典型钢铁企业挥发性有机物排放量测算及组分特征

刘政; 徐晨曦; 陈军辉; 韩丽; 王波; 熊文朋; 梅林德

PDF(596 KB)

中国环境科学 ›› 2020, Vol. 40 ›› Issue (10) : 4292-4303.

大气污染与控制

典型钢铁企业挥发性有机物排放量测算及组分特征

刘政, 徐晨曦, 陈军辉, 韩丽, 王波, 熊文朋, 梅林德

作者信息 +

Emission estimation and component characteristics of volatile organic compounds in typical iron and steel enterprise

LIU Zheng, XU Chen-xi, CHEN Jun-hui, HAN Li, WANG Bo, XIONG Wen-peng, MEI Lin-de

Author information +

文章历史 +

摘要

选取涵盖钢铁炼制全流程的典型企业，综合采用不同核算方法估算比较了该企业挥发性有机物（VOCs）排放结果；并在此基础之上，通过氟聚化合物气袋、SUMMA罐采样及气相色谱质谱联用仪（GC-FID/MS）分析方法，对烧结、焦化、热轧和冷轧等工序废气中VOCs浓度水平及排放特征进行监测.结果表明，整个厂区VOCs年排放量为430.82t，其中工艺有组织排放占66.0%，储罐18.5%；烧结机头和焦炉推焦排放口VOCs及非甲烷总烃（NMHC）浓度高于其他点位；各工序排放的芳香烃占比较高，其中焦化装煤除尘和焦炉推焦排放口芳香烃占90%以上；烧结工序CS₂占比最高（36.6%），其次为苯和甲苯；焦化工序占比靠前的物种为1，2，4-三甲基苯、邻甲乙苯、1，4-二乙基苯、1，2，3-三甲基苯和1，3，5-三甲基苯等；热轧工序与其他工序有一定区别，车间无组织排放芳香烃和烷烃占比均在35%左右，排放靠前的物种除芳香烃外还有高碳烷烃，如十一烷、十二烷和正丁烷等；冷轧工序有组织和无组织排放主要物种较为类似，均为芳香烃物种，如乙基苯、间/对二甲苯、甲苯、苯和邻二甲苯.不同工艺环节排放物种存在一定差异，但主要以焦化副产物（芳香烃）和烧结燃烧产物（CS₂）为主，建议钢铁行业有针对性地加强浓度高、活性高和毒性大的组分控制.

Abstract

This research was performed in a typical steelmaking enterprise, which contained entire process of steel refining. Different methods were applied to estimate the VOCs emission account and the VOCs exhaust concentrations derived from sintering, coking, hot rolling and cold rolling processes were detected by using Teflon/SUMMA canister+GC-FID/MS. The annual VOC emissions from this enterprise were 430.82t in total, 66.0% from controlled emission, and 18.5% from storage tanks. The VOCs concentrations from sintering head and coke pushing outlet were higher than other places. The aromatic hydrocarbons in each process account for a relatively high proportion, which contributed more than 90% in the controlled emission of coking process. The CS₂ exhaust in sintering process was the highest (36.6%), followed by benzene and toluene. The main VOC species in the coking process were 1,2,4-trimethylbenzene, o-ethylbenzene, 1,4-diethylbenzene, 1,2,3-trimethylbenzene and 1,3,5-trimethylbenzene. There were some differences between the hot rolling process and other processes. Aromatics and alkanes emitted from the workshop uncontrolled sources accounted for around 35% respectively. Except the aromatics, high-carbon alkanes such as undecane, dodecane and n-butane were also high emission species. The main VOC species emitted from cold rolling process were similar in controlled and uncontrolled sources, much of them were aromatics, such as ethylbenzene, m-xylene, toluene, benzene and o-xylene. Although, there were some different VOC species detected from different processes, but the main emissions were though coking (aromatic hydrocarbons) and sintering (CS₂). Therefore, we suggested that the high concentration, high activity and high toxicity VOCs should be well controlled in steel manufacturing industry.

导出引用

刘政, 徐晨曦, 陈军辉, 韩丽, 王波, 熊文朋, 梅林德. 典型钢铁企业挥发性有机物排放量测算及组分特征[J]. 中国环境科学. 2020, 40(10): 4292-4303

LIU Zheng, XU Chen-xi, CHEN Jun-hui, HAN Li, WANG Bo, XIONG Wen-peng, MEI Lin-de. Emission estimation and component characteristics of volatile organic compounds in typical iron and steel enterprise[J]. China Environmental Science. 2020, 40(10): 4292-4303

中图分类号： X511

参考文献

[1] Liu T, Li T Y, Zhang Y H, et al. The short-term effect of ambient ozone on mortality is modified by temperature in Guangzhou, China[J]. Atmospheric Environment, 2013,76(3):59-67.
[2] 王倩,陈长虹,王红丽,等.上海市秋季大气VOCs对二次有机气溶胶的生成贡献及来源研究[J]. 环境科学, 2013,34(2):424-433. Wang Q, Chen C H, Wang H L, et al. Forming potential of secondary organic aerosols and sources apportionment of VOCs in autumn of Shanghai, China[J]. Environmental Science, 2013,34(2):424-433.
[3] Liu C M, Xu Z L, Du Y G, et al. Analysis of volatile organic compounds concentrations and variation trends in the air of Changchun. the northeast of China[J]. Atmospheric Environment, 2000,34(26):4459-4466.
[4] 李佳,张晓郁,孙庆宇.唐山市钢铁行业大气污染物排放清单建立[J]. 中国环境监测, 2016,32(5):30-35. Li J, Zhang X Y, Sun Q Y. Research on the Establishment of the Atmospheric Pollutant Emission Inventory of Tangshan Iron and Steel Industry[J]. Environmental Monitoring in China, 2016,32(5):30-35.
[5] 王海风,秦松,姜曦,等.钢铁工业烧结过程VOCs减排研究进展[J]. 钢铁, 2018,53(1):1-7. Wang H F, Qin S, Jiang X, et al. Research development of VOCs emission reduction during iron ore sintering in steel industry[J]. Iron and Steel, 2018,53(1):1-7.
[6] 中华人民共和国生态环境部,关于推进实施钢铁行业超低排放的意见[OE/BL]. http://www.mee.gov.cn/xxgk2018/xxgk/xxgk03/201904/t20190429_701463.html, 2019-04-28.
[7] 伯鑫,赵春丽,吴铁,等.京津冀地区钢铁行业高时空分辨率排放清单方法研究[J]. 中国环境科学, 2015,35(8):2554-256. Bo X, Zhao C L, Wu T, et al. Emission inventory with high temporal and spatial resolution of steel industry in the Beijing-Tianjin-Hebei Region[J]. China Environmental Science, 2015,35(8):2554-256.
[8] Lorenzi A, Rastelli D, Biavati A, et al. Immobilization of iron rich steel industry waste and products characterization[J]. Journal of Environmental Chemical Engineering, 2014,3(1):196-201.
[9] Yu B, Li X, Qiao Y, et al. Low-carbon transition of iron and steel industry in China:Carbon intensity, economic growth and policy Intervention[J]. Journal of Environmental Sciences, 2014.
[10] 马京华.钢铁企业典型生产工艺颗粒物排放特征研究[D]. 重庆:西南大学, 2009. Ma J H. Emission characteristics of particulates from typical production process of iron and steel enterprises[D]. Chongqing:Southwest University, 2009.
[11] Salameh T, Sauvage S, Afif C, et al. Source apportionment vs. emission inventories of non-methane hydrocarbons (NMHC) in an urban area of the Middle East:local and global perspectives[J]. Atmospheric Chemistry and Physics, 2016,16(5):3595-3607.
[12] 盛涛,高松,段玉森,等.典型钢铁企业VOCs污染特征及SOA生成潜势估算[J]. 环境科学研究, 2017,30(12):1979-1988. Sheng T, Gao S, Duan Y S, et al. Characteristics of VOCs in typical iron and steel industry and estimation of secondary organic aerosol formation potential[J]. Research of Environmental Sciences, 2017, 30(12):1979-1988.
[13] 何敏,王幸锐,韩丽.四川省大气固定污染源排放清单及特征[J]. 环境科学学报, 2013,33(11):3127-3137. He M, Wamg X R, Han L. Air pollutant emission inventory and characteristics from stationary sources in Sichuan Province[J]. Acta Scientiae Circumstantiae, 2013,33(11):3127-3137.
[14] 段文娇,郎建垒,程水源,等.京津冀地区钢铁行业污染物排放清单及对PM_2.5影响[J]. 环境科学, 2018,39(4):1445-1456. Duan W J, Liang J L, Chen S Y, et al. Air Pollutant Emission Inventory from Iron and Steel Industry in the Beijing-Tianjin-Hebei Region and Its Impact on PM_2.5[J]. Environmental Science, 2018,39(4):1445-1456.
[15] 何秋生,王新明,盛国英,等.炼焦过程中单环芳烃排放及源特征[J]. 环境科学, 2005,26(5):17-21. He Q S, Wang X M, Sheng G Y, et al. Emission and source characterization of monoaromatic hydrocarbons from coke production[J]. Environmental Science, 2005,26(5):17-21.
[16] 贾记红,黄成,陈长虹,等.炼焦过程挥发性有机物排放特征及其大气化学反应活性[J]. 环境科学学报, 2009,29(5):905-913. Jia J H, Huang C, Chen C H, et al. Emission characterization and ambient chemical reactivity of volatile organic compounds (VOCs) from coking processes[J]. Aeta Scientiae Cirumstantiae, 2009,29(5):905-913.
[17] 王伯光,张远航,邵敏,等.广州地区大气中C2~C9非甲烷碳氢化合物的人为来源[J]. 环境科学学报, 2008,28(7):1430-1440. Wang B G, Zhang Y H, Shao M, et al. Sources apportionment of anthropogenic C2~C9non-methane hydrocarbons in the atmosphere of Guangzhou, China[J]. Acta Scientiae Circumstantiae, 2008,28(7):1430-1440.
[18] 苗沛然.钢铁工业挥发性有机物(VOCs)排放特性研究[J]. 环境与发展, 2017:79-86. Miao P R. Research on VOCs emission characteristics in sintering process[J]. Environmental and Development, 2017:79-86.
[19] 陆海明.炼焦过程中挥发性有机物化学反应活性的研究[J]. 上海化工, 2010,35(5):5-10. Lu H M. Study on Chemical Reactivities of Volatile Organic Compounds Released in Coking Processes[J]. Shanghai Chemical Industry, 35(5):5-10.
[20] 伯鑫,甄瑞卿,屈加豹,等.中国钢铁行业大气污染物排放清单管理系统研究[J]. 环境污染与防治, 2017,39(5):578-82. Bo X, Zhen R Q, Qu J B, et al. Study on the management system of atmospheric pollutant emission inventory for teel industry of China[J]. Environmental Pollution & Control, 2017,39(5):578-582.
[21] 江苏省生态环境厅, 江苏省重点行业挥发性有机物排放量计算暂行办法[EB/OL]. http://hbt.jiangsu.gov.cn/art/2016/7/8/art_1581_6691890.html, 2016-07-08.
[22] Department of Ecology and Environment of Jiangsu Province, Interim Measures of Jiangsu Province for the Calculation of emissions of Volatile organic compounds in key Industries[EB/OL]. http://hbt.jiangsu.gov.cn/art/2016/7/8/art_1581_6691890.html, 2016-07-08.
[23] 中华人民共和国环境保护部,石化行业VOCs污染源排查工作指南[EB/OL]. https://www.docin.com/p-1782390530.html, 2016-11-12.
[24] Ministry of Ecology and Environment of the People's Republic of China, Guidelines for VOCs pollution Source identification in petrochemical industry[EB/OL].
[25] https://www.docin.com/p-1782390530.html, 2016-11-12.
[26] 上海市生态环境局,上海市工业企业挥发性有机物排放量通用计算方法[EB/OL]. https://max.book118.com/html/2017/0317/95745720. html, 2017-03-16.
[27] Shanghai Municipal Bureau of Ecology and Environment, General method for calculating the emission of volatile organic compounds from industrial enterprises in Shanghai[EB/OL].
[28] https://max.book118.com/html/2017/0317/95745720.html,2017-03-16
[29] 中华人民共和国生态环境部,大气挥发性有机物源排放清单编制技术指南(试行)[EB/OL]. https://wenku.baidu.com/view/e58d4d7884868762cbaed5e0.html, 2016-08-26.
[30] Ministry of Ecology and Environment of the People's Republic of China, Technical Guide for compilation of Emission Inventory of Atmospheric Volatile Organic Compounds (TRIAL)[EB/OL]. https://wenku.baidu.com/view/e58d4d7884868762cbaed5e0.html, 2016-08-26.
[31] 何秋生.我国炼焦生产过程排放的颗粒物和挥发性有机物的组成特征、排放因子及排放量初步估算[D]. 广州:中国科学院广州地球化学研究所, 2006:32-82.
[32] He Q S. Composition characteristics, emission factors and initial estimation of particulate matter and volatile organic compounds (VOCs) emitted during coking in China[D]. Guangzhou:Guangzhou Institute of Geochemistry, Chinese Academy, 2006:32-82.
[33] 何秋生.煤焦化过程污染排放及控制[M]. 北京:化学工业出版社, 2014:79-103.
[34] He Q S. Pollution emission and control of coal coking process[M]. Beijing:Chemical Industry Press, 2014:79-103.
[35] 董艳平,喻义勇,母应锋,等.基于GC-MS方法的焦化行业特征挥发性有机物分析[J]. 环境监测管理与技术, 2016,28(3):65-70. Dong Y P, Yu Y Y, Mu Y F, et al. Characteristic Analysis of VOCs from Coking Chemical Industry by GC-MS[J]. The Administration and Technique of Environmental Monitoring, 2016,28(3):65-70.
[36] Wang P. Discussion on estimation of emission sources and quantity of VOC from petrochemical enterprises[J]. Petrochemical Safety and Environmental Protection Technology, 2013,29(1):59-64.
[37] HJ759-2015环境空气挥发性有机物的测定罐采样/气相色谱-质谱法[S].
[38] HJ 38-2017固定污染源废气总烃、甲烷和非甲烷总烃的测定气相色谱法[S].
[39] Tsai J H, Lin K H, Chen C Y, et al. Volatile organic compound constituents from an integrated iron and steel facility[J].Journal of Hazardous Materials, 2008,157(23):569-578.
[40] 李国昊,魏巍,程水源,等.炼焦过程VOCs排放特征及臭氧生成潜势[J]. 北京工业大学学报, 2014,40(1):91-99. Li G H, Wei W, Chen S Y, et al. Emission Characterization and Ozone Formation Potential of VOCs During the Coking Process[J]. Journal of Beijing University of Technology, 2014,40(1):91-99.
[41] Huang C, Chen C H, Li L, et al. Emission inventory of anthropogenic air pollutants and VOC species in the Yangtze River Delta region, China[J]. Atmospheric Chemistry and Physics, 2011,11(9):4105-4120.
[42] Guo Y Y, Gao X, Zhu T Y, et al. Chemical profiles of PM emitted from the iron and steel industry in northern China[J]. Atmospheric Environment, 2017,150:187-197.