberg L E.Comparison of three small chamber test methods for the measurement of VOC emission rates from paint [J]. Indoor Air, 2010,13(2):156-165.
[16]	Li X, He C, Bai Y, et al. Stabilization/solidification on chromium (III) wastes by C(3)A and C(3)A hydrated matrix [J]. Journal of Hazardous Materials, 2014,268(15):61-67.
[17]	Zhang X, Gang D, Sun P, et al.Goethite dispersed corn strawderived biochar for phosphate recovery from synthetic urine and its potential as a slow-release fertilizer [J]. Chemosphere, 2021,262:127861.
[18]	Liu Z, Nicolai A, Abadie M, et al. Development of a procedure for estimating the parameters of mechanistic VOC emission source models from chamber testing data [J]. Building Simulation, 2021,14(2):269-282.
[19]	Crank J.The mathematics of diffusion. 2nd Edn [J]. WSEAS Trans-actions on Systems and Control, 2007,8(3):625-626.
[20]	Salihoglu N K, Ucaroglu S, Salihoglu G. Bioconversion of industrial wastes:paint sludge from automotive manufacturing [J]. Journal of Material Cycles and Waste Management, 2018,20(4):2100-2109.
[21]	Huang S, Xiong J, Cai C, et al.Influence of humidity on the initial emittable concentration of formaldehyde and hexaldehyde in building materials:experimental observation and correlation [J]. Scientific Reports, 2016,6(3):2045-2322.
[22]	Lemmon E W, Mclinden M O, Linstrom, P, et al. 2011. NIST-Chemistry WebBook [DB/OL]. https://doi.org/doi.org/10.18434/T4D303.
[23]	Ke Q, Zhang Y, Little J C, et al. Dimensionless correlations to predict VOC emissions from dry building materials [J]. Atmospheric Environment, 2007,41(2):352-359.
[24]	Liu, Z W, Yan Y S, Tian F,et al.Comprehensive understanding the emission characteristics and kinetics of VOCs from automotive waste paint sludge in a environmental test chamber [J]. Journal of Hazardous Materials, 2022,429:128387.
[25]	Clausen P A, Wolkoff P, Hoist E, et al.Long-term emission of volatile organic compounds from waterborne paints methods of comparison [J]. Indoor Air, 2010,1(4):562-576.