|
|
|
| The preparation and Fenton degradation performance of in-situ grown isolated iron 4A-Fe/PES composite membrane |
| LU Jing1,2, ZHANG Han1,2, YE Hui1,2, SUN Jin-peng1,2, XIN Qing-ping1,2, ZHAO Li-zhi1,2, LIN Li-gang1,2, DING Xiao-li1,2, ZHANG Yu-zhong1,2, LI Hong1,2 |
1. State Key Laboratory of Separation Membranes and Membrane Processes, Tiangong University, Tianjin 300387, China;
2. School of Material Science and Engineering, Tiangong University, Tianjin 300387, China |
|
|
|
|
Abstract The integration of separation with Fenton oxidation aims to achieve efficient degradation of organic wastewater and continuous reuse of catalysts. In this study, 4A zeolite/PES mixed matrix membranes were prepared via non-solvent-induced phase separation and 4A-Fe/PES composite membranes were prepared by in situ growth of isolated iron species on the surface of 4A zeolite through an impregnation technique. Detailed characterization of membrane morphology and structure was conducted using SEM, FTIR, and XPS. The phenol degradation performance of this membrane was investigated under both static and dynamic conditions, with a comparative analysis of the H2O2 decomposition efficiency between 4A-Fe catalysts in powder and membrane forms. The results indicated that in situ growth of isolated iron species increased surface roughness on the zeolite. Under dynamic conditions, the degradation efficiency was significantly higher than in static conditions, reaching a 96.1% degradation rate within 1minute at pH 2, with 31.6mM H2O2 and an initial phenol concentration of 200mg/L. Catalytic kinetics revealed that, at pH 2, the degradation rate of the membrane form was 56times that of the powder form. Even After 5cycles, the membrane maintained a phenol degradation rate exceeding 90%.
|
|
Received: 20 May 2024
|
|
|
|
|
|
[1] Careghini A, Mastorgio A F, Saponaro S, et al. Bisphenol A, nonylphenols, benzophenones, and benzotriazoles in soils, groundwater, surface water, sediments, and food: a review [J]. Environmental Science and Pollution Research, 2015,22(8):5711- 5741.
[2] Pigatto G, Lodi A, Finocchio E, et al. Chitin as biosorbent for phenol removal from aqueous solution: Equilibrium, kinetic and thermodynamic studies [J]. Chemical Engineering and Processing- Process Intensification, 2013,70:131-139.
[3] Edition, Fourth. Guidelines for drinking-water quality [J]. World Health Organization Chronicle, 2011,38(4):104-108.
[4] Ayers R S, Westcot D W. Water quality for agriculture [M]. Rome: Food and agriculture organization of the United Nations, 1985.
[5] Velickovic T D C, Stanic-Vucinic D J. The role of dietary phenolic compounds in protein digestion and processing technologies to improve their antinutritive properties [J]. Comprehensive Reviews in Food Science and Food Safety, 2018,17(1):82-103.
[6] Li E, Bolser D G, Kroll K J, et al. Comparative toxicity of three phenolic compounds on the embryo of fathead minnow, Pimephales promelas [J]. Aquat Toxicol, 2018,201:66-72.
[7] Silva N, de Macedon A C, Pinheiro A D T, et al. Phenol biodegradation by Candida tropicalis ATCC 750immobilized on cashew apple bagasse [J]. Journal of Environmental Chemical Engineering, 2019,7(3): 103076.
[8] Villegas L G C, Mashhadi N, Chen M, et al. A short review of techniques for phenol removal from wastewater [J]. Current Pollution Reports, 2016,2(3):157-167.
[9] Safwat S M, Medhat M, Abdel-Halim H. Adsorption of phenol onto aluminium oxide and zinc oxide: A comparative study with titanium dioxide [J]. Separation Science and Technology, 2019,54(17):2840- 2852.
[10] Sun J, Liu X, Zhang F S, et al. Insight into the mechanism of adsorption of phenol and resorcinol on activated carbons with different oxidation degrees [J]. Colloids and Surfaces a-Physicochemical and Engineering Aspects, 2019,563:22-30.
[11] Tao J Y, Li C, Li J, et al. Multi-step separation of different chemical groups from the heavy fraction in biomass fast pyrolysis oil [J]. Fuel Processing Technology, 2020,202:106366.
[12] Mohammadi S, Kargari A, Sanaeepur H, et al. Phenol removal from industrial wastewaters: A short review [J]. Desalination and Water Treatment, 2015,53(8):2215-2234.
[13] Valdes C, Alzate-Morales J, Osorio E, et al. Characterization of the two-step reaction mechanism of phenol decomposition by a Fenton reaction [J]. Chemical Physics Letters, 2015,640:16-22.
[14] Fenton H J H. LXXIII.—Oxidation of tartaric acid in presence of iron [J]. Journal of the Chemical Society Transactions, 1894,65:899-910.
[15] Qian X F, Wu Y W, Kan M, et al. FeOOH quantum dots coupled g-C3N4 for visible light driving photo- Fenton degradation of organic pollutants [J]. Applied Catalysis B-Environmental, 2018,237:513-520.
[16] Ambika S, Devasena M, Nambi I M. Assessment of meso scale zero valent iron catalyzed Fenton reaction in continuous-flow porous media for sustainable groundwater remediation [J]. Chemical Engineering Journal, 2018,334:264-272.
[17] Feng F, Guo B, Cao Q, et al. Degradation of levofloxacin by electro- Fenton with CNT supported nano-iron cathode. [J]. China Environmental Science, 2024,44(10):5513-5521.
[18] Xu B, Zhang S L, Gao Y X, et al. Degradation of methyl orange by graphene three-dimensional electrode-electro Fenton system [J]. China Environmental Science, 2020,40(10):4385-4394.
[19] Kong Q P, Wu H Z, Liu L, et al. Solubilization of polycyclic aromatic hydrocarbons (PAHs) with phenol in coking wastewater treatment system: Interaction and engineering significance [J]. Science of the Total Environment, 2018,628-629:467-473.
[20] Lei Z C, Feng W M, Feng C H, et al. Nitrified coke wastewater sludge flocs: an attractive precursor for N,S dual-doped graphene-like carbon with ultrahigh capacitance and oxygen reduction performance [J]. Journal of Materials Chemistry A, 2017,5(5):2012-2020.
[21] Zhang Y P, Zhang J L, Wu J J, et al. Degradation of phenol by ultrasound-assisted heterogeneous fenton-like catalytic oxidation [J]. China Environmental Science, 2016,36(12):3665-3671.
[22] Mousset E, Frunzo L, Esposito G, et al. A complete phenol oxidation pathway obtained during electro-Fenton treatment and validated by a kinetic model study [J]. Applied Catalysis B-Environmental, 2016,180: 189-198.
[23] Pliego G, Garcia-Munoz P, Zazo J A, et al. Improving the Fenton process by visible LED irradiation [J]. Environmental Science and Pollution Research, 2016,23(23):23449-23455.
[24] Babuponnusami A, Muthukumar K. A review on Fenton and improvements to the Fenton process for wastewater treatment [J]. Journal of Environmental Chemical Engineering, 2014,2(1):557-572.
[25] Garcia-Segura S, Bellotindos L M, Huang Y H, et al. Fluidized-bed Fenton process as alternative wastewater treatment technology-A review [J]. Journal of the Taiwan Institute of Chemical Engineers, 2016,67:211-225.
[26] Nidheesh P V. Heterogeneous Fenton catalysts for the abatement of organic pollutants from aqueous solution: A review [J]. Royal Society of Chemistry Advances, 2015,5(51):40552-40577.
[27] Cun J, Tian S L, Wang Q, et al. Photo-assisted degradation of rhodamine B by Ferrocene-catalyzed heterogeneous Fenton-like reaction [J]. China Environmental Science, 2013,33(6):1011-1016.
[28] Pan J M, Gong X B, Chen Y, et al. Research on the oxidative degradation of 2,4-dichlorophenol in water by Fe0-CNTs-Cu activation [J]. China Environmental Science, 2021,41(6):2657-2664.
[29] Zhang L, Ye H, Zhao L, et al. Design of isolated iron species for Fenton reactions: lyophilization beats calcination treatment [J]. Chemical communications (Cambridge, England) 2015,51(95):16936- 16939.
[30] Lu P. Spectrophotometric determination of hydrogen peroxide in Fenton advanced oxidation systems by potassium titanium oxalate spectrophotometry [J]. Architectural Engineering Technology and Design, 2014,8:582-582.
[31] Scrocco M. Satellite structure in the x-ray photoelectron spectra of Fe(III) halides: Evidence of multielectron excitation and multiplet structure [J]. Physical Review B, 1981,23(9):4381-4390.
[32] Fujimori A, Saeki M, Kimizuka N, et al. Photoemission satellites and electronic structure of Fe2O3 [J]. Physical Review B: Condensed Matter, 1986,34(10):7318-7328.
[33] Huang Y N, Havenga E A. Why do zeolites with LTA structure undergo reversible amorphization under pressure? [J]. Chemical Physics Letters, 2001,345(1/2):65-71.
[34] Huang L, Wang S, Chen H, et al. Isolated iron/polyether sulfone catalytic membranes for rapid phenol removal [J]. Journal of Applied Polymer Science, 2021,139(3):51508.
[35] Hou L W, Zhang Q H, Jerome F, et al. Shape-controlled nanostructured magnetite-type materials as highly efficient Fenton catalysts [J]. Applied Catalysis B-Environmental, 2014,144:739-749.
[36] Blanco L, Hermosilla D, Merayo N, et al. Assessing the use of zero-valent iron microspheres to catalyze Fenton treatment processes [J]. Journal of the Taiwan Institute of Chemical Engineers, 2016,69: 54-60.
[37] Gao P, Song Y, Hao M, et al. An effective and magnetic Fe2O3- ZrO2catalyst for phenol degradation under neutral pH in the heterogeneous Fenton-like reaction [J]. Separation and Purification Technology, 2018,201:238-243.
[38] Zou J, Ma J, Chen L, et al. Rapid acceleration of ferrous iron/ peroxymonosulfate oxidation of organic pollutants by promoting Fe(III)/Fe(II) cycle with hydroxylamine [J]. Environmental Science & Technology, 2013,47(20):11685-11691.
[39] Zhang Y J, Zhang L, Ma X F, et al. Degradation of orange IV dye solution catalyzed by PVDF/Fe3+-TiO2 catalytic membrane in the presence of H2O2 [J]. Advanced Materials Research, 2010,150-151: 1705-1709.
[40] Zhang L-P, Liu Z, Faraj Y, et al. High-flux efficient catalytic membranes incorporated with iron-based Fenton-like catalysts for degradation of organic pollutants [J]. Journal of Membrane Science, 2019,573:493-503.
[41] Huang Z H, Zhang X, Wang Y X, et al. Fe(3)O(4)/PVDF catalytic membrane treatment organic wastewater with simultaneously improved permeability, catalytic property and anti-fouling [J]. Environmental Research, 2020,187:109617. |
|
|
|
