三段A/O工艺处理发制品产业集聚区综合废水

摘要
图/表
参考文献(38)
相关文章 (15)

全文: PDF (445 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要

利用三段A/O工艺作为发制品产业集聚区综合废水生物处理单元，探讨了不同进水流量分配比和污泥回流比下COD、TN、PO₄^3--P的去除性能和微生物群落特征.结果表明，在进水流量分配比60%：25%：15%、污泥回流比75%、缺氧区与好氧区容积比1：1、SRT 20d、HRT 16h条件下，三段A/O工艺处理综合废水后出水TN平均浓度14.85mg/L，COD浓度低于40m/L；此时PO₄^3--P去除率达到最大值，为56.21%.参与处理综合废水的主要门水平微生物Proteobacteria和Bacteroidetes的相对丰度是45.63%~60.13%和16.65%~30.55%.Denitratisoma、Thauera、uncultured-f-Saprospiraceae和Sulfuritalea等优势菌属相对丰度的增加，是三段A/O工艺TN去除率随第一分段进水流量分配比增大或污泥回流比降低而提高的本质体现.

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	肖才林
	沈建华
	杨洋
	李睿华

关键词 ：多段A/O工艺, 发制品, 进水流量分配, 污泥回流, 脱氮除磷

Abstract：

A three step feed A/O process was utilized as a secondary biological treatment unit to treat comprehensive wastewater from hair product production cluster area. The removals of chemical oxygen demand (COD), TN, PO₄^3--P and the features of microbial communities were investigated at different inflow distribution and sludge return. With volume distribution ratio of anoxic and oxic zone 1:1, solid residence time (SRT) 20d, hydraulic retention time (HRT) 16h, inflow distribution and sludge return were 60%:25%:15% and 75%, average TN and COD concentrations were 14.85mg/L and less than 40mg/L, respectivekly, in effluents from the three step feed A/O process. At the same time, removal efficiency of PO₄^3--P reached the maximum value of 56.21%. Relative abundances of Proteobacteria and Bacteroidetes, the dominating phyla for treating comprehensive wastewater, were 45.63%~60.13% and 16.65%~30.55%. The increasing relative abundances of Denitratisoma, Thauera, uncultured -f -Saprospiraceae, Sulfuritalea, et al. was the essential embodiment that removal efficiency of TN increased with the increase of inflow distribution in the first step or the decrease of sludge return.

Key words： step feed A/O process hair product inflow distribution sludge return nitrogen and phosphorus removal

收稿日期: 2017-09-24

X506

基金资助:

国家水体污染控制与治理科技重大专项（2015ZX07204-002）

通讯作者: 李睿华,副教授,liruihua@nju.edu.cn E-mail: liruihua@nju.edu.cn

作者简介: 肖才林(1990-),男,江西赣州人,助理工程师,硕士研究生,主要从事水体污染控制研究.发表论文6篇.

引用本文:

肖才林, 沈建华, 杨洋, 李睿华. 三段A/O工艺处理发制品产业集聚区综合废水[J]. 中国环境科学, 2018, 38(4): 1304-1311. XIAO Cai-lin, SHEN Jian-hua, YANG Yang, LI Rui-hua. Utilizing three step feed A/O process to treate comprehensive wastewater from hair product production cluster area. CHINA ENVIRONMENTAL SCIENCECE, 2018, 38(4): 1304-1311.

链接本文:

http://www.zghjkx.com.cn/CN/ 或 http://www.zghjkx.com.cn/CN/Y2018/V38/I4/1304

[1]	GB18918-2002城镇污水处理厂污染物排放标准[S].
[2]	郭长虹,刘怀胜,潘峥.发制品加工废水处理工艺的试验研究[J]. 工业水处理, 2007,27(10):48-50.
[3]	Foess G W, Jarrett P, Williams B G. Economic benefits of chemically assisted primary treatment step feed and anoxic zones[J]. Proceedings of the Water Environment Federation, 2003,1(1):313-323.
[4]	李常留,张兴文,徐鹏飞.阶段流入式多级A/O生物脱氮工艺设计及应用[J]. 环境工程, 2010,28(2):45-48.
[5]	高俊发,王骊,关江,等,分段进水多级A/O生物脱氮工艺设计研究[J]. 环境工程, 2007,25(6):11-15.
[6]	Fortin J, Pitt P, O'Connor P, et al. Newtown Creek Demonstration Project Wet Weather Operating Strategies[J]. Water Practice, 2008,2(4):1-17.
[7]	李建政,赵博玮,赵宗亭.多段A/O工艺处理制革废水一级生化出水的效能[J]. 中国环境科学, 2014,34(1):123-129.
[8]	肖才林,沈建华,李甫昌,等.连续流分段进水生物脱氮工艺研究进展[J]. 水处理技术, 2016,42(7):1-5.
[9]	国家环境保护总局《水和废水监测分析方法》编委会.水和废水监测分析方法[M]. 4版.北京:中国环境科学出版社, 2002:211-281.
[10]	Wang Z B, Miao M S, Kong Q, et al. Evaluation of microbial diversity of activated sludge in a municipal wastewater treatment plant of northern China by high-throughput sequencing technology[J]. Desalination and Water Treatment, 2016,3:1-6.
[11]	徐伟超,蒙小俊,尹莉,等.焦化废水活性污泥中降解硫氰化物细菌种群多样性分析[J]. 环境科学, 2016,37(7):2689-2695.
[12]	王敏,张智,陈杰云,等.不同流量分配比对多级A/O工艺去除有机物及脱氮的影响[J]. 环境工程学报, 2013,7(4):1430-1434.
[13]	张国珍,高小波,武福平,等.流量分配比对改良型多级A/O工艺去除污染物的影响[J]. 环境工程学报, 2016,10(3):1165-1170.
[14]	Wang W, Wang S, Peng Y, et al. Enhanced Biological Nutrients Removal in Modified Step-feed Anaerobic/Anoxic/Oxic Process[J]. Chinese Journal of Chemical Engineering, 2009,17(5):840-848.
[15]	王冰.四级三相式生物流化床分段进水脱单效能研究[D]. 哈尔滨:哈尔滨工业大学, 2011.
[16]	李思敏,郝同,王若冰,等.改良型A2/O工艺在低温不同污泥负荷下的运行研究[J]. 中国给水排水, 2014,30(17):64-68.
[17]	Vaiopoulou E, Melidis P, Aivasidis A. An activated sludge treatment plant for integrated removal of carbon, nitrogen and phosphorus[J]. Desalination, 2007,211:192-199.
[18]	Zhu G, Peng Y, Wang S. Effect of influent flow rate distribution on the performance of step-feed biological nitrogen removal process[J]. Chemical Engineering Journal, 2007,131:319-328.
[19]	Vaiopoulou E, Aivasidis A. A modified UCT method for biological nutrient removal:configuration and performance[J]. Chemosphere, 2008,72:1062-1068.
[20]	张洪雷,方舟,艾力江×努尔拉,等.两级A/O填料型MBR工艺的脱氮除磷效果[J]. 中国给水排水, 2013,29(13):42-46.
[21]	Ge S, Peng Y, Wang S, et al. Enhanced nutrient removal in a modified step feed process treating municipal wastewater with different inflow distribution ratios and nutrient ratios[J]. Bioresource technology, 2010,101:9012-9019.
[22]	Tang C, Kuo G, Weiss J. Maximum Nitrogen Removal in the Step-Feed Activated Sludge Process[J]. Water Environment Research, 2007,79:367-374.
[23]	鞠兴华,王社平,王怡,等.遗传算法优化分段进水生物脱氮工艺的流量分配[J]. 中国给水排水, 2006,26(1):89-92.
[24]	毕东苏,郑广宏,陆烽.硝酸盐对富磷剩余污泥厌氧消化的影响试验[J]. 环境工程学报, 2008,2(9):1255-1259.
[25]	龙腾锐,陈垚,周健,等.硝酸盐对磷酸盐还原系统除磷效能的影响[J]. 土木建筑与环境工程, 2009,31(5):127-131/137.
[26]	王伟,彭永臻,殷芳芳,等.改进分段进水A/O生物脱氮工艺强化生物除磷[J]. 环境科学, 2009,30(10):2969-2974.
[27]	葛士建,彭永臻,曹旭,等.改良UCT分段进水工艺处理生活污水性能优化研究[J]. 环境科学, 2011,32(7):2006-2012.
[28]	Ge S, Zhu Y, Lu C, et al. Full-scale demonstration of step feed concept for improving an anaerobic/anoxic/aerobic nutrient removal process[J]. Bioresource technology, 2012,120:305-313.
[29]	Fu C, Yue X, Shi X, et al. Membrane fouling between a membrane bioreactor and a moving bed membrane bioreactor:Effects of solids retention time[J]. Chemical Engineering Journal, 2017,309:397-408.
[30]	Tian H L, Zhao J Y, Zhang H Y, et al. Bacterial community shift along with the changes in operational conditions in a membrane-aerated biofilm reactor[J]. Applied microbiology and biotechnology, 2015,99:3279-3290.
[31]	Wang Z, Huang F, Mei F, et al. Long-term operation of an MBR in the presence of zinc oxide nanoparticles reveals no significant adverse effects on its performance[J]. Journal of Membrane Science, 2014,471:258-264.
[32]	Ma J, Wang Z, He D. Long-term investigation of a novel electrochemical membrane bioreactor for low-strength municipal wastewater treatment[J]. Water Research, 2015,78:98-110.
[33]	Cao S, Du R, Li B, et al. High-throughput profiling of microbial community structures in an ANAMMOX-UASB reactor treating high-strength wastewater[J]. Applied microbiology and biotechnology, 2016,100:6457-6467.
[34]	钱飞跃,王琰,王建芳,等.长期储存亚硝化颗粒污泥的活化及菌群结构变化[J]. 中国环境科学, 2016,36(4):1052-1058.
[35]	Katsou E, Alvarino T, Malamis S, et al. Effects of selected pharmaceuticals on nitrogen and phosphorus removal bioprocesses[J]. Chemical Engineering Journal, 2016,295:509-517.
[36]	Zhou Z, Qiao W, Xing C, et al. Microbial community structure of anoxic-oxic-settling-anaerobic sludge reduction process revealed by 454-pyrosequencing[J]. Chemical Engineering Journal, 2015,266:249-257.
[37]	Guo Y, Peng Y, Wang B, et al. Achieving simultaneous nitrogen removal of low C/N wastewater and external sludge reutilization in a sequencing batch reactor[J]. Chemical Engineering Journal, 2016,306:925-932.
[38]	Lei X, Li Y, Wang G, et al. Phaeodactylibacter luteus sp. nov., isolated from the oleaginous microalga Picochlorum sp.[J]. International journal of systematic and evolutionary microbiology, 2015,65:2666-2670.