Characteristics and ozone formation potential of fugitive volatile organic compounds (VOCs) emitted from petrochemical industry in Pearl River Delta
LI Qin-qin1,2,3, ZHANG Zhi-juan1,2, LI Yang1,2,3, GONG Dao-cheng1,2, GAO Jie1,2,3, ZHANG Chun-lin1,2, WANG Bo-guang1,2
1. Environment and Climate Institute, Jinan University, Guangzhou 510632, China;
2. Institute of Atmospheric Environmental Safety and Pollution Control, Jinan University, Guangzhou 510632, China;
3. Research Center on Low-carbon Economy for Guangzhou Region, Jinan University, Guangzhou 510632, China
Refinery installations, chemical installations and wastewater treatment installations of typical petrochemical facilities were selected in Pearl River Delta where the photochemistry was active. Multiple on-line and off-line monitoring instruments were used to analyze the fugitive emission characteristics of VOCs. The ratios of m, p-xylene/benzene (X/B), toluene/benzene (T/B) and ethyl benzene/benzene (E/B) were applied to analyze the aging characteristics of VOCs. The atmospheric chemical reactivity of VOCs and their Ozone Formation Potential (OFP) were evaluated by using Maximum Increment Reactivity (MIR), propy-equiv concentration and OH radical reactivity methods. The concentrations of TVOCs in refinery unit and chemical unit were both higher in the morning and night, lower at noon. However, for the wastewater treatment unit, it's bimodal. Alkanes were the most abundant species in all the three units, and VOCs emitted from different units were totally different. The ratio of X/B, T/B and E/B in petroleum refinery were higher than that in cities and suburbs, while T/B of Compression Alkali Washing area (CAW) in the chemical units was the highest. The photochemical reactivity of VOCs in the petroleum refinery was higher than that in cities and suburbs. Moreover, the average OH consumption rate of VOCs emitted from the petroleum refinery was 15.22×10-12cm3/ (mol·s), and the largest incremental reactivity was 4.21mol (O3)/mol (VOC). The OFP estimated from the VOCs in the chemical units accounted for the highest ratio, which is up to 84.83%. While the VOCs emitted from the wastewater treatment unit was the second, with the ratio of 12.95%. And, the contribution of refinery installation area was the lowest, with the ratio of 2.22%. The contribution of CAW in chemical installation unit to the OFP of the petroleum refinery was the highest with the ratio of 34.26%. The contribution of Flotation Tank (FT) in wastewater treatment unit was the lowest with the ratio of 0.36%.
李勤勤, 张志娟, 李杨, 龚道程, 高洁, 张春林, 王伯光. 石油炼化无组织VOCs的排放特征及臭氧生成潜力分析[J]. 中国环境科学, 2016, 36(5): 1323-1331.
LI Qin-qin, ZHANG Zhi-juan, LI Yang, GONG Dao-cheng, GAO Jie, ZHANG Chun-lin, WANG Bo-guang. Characteristics and ozone formation potential of fugitive volatile organic compounds (VOCs) emitted from petrochemical industry in Pearl River Delta. CHINA ENVIRONMENTAL SCIENCECE, 2016, 36(5): 1323-1331.
Kuo Y-M, Chiu C-H, Yu H-L. Influences of ambient air pollutants and meteorological conditions on ozone variations in Kaohsiung, Taiwan [J]. Stochastic Environmental Research And Risk Assessment, 2015,29(3):1037-1050.
[2]
Wang S Y, Wu D W, Wang X M, et al. Relative contributions of secondary organic aerosol formation from toluene, xylenes, isoprene, and monoterpenes in Hong Kong and Guangzhou in the Pearl River Delta, China: an emission-based box modeling study [J]. Journal Of Geophysical Research-Atmospheres, 2013,118(2): 507-519.
Bale A S, Meacham C A, Benignus V A, et al. Volatile organic compounds inhibit human and rat neuronal nicotinic acetylcholine receptors expressed in Xenopus oocytes [J]. Toxicology and Applied Pharmacology, 2005,205(1):77-88.
[5]
Wei W, Wang S X, Chatani S, et al. Emission and speciation of non-methane volatile organic compounds from anthropogenic sources in China [J]. Atmospheric Environment, 2008,42(20): 4976-4988.
[6]
Lyu XP, Chen N, Guo H, et al. Ambient volatile organic compounds and their effect on ozone production in Wuhan, central China [J]. Science of the Total Environment, 2016, 54(1):200-209.
Guo Y, Zeng H, Zheng R, et al. The association between lung cancer incidence and ambient air pollution in China: A spatiotemporal analysis [J]. Environ. Res., 2016,144,Part A60-65.
Bo Y, Cai H, Xie S D. Spatial and temporal variation of historical anthropogenic NMVOCs emission inventories in China [J]. Atmospheric Chemistry and Physics, 2008,8(23):7297-7316.
[12]
Yin S, Zheng J, Lu Q, et al. A refined 2010-based VOC emission inventory and its improvement on modeling regional ozone in the Pearl River Delta Region, China [J]. Sci. Total Environ., 2015, 51(4):426-438.
[13]
Cetin E, Odabasi M, Seyfioglu R. Ambient volatile organic compound (VOC) concentrations around a petrochemical complex and a petroleum refinery [J]. Science of the Total Environment, 2003,312(1-3):103-112.
Wei W, Cheng S, Li G, et al. Characteristics of volatile organic compounds (VOCs) emitted from a petroleum refinery in Beijing, China [J]. Atmospheric Environment, 2014,89(3):358-366.
[16]
Mo Z, Shao M, Lu S, et al. Process-specific emission characteristics of volatile organic compounds (VOCs) from petrochemical facilities in the Yangtze River Delta, China [J]. Science of the Total Environment, 2015,53(3):422-431.
[17]
Chen C L, Fang H Y, Shu M. Source location and characterization of volatile organic compound emissions at a petrochemical plant in Kaohsiung, Taiwan [J]. Journal Of the Air & Waste Management Association, 2005,55(10):1487-1497.
Liu Y, Shao M, Fu L L, et al. Source profiles of volatile organic compounds (VOCs) measured in China: Part I [J]. Atmospheric Environment, 2008,42(25):6247-6260.
[20]
Zheng J, Shao M, Che W, et al. Speciated VOC Emission Inventory and Spatial Patterns of Ozone Formation Potential in the Pearl River Delta, China [J]. Environ. Sci. Technol., 2009, 43(22):8580-8586.
Huang C, Chen C H, Li L, et al. Emission inventory of anthropogenic air pollutants and VOC species in the Yangtze River Delta region, China [J]. Atmospheric Chemistry and Physics, 2011,11(9):4105-4120.
[23]
Chen C-L, Shu C-M, Fang H-Y. Location and characterization of emission sources for airborne volatile organic compounds inside a refinery in Taiwan [J]. Environmental Monitoring and Assessment, 2006,120(1-3):487-498.
Yuan B, Shao M, Lu S, et al. Source profiles of volatile organic compounds associated with solvent use in Beijing, China [J]. Atmospheric Environment, 2010,44(15):1919-1926.
[27]
Wang B G, Gu Y G, Zhou L, et al. Determination of dimethyl sulfide in gas samples by single photon ionization time of flight mass spectrometry [J]. Analytical Letters, 2014,47(12):2003-2011.
Cai C, Geng F, Tie X, et al. Characteristics and source apportionment of VOCs measured in Shanghai, China [J]. Atmospheric Environment, 2010,44(38):5005-5014.
Carter W. Development of the SAPRC-07chemical mechanism and updated ozone reactivity scales, report to the California Air Resources Board Contracts 03-318, 06-408and 07-730 2010 [R]. California Air Resources Board: Sacramento, CA, 2010.
Gariazzo C A P, Di Filippo P, Sallusti F, et al. Monitoring and analysis of volatile organic compounds around an oil refinery [J]. Water, Air, and Soil Pollution, 2005,167(1):17-38.
[34]
An Jun-lin, Wang Yue-si, W Fang-kun, et al. Characterizations of volatile organic compounds during high ozone episodes in Beijing, China [J]. Environmental Monitoring and Assessment, 2012,184(4):1879-1889.
[35]
Lin T-Y, Sree U, Tseng S-H, et al. Volatile organic compound concentrations in ambient air of Kaohsiung petroleum refinery in Taiwan [J]. Atmospheric Environment, 2004,38(25):4111-4122.
[36]
Prinn R, Cunnold D, Rasmussen R, et al. Atmospheric trends in methylchloroform and the global average for the hydroxyl radical [J]. Science, 1987,238(4829):945-950.
[37]
Tang J H, Chan L Y, Chan C Y, et al. Characteristics and diurnal variations of NMHCs at urban, suburban, and rural sites in the Pearl River Delta and a remote site in South China [J]. Atmospheric Environment, 2007,41(38):8620-8632.
[38]
Song Y, Dai W, Shao M, et al. Comparison of receptor models for source apportionment of volatile organic compounds in Beijing, China [J]. 2008,156(1):174-183.
Chang C-C, Chen T-Y, Lin C-Y, et al. Effects of reactive hydrocarbons on ozone formation in southern Taiwan [J]. Atmospheric Environment, 2005,39(16):2867-2878.