基于酸浸焚烧污泥灰中的磷释放及蓝铁矿生成

康素琴; 郑亚卿; 杨睿; 桑倩倩; 马娟

PDF(1732 KB)

中国环境科学 ›› 2023, Vol. 43 ›› Issue (1) : 225-233.

水污染与控制

基于酸浸焚烧污泥灰中的磷释放及蓝铁矿生成

康素琴¹, 郑亚卿¹, 杨睿¹, 桑倩倩¹, 马娟^1,2,3

作者信息 +

Phosphorus release and formation of vivianite from acid leaching incineration sludge ash

KANG Su-qin¹, ZHENG Ya-qing¹, YANG Rui¹, SANG Qian-qian¹, MA Juan^1,2,3

Author information +

文章历史 +

摘要

酸浸焚烧污泥灰(ISSA)是一种湿化学法提取磷(P)的工艺,因其操作简单、损耗低而被广泛应用.以烘干污泥为对照,通过考察不同温度(600~900℃)下ISSA中的磷形态和矿物相转变,研究了H₂SO₄和HCl作为提取液的酸浓度、酸浸时间和液固比对ISSA样品释磷性能以及对Ca、Al、Mg、Fe等关键金属元素浸出行为的影响,最终通过酸浸、阳离子交换树脂(CER)纯化和沉淀三步反应得到磷回收产物.结果表明:ISSA样品磷的形态以非磷灰石态无机磷(NAIP)为主,且部分NAIP会随着焚烧温度的升高转变为磷灰石态无机磷(AP);同时,污泥样品经两种提取液酸浸后,金属元素Ca、Al、Mg释出量最多,其中Ca、Mg元素的浸出量随焚烧温度的升高变化不大,而Al的浸出量随焚烧温度的升高急剧降低;相比其他焚烧温度,800℃条件下ISSA释磷性能更好,且H₂SO₄酸浸释磷性能优于HCl酸浸,当H₂SO₄浓度为0.10mol/L、液固比为150mL/g、酸浸时间为150min时释磷率达到最高;分析表征结果表明,采用CER对H₂SO₄浸出液纯化后,反应合成的磷回收产物为纯度较高的蓝铁矿.

Abstract

Acid leaching incinerated sewage sludge ash (ISSA) which is a wet chemical process to extract phosphorus (P), is widely employed due to its simple operation and low loss. In this study, the effects of acid concentration, acid leaching time and liquid-solid ratio on the phosphorus release performance and the leaching behavior of key metal elements (Ca, Al, Mg, Fe) of ISSA samples using H₂SO₄ and HCl as extraction solutions were investigated by analyzing phosphorus form and mineral phase transition in ISSA at different temperatures (600~900℃) with dried sludge as control. Finally, phosphorus recovery products were separated by acid leaching, cation exchange resin (CER) purification and precipitation. The results showed that the form of phosphorus in ISSA sample was mainly dominated by non-apatite inorganic phosphorus (NAIP), and part of NAIP could change to apatite inorganic phosphorus (AP) with the increase of incineration temperature. At the same time, after acid leaching with two extraction solutions, Ca, Al and Mg were the highest released metals in sludge samples, among of which the leaching amount of Ca and Mg changed slightly while Al decreased sharply with the increase of incineration temperature. Moreover, ISSA had a better phosphorus release performance at 800℃ compared with other incineration temperatures, and the phosphorous release performance of H₂SO₄ acid leaching was better than that of HCl acid leaching. As H₂SO₄ concentration was 0.10mol/L, liquid-solid ratio was 150mL/g and acid leaching time was 150min, the phosphorus release rate reached the highest. Analysis and characterization revealed that, the phosphorus recovery product synthesized from H₂SO₄ leaching solution after CER purification was highly purified vivianite.

导出引用

康素琴, 郑亚卿, 杨睿, 桑倩倩, 马娟. 基于酸浸焚烧污泥灰中的磷释放及蓝铁矿生成[J]. 中国环境科学. 2023, 43(1): 225-233

KANG Su-qin, ZHENG Ya-qing, YANG Rui, SANG Qian-qian, MA Juan. Phosphorus release and formation of vivianite from acid leaching incineration sludge ash[J]. China Environmental Science. 2023, 43(1): 225-233

中图分类号： X703.1

参考文献

[1] 田文清,俞小军,邓颖等.基于磷回收的低温微氧EBPR系统的表观与微观特性[J]. 中国环境科学, 2022,42(4):1625-1634. Tian W Q, Yu X J, Deng Y. et al. Apparent and microscopic performance of low temperature and low dissolved oxygen EBPR system subjected to side-stream phosphorus recovery[J]. China Environmental Science, 2022,42(4):1625-1634.
[2] 王松,谢洪勇.鸟粪石结晶法回收高浓度酸性含磷废水中磷的研究[J]. 江苏农业科学, 2020,48(4):282-285. Wang S, Xie H Y. Study on the recovery of phosphorus from high concentration acidic phosphorous wastewater by struvite crystallization[J]. Jiangsu Agricultural Sciences, 2020,48(4):282-285.
[3] Liang S, Chen H M, Zeng X H, et al. A comparison between sulfuric acid and oxalic acid leaching with subsequent purification and precipitation for phosphorus recovery from sewage sludge incineration ash[J]. Water Research, 2019,159:242-251.
[4] 王卓艺.污水处理系统中磷的转化途径[J]. 科技情报开发与经济, 2007,(32):154-156. Wang Z Y. Phosphorus conversion in sewage treatment system[J]. Development of Scientific and Technological Information and Economy, 2007,(32):154-156.
[5] 桑倩倩.污泥预处理强化释磷及磷回收研究[D]. 兰州:兰州交通大学, 2021. Sang Q Q. Study on enhanced phosphorus release and phosphorus recovery by sludge pretreatment[D]. Lanzhou:Lanzhou Jiaotong University, 2021.
[6] Liang S, Yang L, Chen H M, et al. Phosphorus recovery from incinerated sewage sludge ash (ISSA) and reutilization of residues for sludge pretreated by different conditioners[J]. Resources, Conservation & Recycling, 2021,169:105524.
[7] Fang L, Li J S, Guo M Z, et al. Phosphorus recovery and leaching of trace elements from incinerated sewage sludge ash (ISSA)[J]. Chemosphere, 2018,193:278-287.
[8] Wang Q M, Li J S, Tang T, et al. Sustainable reclamation of phosphorus from incinerated sewage sludge ash as value-added struvite by chemical extraction, purification and crystallization[J]. Journal of Cleaner Production, 2018,181:717-725.
[9] Egle L, Rechberger H, Zessner M.Overview and description of technologies for recovering phosphorus from municipal wastewater[J]. Resources Conservation and Recycling, 2015,105:325-346.
[10] Wu Y, Luo J, Zhang Q, et al. Potentials and challenges of phosphorus recovery as vivianite from wastewater:a review[J]. Chemosphere, 2019,226:24-25.
[11] Bezzina James P, Robshaw Thomas J, Canner Adam J, et al. Adsorption studies of a multi-metal system within acetate media, with a view to sustainable phosphate recovery from sewage sludge[J]. Journal of Environmental Management, 2022,324:116279-116279.
[12] Rothe M, Frederichs T, Eder M, et al. Evidence for vivianite formation and its contribution to long-term phosphorus retention in a recent lake sediment:a novel analytical approach[J]. Biogeosciences, 2014,11(5):5169-5180.
[13] Rothe M, Kleeberg A, Hupfer M.The occurrence,identification and environmental relevance of vivianite in waterlogged soils and aquatic sediments[J]. Earth-Science Reviews,2016,158:51-64.
[14] Zha J R, Huang Y J, Xia W Q, et al. Effect of mineral reaction between calcium and aluminosilicate on heavy metal behavior during sludge incineration[J]. Fuel, 2018,229:241-249.
[15] 杨艳飞.磷酸亚铁和磷酸亚铁锂制备工艺及其性能研究[D]. 郑州:郑州大学, 2012. Yang Y F. Preparation technology and properties of ferrous phosphate and lithium ferrous phosphate[D]. Zhengzhou:Zhengzhou University, 2021.
[16] 郝晓地,周健,王崇臣.蓝铁矿形成于污泥厌氧消化系统的验证与分析[J]. 中国给水排水, 2018,34(13):7-13. Hao X D, Zhou J, Wang C C. Verification and analysis of formation of vivianite in sludge anaerobic digestion system[J]. China Water & Wastewater, 2018,34(13):7-13.
[17] 魏铭泽,张彩杰,戚秀芝,等.水产品加工厂污泥焚烧灰中磷及重金属释放特性研究[J]. 中国海洋大学学报(自然科学版), 2016,46(4):118-126. Wei M Z, Zhang C J, Qi X Z, et al. Study on release characteristics of phosphorus and heavy metals in sludge incineration ash of aquatic product processing plant[J]. Journal of Ocean University of China (Natural Science edition), 2016,46(4):118-126.
[18] Xu H C, He P J, Gu W M, et al. Recovery of phosphorus as struvite from sewage sludge ash[J]. Journal of Environmental Sciences, 2012, 24(8):1533-1538.
[19] Lisbeth M Ottosen, Gunvor M Kirkelund, Pernille E Jensen. Extracting phosphorous from incinerated sewage sludge ash rich in iron or aluminum[J]. Chemosphere, 2013,91(7):963-969.
[20] Zhang M Y, Kuba Takahiro. Inhibitory effect of metal ions on the poly-phosphate release from sewage sludge during thermal treatment[J]. Environmental technology, 2014,35(9):1157-1164.
[21] Kleemann R, Chenoweth R, Clift R, et al. Comparison of phosphorus recovery from incinerated sewage sludge ash(ISSA) and pyrolysed sewage sludge char (PSSC)[J]. Waste Manag, 2017,60:201-210.
[22] M Atienza-Martinez, G Gea, J Arauzo, et al. Phosphorus recovery from sewage sludge char ash[J]. Biomass and Bioenergy, 2014,65:42- 50.
[23] 陈昊铭.市政污泥焚烧过程磷形态转变及焚烧灰草酸浸出磷回收的研究[D]. 武汉:华中科技大学, 2019. Chen H M. Study on phosphorus transformation in municipal sludge incineration process and phosphorus recovery from oxalic acid leaching from incineration ash[D]. Wuhan:Huazhong University of Science and Technology, 2019.
[24] Cohen Yariv. Phosphorus dissolution from ash of incinerated sewage sludge and animal carcasses using sulphuric acid[J]. Environmental Technology, 2009,30(11):1215-1226.
[25] Lu Y S, Liu H, Feng W, et al. A new and efficient approach for phosphorus recovery from wastewater in the form of vivianite mediated by iron-reducing bacteria[J]. Journal of Water Process Engineering, 2021,42.
[26] Jin Z Y, Chang F M, Meng F L, et al. Sustainable pyrolytic sludge- char preparation on improvement of closed-loop sewage sludge treatment:Characterization and combined in-situ application[J]. Chemosphere, 2017,184:1043-1053.
[27] Li R D, Zhang Z H, Li Y L, et al. Transformation of apatite phosphorus and non- apatiteinorganic phosphorus during incineration of sewage sludge[J]. Chemosphere, 2015,141:57-61.
[28] Petzet S, Peplinsfei B, Cornel P, et al. On wet chemical phosphorus recovery from sewage sludge ash by acidic or alkaline leaching and an optimized combination of both[J]. Water Research, 2012,46(12):3769-3780.
[29] Donatello S, Tong D, Cheeseman C R, et al. Production of technical grade phosphoric acid from incinerator sewage sludge ash (ISSA)[J]. Waste Management, 2010,30(8/9):1634-1642.
[30] Ottosen L M, Kirkelund G M, Jensen P E, et al. Extracting phosphorous from incinerated sewage sludge ash rich in iron or aluminum[J]. Chemosphere, 2013,91(7):963-969.
[31] Cohen Y. Phosphorus dissolution from ash of incinerated carcasses using sulphuric acid[J]. Environmental Technology, sewage sludge and animal 2009,30(11):1215-1226.
[32] 曾晓会.鸟粪石法回收剩余污泥释磷液及污泥焚烧灰酸浸液中磷的研究[D]. 武汉:华中科技大学, 2018. Zeng X H. Study on recovery of phosphorus release solution from sludge and acid leaching solution from sludge incineration ash by struvite method[D]. Wuhan:Huazhong University of Science and Technology, 2018.
[33] 郝晓地,周健,王崇臣.探究污泥厌氧消化系统中蓝铁矿生成的干扰因子[J]. 中国给水排水, 2018,34(23):1-7. Hao X D, Zhou J, Wang C C. To explore the interference factors of vivianite formation in sludge anaerobic digestion system[J]. China Water & Wastewater, 2018,34(23):1-7.
[34] 周健.从厌氧消化污泥中回收磷-蓝铁矿形成机制初探[D]. 北京:北京建筑大学, 2018. Zhou J. Preliminary study on formation mechanism of phosphorusvivianite recovered from anaerobic digestion sludge[D]. Beijing:Beijing University of Civil Engineering and Architecture, 2018.
[35] 叶嘉洲.蓝铁矿形成与分离试验研究[D]. 北京:北京建筑大学, 2020. Ye J Z. Experimental study on formation and separation of vivianite[D]. Beijing:Beijing University of Civil Engineering and Architecture, 2020.
[36] Wu Y, Wang C, Wang S, et al. Graphite accelerate dissimilatory iron reduction and vivianite crystal enlargement[J]. Water Research, 2021,189:116663.
[37] Tian Jingbao, Cheng Xiang, Deng Shaoyu, et al. Inducing in Situ crystallization of vivianite in a UCT-MBR system for enhanced removal and possible recovery of phosphorus from sewage[J]. Environmental science & technology, 2019,53(15):9045-9053.
[38] 王聪,王舒,李楠.石墨强化微生物异化铁还原合成蓝铁石的磷回收研究[J]. 环境科学学报, 2019,39(10):3325-3332. Wang C, Wang S, Li N. Study on phosphorus recovery of vivianite synthesized by microbial dissimilar Iron reduction enhanced by graphite[J]. Journal of Environmental Sciences, 2019,39(10):3325- 3332.