|
|
Preparation of activated carbon from waste tire pyrolysis carbon black and its treatment of dyeing wastewater |
LIU Jun, CHEN Yun-nen, NIE Jin-xia |
Jiangxi Key Laboratory of Mining & Metallurgy Environmental Pollution Control, Jiangxi University of Science and Technology, Ganzhou 341000, China |
|
|
Abstract China is the world's largest consumer of rubber, the annual production of more than 400million waste tires. Pyrolysis of waste tyre is a recycling route with high value-added and environmentally friendly. The higher color of dye wastewater has a serious impact on the ecological environment. In this paper, H2SO4 and NaOH were used to modify the pyrolytic carbon black of waste tire. The experimental results showed that when the ratio of carbon black to H2SO4 was 1g/15mL, the best decolorization rate of acid lake blue solution was obtained over HBC. Also, NBC obtained with the ratio of carbon black to NaOH 1g/10mL was good for treating basic lake blue solution. The stronger the acidity of the solution, the better the decolorization effect of HBC on the acid lake blue solution. On the contrary, the stronger the alkalinity of the solution, the better the NBC on the basic lake blue solution. In addition, the adsorption process of acid lake blue over HBC and alkaline lake blue over NBC was very close. The whole adsorption reaction was very fast. After 20min, the adsorption equilibrium was basically reached. The adsorption process of acid lake blue over HBC and alkaline lake blue over HBC conform to the pseudo second-order kinetic equation. The properties of scanning electron microscope, infrared spectrum and specific surface area of solid materials before and after modification were analyzed.
|
Received: 20 June 2018
|
|
|
|
|
[1] |
杨广巍.我国废轮胎循环利用现状研究[J]. 中国轮胎资源综合利用, 2018,(1):43-47.
|
[2] |
Ahmed Belgacem, Rachid Rebiai, Hocine Hadoun et al. The removal of uranium (VI) from aqueous solutions onto activated carbon developed from grinded used tire[J]. Environ. Sci. Pollut. Res., 2014, 21:684-694.
|
[3] |
韩飞,李治琨.日本的废旧轮胎的再循环利用技术[J]. 综合利用, 2002,(4):45-47.
|
[4] |
陆永其.我国与发达国家废橡胶资源利用比较[J]. 中国橡胶, 2014, 30(17):11-14.
|
[5] |
李赓.再生炭黑橡胶补强性能的研究[D]. 杭州:浙江大学, 2006.
|
[6] |
陈守燕.废轮胎热解特性的试验研究[D]. 济南:山东大学, 2005.
|
[7] |
朱金华.面向轮胎行业逆向物流处理中心的选址规划[D]. 济南:山东大学, 2006.
|
[8] |
金晶.废轮胎热解炭脱味降灰研究[D]. 上海:华东理工大学, 2011.
|
[9] |
苏州建再生资源产业园,回收网点覆盖城区10万t旧瓶子废轮胎有家可归[J]. 中国环境科学, 2011,31(9):1522.
|
[10] |
周作艳,夏琳,王军晓,等.废轮胎热解炭黑的改性及应用研究进展[J]. 弹性体, 2016,26(6):79-82.
|
[11] |
Duan P, Jin B, Xu Y, et al. Co-pyrolysis of microalgae and waste rubber tire in supercritical ethanol[J]. Chemical Engineering Journal, 2015,269:262-271.
|
[12] |
周作艳,夏琳,王军晓,等.废轮胎热解炭黑在天然橡胶中的应用研究[J]. 橡胶工业, 2018,65(1):56-59.
|
[13] |
Ivan M, Matteo O, Manuela A, et al. Full factorial experimental design to study the devulcanization of ground tire rubber in supercritical carbon dioxide[J]. The Journal of Supercritical Fluids, 2014,92:249-256.
|
[14] |
ANDREA U, BARBARA S, EMMA C, et al. Carbon from microwave assisted pyrolysis of waste tires[J]. Journal of Analytical and Applied Pyrolysis, 2013,104:396-404.
|
[15] |
周龙.轮胎胶粉微波热解特性试验研究[D]. 济南:山东大学, 2014.
|
[16] |
温沁雪,王进,郑明明,等.印染废水深度处理技术的研究进展及发展趋势[J]. 化工环保, 2015,35(4):363-369.
|
[17] |
张腾,王勇梅,彭昌盛,等.染料废水的处理方法及研究进展[J]. 环保科技, 2016,22(1):36-40.
|
[18] |
魏金枝,陈芳妮,孙晓君,等.氨基修饰磁性氧化石墨烯吸附离子型染料性能[J]. 中国环境科学, 2016,36(7):2020-2026.
|
[19] |
马红霞,张菁菁,郑艳军,活性炭应用于印染废水处理及其回收现状[J]. 纺织科技进展, 2017,(5):34-38.
|
[20] |
李立清,石瑞,顾庆伟,等.酸改性活性炭吸附甲苯的性能研究[J]. 2013,40(5):92-98.
|
[21] |
刘寒冰,杨兵,薛南冬.酸碱改性活性炭及其对甲苯吸附的影响[J]. 环境科学, 2016,37(9):3670-3678.
|
|
|
|