Process characteristics of ammonia wastewater treatment by embedded immobilized nitrifying sludge
XU Xiao-yi1,2, ZHANG Ting-ting1,2, YOU Xiao-lu1,2, LÜ Chen-pei1,2
1. Key Lab of Ministry of Education for Three Gorges Reservoir Region's Eco-Environment, Chongqing University, Chongqing 400045, China; 2. National Centre for International Research of Low-carbon and Green Buildings, Chongqing University, Chongqing 400045, China
Abstract:Polyvinyl alcohol (PVA) as a gel matrix was used to immobilize activated sludge with good nitrification performance. The mass transfer efficiency and nitrogen removal characteristics of immobilized particles were evaluated for different initial ammonium concentration of simulated wastewater in the sequencing batch reactor (SBR). When the package percentage of immobilized particles, water temperature, pH, and the DO concentration were 10%, 26~30℃, 7.5~8.5, and 4~5mg/L, respectively, the maximal ammonia removal load in the stable period kept at 61.8~242.3mgN/(L-particles·h) with different influent NH4+-N concentration of 50~400mg/L. The removal kinetics of ammonia nitrogen followed the zero-order reaction model, furthermore, the maximum ammonia oxidation rate (μmax) and half-saturation constant (Ks) were estimated as 271.40mgN/(L-particles·h) and 66.69mg/L, respectively. According to the diffusion experiments, the effective diffusion coefficient (De) of ammonia and oxygen in immobilized particles were calculated as 0.467×10-9m2/s and 0.279×10-9m2/s, respectively. SEM observation and the test of specific surface area showed that the specific surface area and the average pore diameter in the interior of the particles increased greatly during the stable stage compared with the fresh particles. Comprehensive comparison of three different systems including immobilized particles reactor, activated sludge reactor, and the mixing reactor with immobilized particles and activated sludge was carried out. The sludge reactor with adding immobilized particles could enhance the nitrification and nitrogen removal process significantly. Moreover, the simultaneous nitrification and denitrification also could be observed.
Conley D J, Paerl H W, Howarth R W, et al. Controlling eutrophication: nitrogen and phosphorus [J]. Science, 2009, 323(5917):1014-1015.
[2]
Matsumura M, Yamamoto T, Wang P, et al. Rapid nitrification with immobilized cell using macro-porous cellulose carrier [J]. Water research, 1997,31(5):1027-1034.
[3]
Eikelboom D H, Grovenstein J. Control of bulking in a full scale plant by addition of talc (PE 8418) [J]. Water Science and Technology, 1998,37(4):297-301.
[4]
Hansen K H, Angelidaki I, Ahring B K. Anaerobic digestion of swine manure: inhibition by ammonia [J]. Water research, 1998, 32(1):5-12.
Uemoto H, Saiki H. Behavior of immobilized Nitrosomonas europaea and Paracoccus denitrificans in tubular gel for nitrogen removal in wastewater [J]. Progress in Biotechnology, 1996,11: 695-702.
[7]
Uemoto H, Saiki H. Nitrogen removal by tubular gel containing Nitrosomonas europaea and Paracoccus denitrificans [J]. Applied and environmental microbiology, 1996,62(11):4224-4228.
[8]
Qiao S, Tian T, Duan X M, et al. Novel single-stage autotrophic nitrogen removal via co-immobilizing partial nitrifying and anammox biomass [J]. Chemical engineering journal, 2013,230: 19-26.
[9]
Strotmann U J, Windecker G. Kinetics of ammonium removal with suspended and immobilized nitrifying bacteria in different reactor systems [J]. Chemosphere, 1997,35(12):2939-2952.
Dong Y, Zhang Z, Jin Y, et al. Nitrification performance of nitrifying bacteria immobilized in waterborne polyurethane at low ammonia nitrogen concentrations [J]. Journal of Environmental Sciences, 2011,23(3):366-371.
[13]
Li Z R, Zhang Z, Zhang Z J. Inhibition of Nitrification of Ammonia-Rich Wastewater in Immobilized Nitrifiers System [C]//Advanced Materials Research. 2011,183:197-200.
[14]
Li Z, Zhang Z, Li J, et al. Comparative study of the nitrification characteristics of two different nitrifier immobilization methods [J]. Biodegradation, 2009,20(6):859-865.
[15]
Dong Y, Zhang Z, Jin Y, et al. Nitrification characteristics of nitrobacteria immobilized in waterborne polyurethane in wastewater of corn-based ethanol fuel production [J]. Journal of Environmental Sciences, 2012,24(6):999-1005.
[16]
Leenen E J T M, Dos Santos V A P, Grolle K C F, et al. Characteristics of and selection criteria for support materials for cell immobilization in wastewater treatment [J]. Water Research, 1996,30(12):2985-2996.
[17]
Magrí A, Vanotti M B, Szögi A A. Anammox sludge immobilized in polyvinyl alcohol (PVA) cryogel carriers [J]. Bioresource technology, 2012,114:231-240.
[18]
Rostron W M, Stuckey D C, Young A A. Nitrification of high strength ammonia wastewaters: comparative study of immobilisation media [J]. Water Research, 2001,35(5):1169- 1178.
Urfer D, Huck P M. Measurement of biomass activity in drinking water biofilters using a respirometric method [J]. Water research, 2001,35(6):1469-1477.
[21]
Surmacz-Gorska J, Gernaey K, Demuynck C, et al. Nitrification monitoring in activated sludge by oxygen uptake rate (OUR) measurements [J]. Water Research, 1996,30(5):1228-1236.
[22]
Takei T, Ikeda K, Ijima H, et al. Fabrication of poly (vinyl alcohol) hydrogel beads crosslinked using sodium sulfate for microorganism immobilization [J]. Process Biochemistry, 2011, 46(2):566-571.
[23]
Zain N A M, Suhaimi M S, Idris A. Development and modification of PVA–alginate as a suitable immobilization matrix [J]. Process Biochemistry, 2011,46(11):2122-2129.
[24]
Vanotti M B, Hunt P G. Nitrification treatment of swine wastewater with acclimated nitrifying sludge immobilized in polymer pellets [J]. Transactions of the ASAE, 2000,43(2):405- 413.
Pu H T, Yang R Y K. Diffusion of sucrose and yohimbine in calcium alginate gel beads with or without entrapped plant cells [J]. Biotechnology and bioengineering, 1988,32(7):891-896.
Wiesmann R, Zimelka W, Baumgärtl H, et al. Investigation of oxygen transfer through the membrane of polymer hollowspheres by oxygen micro-electrodes [J]. Journal of biotechnology, 1994, 32(3):221-229.