活化方式对过硫酸盐强化剩余污泥发酵的影响

Abstract
Figure/Table
References (29)
Related Citation (15)

Download: PDF (538 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract

Persulfate (S₂O₈^2-) and its activations were investigated, including ferrous (Fe²⁺), zero-valent iron (ZVI) and ultrasonic (US), on waste activated sludge (WAS) disintegration and acidification. Experimental results showed that S₂O₈^2- effectively disintegrated WAS flocs matrix and further enhanced short-chain fatty acids (SCFAs) production, compared with that obtained from un-pretreated WAS. In addition, activated S₂O₈^2- presented better WAS hydrolysis and acidification performance over un-activated S₂O₈^2- test. The lysis rates of Fe²⁺, ZVI and US activated S₂O₈^2- groups reached to 42.6%, 36.5% and 32.9%, respectively, which were about 10.6%~20.3% higher than that obtained in the non-activated test (22.3%). The maximum SCFAs concentration in the aforementioned three activated tests were 8052, 6613, 4996mg COD/L, respectively, while that was only 3296mg COD/L in non-activated test. Furthermore, the release of organics and the distribution of generated SCFAs were also affected by S₂O₈^2- activations. From the environmental and economic perspective, the S₂O₈^2-+Fe²⁺ system played more significant role for enhancing the SCFAs recovery from WAS fermentation.

Key words： waste activated sludge (WAS) persulfate activation methods anaerobic fermentation short-chain fatty acids (SCFAs)

Received: 07 November 2018

PACS:

X705

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	FAN Ya-xin
	LIU Hong-yan
	PAN Ling-feng
	ZHOU Ai-juan
	YUE Xiu-ping

Cite this article:

FAN Ya-xin,LIU Hong-yan,PAN Ling-feng等. Enhancement of waste activated sludge acidification by persulfate: Role of activation methods[J]. CHINA ENVIRONMENTAL SCIENCECE, 2019, 39(6): 2460-2466.

URL:

http://www.zghjkx.com.cn/EN/ OR http://www.zghjkx.com.cn/EN/Y2019/V39/I6/2460

[1]	Park B, Ahn J H, Kim J, et al. Use of microwave pretreatment for enhanced anaerobiosis of secondary sludge[J]. Water Science and Technology, 2004,50(9):17-23.
[2]	Eastman J A, Ferguson J F. Solubilization of Particulate Organic Carbon during the Acid Phase of Anaerobic Digestion[J]. Water Pollution Control Federation, 1981,53(3):352-366.
[3]	周爱娟.预处理促进剩余污泥发酵制取短链脂肪酸的效能及机制研究[D]. 哈尔滨:哈尔滨工业大学, 2014.Zhou A J. Short-chain fatty acids production from waste activated sludge ermentation stimulated by pretreatments[D]. Harbin:Harbin Institute of Technology, 2014.
[4]	Zhou A, Luo H, Varrone C, et al. Enhanced anaerobic digestibility of waste activated sludge by plant-derived biosurfactant[J]. Process Biochemistry, 2015,47(9):1413-1421.
[5]	Ruiz-Hernando M, Cabanillas E, Labanda J, et al. Ultrasound, thermal and alkali treatments affect extracellular polymeric substances (EPSs) and improve waste activated sludge dewatering[J]. Process Biochemistry, 2015,50(3):438-446.
[6]	Yu Q, Jin X, Zhang Y. Sequential pretreatment for cell disintegration of municipal sludge in a neutral Bio-electro-Fenton system[J]. Water Research, 2018,135:44-56.
[7]	Shi Y, Yang J, Yu W, et al. Synergetic conditioning of sewage sludge via Fe2+/persulfate and skeleton builder:Effect on sludge characteristics and dewaterability[J]. Chemical Engineering Journal, 2015,270:572-581.
[8]	Zhou X, Wang Q, Jiang G, et al. A novel conditioning process for enhancing dewaterability of waste activated sludge by combination of zero-valent iron and persulfate[J]. Bioresource Technology, 2015,185:416-420.
[9]	徐文迪,常沙,明铁山,等.基于硫酸根自由基(SO4-·)的污泥预处理技术[J]. 环境工程学报, 2018,12(5):1528-1535.Xu W D, Chang S, Ming T S, et al. Pretreatment technology of sewage of sludge with sulfate radical (SO4-·)[J]. Chinese Journal of Environmental Engineering, 2018,12(5):1528-1535.
[10]	Neta P, Madhavan V, Zemel H, et al. Rate constants and mechanism of reaction of sulfate radical anion with aromatic compounds[J]. Journal of the American Chemical Society, 1977,99(1):163-164.
[11]	刘昌庚,伍斌,谢四才.Fe(Ⅱ)活化过一硫酸盐氧化调理剩余活性污泥[J]. 中国环境科学, 2017,37(10):3794-3799.Liu C G, Wu B, Xie S C. Conditioning of excess activate sludge by Fe(Ⅱ)-activated peroxymonosulfate oxidation[J]. China Environmental Science, 2017,37(10):3794-3799.
[12]	Ren W, Zhou Z, Zhu Y, et al. Effect of sulfate radical oxidation on disintegration of waste activated sludge[J]. International Biodeterioration & Biodegradation, 2015,104:384-390.
[13]	Shi P, Su R, Wan F, et al. Co3O4 nanocrystals on graphene oxide as a synergistic catalyst for degradation of Orange Ⅱ in water by advanced oxidation technology based on sulfate radicals[J]. Applied Catalysis B Environmental, 2012,123-124(12):265-272.
[14]	Zhen G, Lu X, Zhao Y, et al. Enhanced dewaterability of sewage sludge in the presence of Fe(Ⅱ)-activated persulfate oxidation[J]. Bioresource Technology, 2012,116(4):259-265.
[15]	Shi Y, Yang J, Liang S, et al. Principal component analysis on sewage sludge characteristics and its implication to dewatering performance with Fe2+/persulfate-skeleton builder conditioning[J]. International Journal of Environmental Science and Technology, 2016,13(9):2283-2292.
[16]	Song K, Zhou X, Liu Y, et al. Improving dewaterability of anaerobically digested sludge by combination of persulfate and zero valent iron[J]. Chemical Engineering Journal, 2016,295:436-442.
[17]	Zhen G, Lu X, Su L, et al. Unraveling the catalyzing behaviors of different iron species (Fe2+ vs. Fe0) in activating persulfate-based oxidation process with implications to waste activated sludge dewaterability[J]. Water Research, 2018,134:101-114.
[18]	Zhen G, Lu X, Wang B, et al. Synergetic pretreatment of waste activated sludge by Fe(Ⅱ)-activated persulfate oxidation under mild temperature for enhanced dewaterability[J]. Bioresource Technology, 2012,124(9):29-36.
[19]	周宁.超声/过硫酸盐法去除水中卡马西平及腐殖酸的研究[D]. 武汉:华中科技大学, 2015.Zhou N. Study on the degradation of carbamazepine and humic acid in water using ultrasonic combined with persulfate method[D]. Wuhan:Huazhong University of Science and Technology, 2015.
[20]	刘佳露,卢伟,张凤君,等.活化过硫酸盐氧化地下水中苯酚的动力学研究[J]. 中国环境科学, 2015,35(9):2677-2681.Liu J L, Lu W, Zhang F J, et al. Kinetics study of activated persulfate oxidation of phenol in ground water[J]. China Environmental Science, 2015,35(9):2677-2681.
[21]	田凯勋,杨超,肖泉,等.超声强化零价铁/过硫酸钾体系降解2,4,6-三氯苯酚废水[J]. 中国环境科学, 2017,37(10):3729-3734.Tian K X, Yang C, Xiao Q, et al. Degradation of 2,4,6-TCP in an ultrasound-enhanced zero-valent iron/potassium persulfate system[J]. China Environmental Science, 2017,37(10):3729-3734.
[22]	何洋洋,唐素琴,康婷婷,等.响应面法优化硫酸根自由基高级氧化深度处理渗滤液生化尾水[J]. 中国环境科学, 2015,35(6):1749-1755.He Y Y, Tang S Q, Kang T T, et al. Optimization of sulfate radical-based advanced oxidation process using response surface methodology for treating effluent from biological treatment of landfill leachate[J]. China Environmental Science, 2015,35(6):1749-1755.
[23]	Chakma S, Praneeth S, Moholkar V S. Mechanistic investigations in sono-hybrid (ultrasound/Fe2+/UVC) techniques of persulfate activation for degradation of Azorubine[J]. Ultrasonics Sonochemistry, 2017,38:652-663.
[24]	国家环境保护总局.水和废水监测分析方法[M]. 北京:中国环境科学出版社, 2002.Nation Enviromental protection Administration. Water and wastewater monitoring and analysis methods[M]. Beijing:China Enviromental Science Press, 2002.
[25]	Zhou A, Zhang J, Wen K, et al. What could the entire cornstover contribute to the enhancement of waste activated sludge acidification? Performance assessment and microbial community analysis[J]. Biotechnology for Biofuels, 2016,9(1):241-254.
[26]	Yang J, Liu X, Wang D, et al. Mechanisms of peroxymonosulfate pretreatment enhancing production of short-chain fatty acids from waste activated sludge[J]. Water Research, 2019,148:239-249.
[27]	Liang C, Lai M C. Trichloroethylene Degradation by Zero Valent Iron Activated Persulfate Oxidation[J]. Environmental Engineering Science, 2008,25(7):1071-1078.
[28]	Wang S, Zhou N. Removal of carbamazepine from aqueous solution using sono-activated persulfate process[J]. Ultrasonics Sonochemistry, 2016,29:156-62.
[29]	Yang Q, Zhong Y, Zhong H, et al. A novel pretreatment process of mature landfill leachate with ultrasonic activated persulfate:Optimization using integrated Taguchi method and response surface methodology[J]. Process Safety and Environmental Protection, 2015,98:268-275.