生物炭辅助湿法球磨锰渣增效吸附Sb (V)

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (2064 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract This study used wet ball milling to synthesize ball-milled biochar-based manganese slag composites (QBM) with a 1:1ratio of biochar to manganese slag. The goal was to improve the adsorption efficiency of Sb(V) and the resource utilization of waste manganese slag. Herein, physicochemical properties, leaching toxicity, and Sb(V) adsorption properties of the composite materials were discussed. The composite materials exhibited a reduction of 9.7%, 63.9%, 15.2%, and 70.9% in pH value, conductivity, cation exchange capacity, and particle size, respectively, after being wet ball milled at room temperature for 8hours with a solid-liquid ratio of 1:6 and a rotation speed of 150r/min. Zeta potential significantly increased (P<0.05) between –15 and -21mV. Ball milling effectively reduced the leaching of manganese ions and ammonium nitrogen in the manganese slag from 415mg/L to 2mg/L and 82mg/L to 15mg/L, respectively, which is the levels below the standard "Integrated Wastewater Discharge Standard" (GB8978-1996). Moreover, the Sb(V) removal rate significantly increased from 31.86% to 80.98% (P<0.05). Wet ball milling improved Sb(V) adsorption efficiency and safety by enhancing the physicochemical properties of materials. This study suggests that biochar-assisted wet ball milling of manganese slag can effectively mitigate Sb(V) antimony pollution in the environment. This provides the idea that manganese slag can be used as a resource to reduce environmental pollution.

Key words： biochar manganese slag wet ball milling leaching adsorption antimony

Received: 15 November 2023

PACS:

X703

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	LU Hong-yu
	CHENG Hong-guang
	GRATIEN Twagirayezu
	FANG Xin
	HUANG Sheng-lan
	DENG Lin-bo
	JI Bo

Cite this article:

LU Hong-yu,CHENG Hong-guang,GRATIEN Twagirayezu等. Synergistic adsorption of Sb(V) using wet ball milling of manganese slag supported by biochar[J]. CHINA ENVIRONMENTAL SCIENCECE, 2024, 44(7): 3741-3748.

URL:

http://www.zghjkx.com.cn/EN/ OR http://www.zghjkx.com.cn/EN/Y2024/V44/I7/3741

[1] Amarasiriwardena D, Wu F. Antimony: Emerging toxic contaminant in the environment Preface [J]. Microchemical Journal, 2011,97(1):1-3.
[2] Kulp T R, Early E. Arsenic and primordial life [J]. Nature Geoscience, 2014,7(11):785-786.
[3] Ungureanu G, Santos S, Boaventura R, et al. Arsenic and antimony in water and wastewater: Overview of removal techniques with special reference to latest advances in adsorption [J]. Journal of Environmental Management, 2015,151:326-342.
[4] Filella M, Belzile N, Chen Y W. Antimony in the environment: A review focused on natural waters I. Occurrence [J]. Earth-Science Reviews, 2002,57(1/2):125-176.
[5] Wilson S C, Lockwood P V, Ashley P M, et al. The chemistry and behaviour of antimony in the soil environment with comparisons to arsenic: A critical review [J]. Environmental Pollution, 2010,158(5): 1169-1181.
[6] 马志强,胥思勤,孙靖茹,等.改性生物炭对废水中锑的去除研究进展[J]. 化学通报, 2021,84(4):372-376,382. Ma Z Q, Xu S Q, Sun J R, et al. Research progress on the removal of antimony from wastewater by modified biochar [J]. Chemical Bulletin, 2021,84(4):372-376,382.
[7] 李立刚,周建伟,郝春明,等.湖南冷水江锡矿山锑矿地下水污染成因研究[C]//中国陕西西安,中国地质学会2015学术年会, 2015:111- 112. Li L G, Zhou J W, Hao C M, et al. Research on the causes of groundwater pollution from antimony mines in Jiangxi Mine, Lengshui, Hunan [C]//Xi'an Shaanxi, China, Academic Annual Meeting of the Geological Society of China, 2015:111-112.
[8] Jie R, Xiao W L, Jie L, et al. Analysis of exposure status quo and environmental chemical behaviors of antimony in China [J]. Environmental Chemistry, 2020,(12):3436-3449.
[9] Belzile N, Chen Y W, Filella M. Human Exposure to Antimony: I. Sources and Intake [J]. Critical Reviews in Environmental Science and Technology, 2011,41(14):1309-1373.
[10] Wu Z, He M, Guo X, et al. Removal of antimony (III) and antimony (V) from drinking water by ferric chloride coagulation: Competing ion effect and the mechanism analysis [J]. Separation and Purification Technology, 2010,76(2):184-190.
[11] Mitsunobu S, Takahashi Y, Terada Y, et al. Antimony(V) Incorporation into Synthetic Ferrihydrite, Goethite, and Natural Iron Oxyhydroxides [J]. Environmental Science and Technology, 2010,44(10):3712-3718.
[12] Demirbas A. Heavy metal adsorption onto agro-based waste materials: A review [J]. Journal of Hazardous Materials, 2008,157(2/3):220-229.
[13] Zhao X, Dou X, Mohan D, et al. Antimonate and antimonite adsorption by a polyvinyl alcohol-stabilized granular adsorbent containing nanoscale zero-valent iron [J]. Chemical Engineering Journal, 2014,247:250-257.
[14] Jiang H, Tian L, Chen P, et al. Efficient antimony removal by self-assembled core-shell nanocomposite of Co₃O₄@rGO and the analysis of its adsorption mechanism [J]. Environmental Research, 2020,187,109657.
[15] Zhang C, Wu M, Wu K, et al. Efficient removal of antimonate and antimonite by a novel lanthanum-manganese binary oxide: Performance and mechanism [J]. Journal of Hazardous Materials, 2023,442:130-132.
[16] Meng Z, Huang S, Wu J, et al. Competitive adsorption and immobilization of Cd, Ni, and Cu by biochar in unsaturated soils under single-, binary-, and ternary-metal systems [J]. Journal of Hazardous Materials, 2023,451:103-131.
[17] Dong M, He L, Jiang M, et al. Biochar for the removal of emerging pollutants from aquatic systems: A review [J]. International journal of environmental research and public health, 2023,20(3):1679.
[18] Qiu B, Tao X, Wang H, et al. Biochar as a low-cost adsorbent for aqueous heavy metal removal: A review [J]. Journal of Analytical and Applied Pyrolysis, 2021,155:406-433.
[19] Wang L, Wang J, Wang Z, et al., Enhanced antimonate (Sb(V)) removal from aqueous solution by La-doped magnetic biochars [J]. Chemical Engineering Journal, 2018,46(4):623-632.
[20] Ma Y, Liu W J, Zhang N, et al. Polyethylenimine modified biochar adsorbent for hexavalent chromium removal from the aqueous solution [J]. Bioresource Technology, 2014,169:403-408.
[21] 金修齐,黄代宽,赵书晗,等.电解锰渣胶凝固化研究进展及其胶结充填可行性探讨[J]. 矿物岩石地球化学通报, 2020,39(1):97-103. Jin X Q, Huang D K, Zhao S H, et al. Research progress on gelation and solidification of electrolytic manganese slag and discussion on the feasibility of cementation filling [J]. Bulletin of Mineral Petrology and Geochemistry, 2020,39(1):97-103.
[22] Zhou C, Wang J, Wang N. Treating electrolytic manganese residue with alkaline additives for stabilizing manganese and removing ammonia [J]. Korean Journal of Chemical Engineering, 2013,30(11): 2037-2042.
[23] Jia X, Zhou J, Liu J, et al. The antimony sorption and transport mechanisms in removal experiment by Mn-coated biochar [J]. Science of the Total Environment, 2020,724:138-158.
[24] Garau G, Lauro G P, Diquattro S, et al. Sb(V) adsorption and desorption onto ferrihydrite: Influence of pH and competing organic and inorganic anions [J]. Environmental Science and Pollution Research, 2019,26(26):27268-27280.
[25] Liu X, Zhou J, Zhou W, et al. Efficiency and mechanisms of Sb(III/V) removal by Fe-modified biochars using X-ray absorption spectroscopy [J]. Journal of Environmental Chemical Engineering, 2021,9(6):106741.
[26] Vithanage M, Rajapaksha A U, Ahmad M, et al. Mechanisms of antimony adsorption onto soybean stover-derived biochar in aqueous solutions [J]. Journal of Environmental Management, 2015,151:443- 449.
[27] Yu T C, Wang X H, Li C. Removal of antimony by FeCl₃-modified granular-activated carbon in aqueous solution [J]. Journal of Environmental Engineering, 2014,140:1-6.
[28] Yuan J H, Xu R K, Zhang H. The forms of alkalis in the biochar produced from crop residues at different temperatures [J]. Bioresource Technology, 2011,102(3):3488-3497.
[29] 张伟明,修立群,吴迪,等.生物炭的结构及其理化特性研究回顾与展望[J]. 作物学报, 2021,47(1):1-18. Zhan W M, Xiu L Q, Wu D, et al. Review and prospects of research on the structure and physical and chemical properties of biochar [J]. Journal of Crop Science, 2021,47(1):1-18.
[30] Panahi H K S, Dehhaghi M, Ok Y S, et al. A comprehensive review of engineered biochar: Production, characteristics, and environmental applications [J]. Journal of Cleaner Production 2020,270,122462.
[31] Weber K,Quicker P. Properties of biochar [J]. Fuel, 2018,217:240-261.
[32] Zhang Q, Wang J, Lyu H, et al. Ball-milled biochar for galaxolide removal: Sorption performance and governing mechanisms [J]. Science of the Total Environment, 2019,659:1537-1545.
[33] Lyu H, Gao B, He F, et al. Experimental and modeling investigations of ball-milled biochar for the removal of aqueous methylene blue [J]. Chemical Engineering Journal, 2018,335:110-119.
[34] Lunardi C N, Gomes A J, Rocha F S, et al. Experimental methods in chemical engineering: Zeta potential [J]. Canadian Journal of Chemical Engineering, 2021,101(11):627.
[35] 王家伟.电解锰渣预处理除氨硫锰的研究[J]. 矿产综合利用, 2018,(1):115-118. Wang J W. Research on electrolytic manganese slag pretreatment to remove ammonia, sulfur and manganese [J]. Comprehensive utilization of minerals, 2018,(1):115-118.
[36] 赵博超,王雪婷,朱克松,等.洗涤方式对电解锰渣中锰回收效率及无害化处理的影响[J]. 环境工程学报, 2017,11(11):6103-6108. Zhao B C, Wang X T, Zhu K S, et al. Effect of washing methods on manganese recovery efficiency and harmless treatment in electrolytic manganese slag [J]. Journal of Environmental Engineering, 2017, 11(11):6103-6108.
[37] 赵洁,叶志隆,王佳妮,等.改性生物炭固定床对模拟湖库水体中Mn²⁺的吸附[J]. 环境科学, 2022,43(11):4971-4981. Zhao J, Ye L Z, Wang J N, et al. Adsorption of Mn²⁺ in simulated lake and reservoir water by modified biochar fixed bed [J]. environmental science, 2022,43(11):4971-4981.
[38] Wilamas A, Vinitnantharat S,Pinisakul A. Manganese adsorption onto permanganate-modified bamboo biochars from groundwater [J]. Sustainability 2023,15(8):6831.
[39] 郑华楠,宋晴,朱义,等.芦苇生物炭复合载体固定化微生物去除水中氨氮[J]. 环境工程学报, 2019,13(2):310-318. Zheng H N, Song Q, Zhu Y, et al. Reed biochar composite carrier immobilized microorganisms remove ammonia nitrogen from water [J]. Journal of Environmental Engineering, 2019,13(2):310-318.
[40] Sakhiya A K, Vijay V K,Kaushal P. Development of rice straw biochar through pyrolysis to improve drinking water quality in arsenic and manganese contaminated areas [J]. Surfaces and Interfaces, 2023,36: 102582.
[41] Cao D, Zeng H, Yang B, et al. Mn assisted electrochemical generation of two-dimensional Fe-Mn layered double hydroxides for efficient Sb(V) removal [J]. Journal of Hazardous Materials, 2017,336:33-40.
[42] Sun Q, Cui P, Liu C, et al. Antimony oxidation and sorption behavior on birnessites with different properties (δ-MnO₂ and triclinic birnessite) [J]. Environmental Pollution, 2019,246:990-998.
[43] Zhu G, Lin J, Yuan Q, et al. A biochar supported magnetic metal organic framework for the removal of trivalent antimony [J]. Chemosphere, 2021,282,131068.
[44] Tang B, Xu H, Song F, et al. Effect of biochar on immobilization remediation of Cd center dot contaminated soil and environmental quality [J]. Environmental Research, 2022,204:22-35.
[45] Zhang Y, Ren M, Tang Y, et al. Immobilization on anionic metal(loid)s in soil by biochar: A meta-analysis assisted by machine learning [J]. Journal of Hazardous Materials, 2022,438,129442.
[46] Yuan Y, Zhang N, Hu X. Effects of wet and dry ball milling on the physicochemical properties of sawdust derived-biochar [J]. Instrumentation Science and Technology, 2020,48(3):287-300.
[47] Zhai W, Dai Y, Zhao W, et al., Simultaneous immobilization of the cadmium, lead and arsenic in paddy soils amended with titanium gypsum [J]. Environmental Pollution, 2020,258.
[48] Lyu H, Gao B, He F, et al. Effects of ball milling on the physicochemical and sorptive properties of biochar: Experimental observations and governing mechanisms [J]. Environmental Pollution, 2018,233:54-63.
[49] Xiao J, Hu R, Chen G. Micro-nano-engineered nitrogenous bone biochar developed with a ball-milling technique for high-efficiency removal of aquatic Cd(II), Cu(II) and Pb(II) [J]. Journal of Hazardous Materials, 2020,387,121980.
[50] 罗乐,降林华,段宁.电解锰废渣的浸出毒性及生石灰固化技术[J]. 环境工程, 2017,35(12):139-143. Luo L, Xiang L H, Duan N. Leaching toxicity of electrolytic manganese waste residue and quicklime solidification technology [J]. Environmental Engineering, 2017,35(12):139-143.
[51] Li M, He Z, Zhong H, et al. Highly efficient persulfate catalyst prepared from modified electrolytic manganese residues coupled with biochar for the roxarsone removal [J]. Journal of Environmental Management, 2023,328,116945.
[52] Wei M, Wang B, Wu P, et al. Electrolytic manganese residue-biochar composite for simultaneous removal of antimony and arsenic from water: Adsorption performance and mechanisms[J]. Journal of Cleaner Production, 2024,437,140623.