|
|
|
| Emission characteristics of volatile organic compounds (VOCs) from typical plywood industry |
| Lü Da-qi1,2, LU Si-hua1,2, SHAO Min1,2, WANG Ling-feng3, REN Jie1,2 |
1. College of Environmental Sciences and Engineering, Peking University, Beijing 100871, China;
2. State Joint Key Laboratory of Environmental Simulation and Pollution Control, Beijing 100871, China;
3. Heze Institute of Environmental Science, Heze 274200, China |
|
|
|
|
Abstract VOCs emission characteristics of typical plywood industry in Shandong were determined using SUMMA canister-GC- MS/FID analysis system. The results showed that alkanes (13.81%~39.16%), oxygenated VOCs (5.68%~36.06%) and aromatics (3.58%~48.12%) were the main emission components of hot pressing and gluing processes, while exhaust gas discharges were dominated by oxygenated VOCs(6.49%~83.88%). The characterized VOC emissions compositions in each process were different; alkenes and alkynes(27.12%~39.38%) and aromatics(32.47%~45.63%) were the high OFP components of hot pressing and gluing process, and oxygenated VOCs(52.82%) in the exhaust gas discharge contributed the most to O3 generation. Based on the SOAP evaluation, aromatics(97.08%~98.03%) were the main active components in all processes; also, the emission factor of VOCs in the Shandong plywood manufacturing industry was measured to be 0.89g VOCs/m3 plywood.
|
|
Received: 11 October 2019
|
|
|
|
|
|
| [1] |
Huang R J, Zhang Y L, Bozzetti C, et al. High secondary aerosol contribution to particulate pollution during haze events in China[J]. Nature, 2014,514(7521):218-222.
|
| [2] |
Ding A J, Fu C B, Yang X Q, et al. Ozone and fine particle in the western Yangtze River Delta:an overview of 1yr data at the SORPES station[J]. Atmospheric Chemistry and Physics, 2013,13(11):5813-5830.
|
| [3] |
Li K, Jacob D J, Liao H, et al. Anthropogenic drivers of 2013~2017 trends in summer surface ozone in China[J]. Proceedings of the National Academy of Sciences, 2019,116(2):422-427.
|
| [4] |
Shao M, Zhang Y H, Zeng L M, et al. Ground-level ozone in the Pearl River Delta and the roles of VOC and NOx in its production[J]. Journal of Environmental Management, 2009,90(1):512-518.
|
| [5] |
Kroll J H, Seinfeld J H. Chemistry of secondary organic aerosol:Formation and evolution of low-volatility organics in the atmosphere[J]. Atmospheric Environment, 2008,42(16):3593-3624.
|
| [6] |
莫梓伟,邵敏,陆思华.中国挥发性有机物(VOCs)排放源成分研究进展[J]. 环境科学学报, 2014,34(9):2179-2189. Mo Z W, Shao M, Lu S H. Review on volatile organic compounds (VOCs) source profiles measured in China[J]. Acta Scientiae Circumstantiae, 2014,34(9):2179-2189.
|
| [7] |
Zhang Z J, Yan X Y, Gao F L, et al. Emission and health risk assessment of volatile organic compounds in various processes of a petroleum refinery in the Pearl River Delta, China[J]. Environmental Pollution, 2018,238:452-461.
|
| [8] |
王家德,吕建璋,李文娟,等.浙江省包装印刷行业挥发性有机物排放特征及排放系数[J]. 环境科学, 2018,39(8):3552-3556. Wang J D, Lv J Z, Li W J, et al. Pollution characteristics and emission coefficients of volatile organic compounds from the packaging and printing industry in Zhejiang Province[J]. Environmental Science, 2018,39(8):3552-3556.
|
| [9] |
张晓坤,巫国富,胡显宁,等.胶合板生产技术[M]. 北京:中国林业出版社, 2014:1-3. Zhang X K, Wu G F, Hu X N, et al. Plywood production technology[M]. Beijing:China Forestry Publishing House, 2014:1-3.
|
| [10] |
叶代启.工业挥发性有机物的排放与控制[M]. 北京:科学出版社, 2017:62-63. Ye D Q. Emission and control of industrial volatile organic compounds[M]. Beijing:Science Press, 2017:62-63.
|
| [11] |
何中凯.人造板VOC散发控制:原理、方法和效果[D]. 清华大学, 2011. He Z K. Control of VOC emissions from wood-based panels:Principle, method and effect[D]. Tsinghua University, 2011.
|
| [12] |
张春洋,马永亮.UV_(254nm+185nm)光照降解气态甲苯的实验研究[J]. 中国环境科学, 2011,31(6):898-903. Zhang C Y, Ma Y L. Experimental study on UV_(254nm +185nm) phtotodegradation of gaseous toluene[J]. China Environmental Science, 2011,31(6):898-903.
|
| [13] |
李贞燕,陈冰,平静.紫外光(UV)光解油田采出水中多环芳烃[J]. 环境工程学报, 2014,8(6):2267-2270. Li Z Y, Chen B, Ping J. Ultraviolet(UV) photolysis of polycyclic aromatic hydrocarbons in produced water[J]. Chinese Journal of Environmental Engineering, 2014,8(6):2267-2270.
|
| [14] |
Chen J M, Cheng Z W, Jiang Y F, et al. Direct VUV photodegradation of gaseous α-pinene in a spiral quartz reactor:Intermediates, mechanism, and toxicity/biodegradability assessment[J]. Chemosphere, 2010,81(9):1053-1060.
|
| [15] |
Carter W P. SAPRC atmospheric chemical mechanisms and VOC reactivity scales[R]. http://www.engr.ucr.edu/~carter/SAPRC/, 2013.
|
| [16] |
Kleindienst T E, Jaoui M, Lewandowski M, et al. Estimates of the contributions of biogenic and anthropogenic hydrocarbons to secondary organic aerosol at a southeastern US location[J]. Atmospheric Environment, 2007,41(37):8288-8300.
|
| [17] |
周杨.华北地区气溶胶理化特性、来源解析及实验室模拟[D]. 济南:山东大学, 2012. Zhou Y. Characteristics and sources of aerosol in North China Plain and smog chamber simulation[D]. Ji'nan:Shandong University, 2012.
|
| [18] |
Sato K, Takami A, Kato Y, et al. AMS and LC/MS analyses of SOA from the photooxidation of benzene and 1,3,5-trimethylbenzene in the presence of NOx:effects of chemical structure on SOA aging[J]. Atmospheric Chemistry and Physics, 2012,12(10):4667-4682.
|
| [19] |
Derwent R G, Jenkin M E, Utembe S R, et al. Secondary organic aerosol formation from a large number of reactive man-made organic compounds[J]. Science of the Total Environment, 2010,408(16):3374-3381.
|
| [20] |
生态环境部.《大气挥发性有机物源排放清单编制技术指南(试行)》(征求意见稿)[Z]. 2014. Ministry of Ecology and Environment. Technical guidelines for the source emission inventories of atmospheric volatile organic compounds (trial)[Z]. 2014.
|
| [21] |
赵锐,黄络萍,张建强,等.成都市典型溶剂源使用行业VOCs排放成分特征[J]. 环境科学学报, 2018,38(3):1147-1154. Zhao R, Huang L P, Zhang J Q, et al. Emissions characteristics of volatile organic compounds (VOCs) from typical industries of solvent use in Chengdu City[J]. Acta Scientiae Circumstantiae, 2018,38(3):1147-1154.
|
|
|
|
