|
|
Performance of NO removal using Fe(II)EDTA complexing absorption coupled with H2-MBfR |
LIU Wan-ting1, QIAN Fei-yue1,2, ZHAO Jun-jie1, XU Zheng-hui3, WANG Jian-fang1,2,3, MIAO Run-zhu1 |
1. School of Environmental Science and Engineering, Suzhou University of Science and Technology, Suzhou 215009, China; 2. National Local Joint Engineering Laboratory of Urban Domestic Wastewater Resource Utilization Technology, Jiangsu Collaborative Innovation Center of Water Treatment Technology and Material, Suzhou 215009, China; 3. Tianping College, Suzhou University of Science and Technology, Suzhou 215009, China |
|
|
Abstract An integrated system of Fe(II)EDTA complexing absorption coupled with H2-based membrane biofilm reactor (H2-MBfR) was constructed and a mixed bacterial strain capable of simultaneous denitrification and iron reduction was domesticated. Based on the maintenance of the stable denitrification of the reduction system, the effects of Fe(II)EDTA concentration and pH on NO removal efficiency were investigated and the microbial community structure was analyzed. The results showed that the Fe(II)EDTA complexing absorption coupled with H2-MBfR reduction integrated system had a stable NO removal efficiency, and the maximum removal efficiency was 99.50%. Elevating the initial Fe(II)EDTA concentration facilitated the formation of Fe(II)EDTA-NO, subsequently enhancing average NO removals in the system. The maximum removal rate of 44.68mg/(m3·h) was achieved at a Fe(II)EDTA concentration of 10mmol/L. Increasing the pH hindered the accumulation of Fe(II)EDTA-NO, and maintaining a pH of 6proved more suitable for optimal operation of the integration system. The microbial community structure analysis revealed that the dominant phylum in the integration stage were Proteobacteria, Bacteroidetes and Firmicutes, played important roles in this system, with abundance of 50.35%, 16.43% and 14.98%, respectively.
|
Received: 25 July 2023
|
|
Corresponding Authors:
王建芳,教授,wjf302@163.com
E-mail: wjf302@163.com
|
|
|
|
[1] 刘怀平,尹海滨,熊尚超,等.水泥炉窑中低温催化脱硝技术中试性能[J]. 中国环境科学, 2021,41(7):3169-3175. Liu H P, Yin H B, Xiong S C, et al. Pilot performance of low- temperature catalytic denitrification in cement kilns[J]. China Environmental Science, 2021,41(7):3169-3175. [2] 侯丽敏,吕秉娱,付善聪,等.Ni改性对稀土尾矿NH3-SCR脱硝性能的影响[J]. 中国环境科学, 2023,43(4):1574-1581. Hou L M, Lv B Y, Fu S C, et al. Effect of Ni modification on the denitrification performance of rare earth tailings NH3-SCR[J]. China Environmental Science, 2023,43(4):1574-1581. [3] Gao L, Mi X, Zhou Y, et al. A pilot study on the regeneration of ferrous chelatecomplex in NOx scrubber solution by a biofilm electrode reactor[J]. Bioresoure Technology, 2011,102:2605-2609. [4] Razaviarani V, Ruiz-Urigüen M, Jaffé P R. Denitrification of nitric oxide using hollow fiber membrane bioreactor; effect of nitrate and nitric oxide loadings on the reactor performance and microbiology[J]. Waste and Biomass Valorization, 2019,10:1989-2000. [5] Zhang J, Ren L, Zhang D, et al. Reduction of NO to N2 in an autotrophic up-flow bioreactor with sponge iron bed based Fe(II)EDTA complexation[J]. Fuel, 2019,254:115631. [6] Li W, Wu C, Zhang S, et al. Evaluation of microbial reduction of Fe(III)EDTA in a chemical absorption-biological reduction integrated NOx removal system[J]. Environmental Science & Technology, 2007,41(2):639-644. [7] 徐梦蝶,王建芳,葛璟麟,等.生物法烟气脱硝工艺研究进展[J]. 环境工程技术学报, 2022,12(6):2049-2056. Xu M D, Wang J F, Ge J L, et al. Progress of biological flue gas denitrification[J]. Journal of Environmental Engineering Technology, 2022,12(6):2049-2056. [8] Zhang S, Chen H, Xia Y, et al. Current advances of integrated processes combining chemical absorption and biological reduction for NOx removal from flue gas[J]. Applied Microbiology and Biotechnology, 2014,98:8497-8512. [9] Bruce E. Rittman. Biofilms, active substrata, and me[J]. Water Research, 2018,132:135-145. [10] 丁欣,陈虎,王莹,等.生物法处理烟气中NOx的研究进展[J]. 现代化工, 2021,41(7):46-50. Ding X, Chen H, Wang Y, et al. Research progress of biological treatment of NOx in flue gas[J]. Modern Chemical Industry, 2021, 41(7):46-50. [11] 黎宝林,李明玉,刘海豪,等.络合-氧化-还原耦合方法脱除烟气中NOx的研究[J]. 中国环境科学, 2014,34(5):1125-1130. Li B L, Li M Y, Liu H H, et al. Study on NOx removal from flue gas by a coupled complexation-oxidation-reduction method[J]. China Environmental Science, 2014,34(5):1125-1130. [12] Lu J J, Yan W J, Shang W T, et al. Simultaneous enhancement of nitrate removal flux and methane utilization efficiency in MBfR for aerobic methane oxidation coupled to denitrification by using an innovative scalable double-layer membrane[J]. Water research:A journal of the international water association, 2021,194(15):116936.1- 116936.11. [13] Lu J J, Shen Q, Li X Y, et al. Surface-manipulated membranes to accelerate biofilm formation and to resist bacterial detachment in MBfR for aerobic methane oxidation coupled to denitrification[J]. Chemical Engineering Journal, 2022,430:132629. [14] Chen J, He J, Wang X, et al. Reduction of Fe(II)EDTA-NO by Mn powder in wet flue gas denitrification technology:stoichiometry, kinetics, and thermodynamics[J]. Environmental Science and Pollution Research, 2019,26:36933-36941. [15] He F, Deng X, Chen M. Evaluation of Fe(II)EDTA-NO reduction by zinc powder in wet flue gas denitrification technology with Fe(II)EDTA[J]. Fuel, 2017,199:523-531. [16] Li W, Xia Y, Zhao J, et al. Generation, utilization, and transformation of cathode electrons for bioreduction of Fe(III)EDTA in a biofilm electrode reactor related to NOx removal from flue gas[J]. Environmental Science & Technology, 2015,49:4530-4535. [17] Zhou Y, Gao L, Xia Y, et al. Enhanced reduction of Fe(II)EDTA- NO/Fe(III)EDTA in NOx scrubber solution using a three-dimensional biofilm-electrode reactor[J]. Environmental Science & Technology, 2012,46:12640-12647. [18] Lu B, Jiang Y, Cai L, et al. Enhanced biological removal of NOx from flue gas in a biofilter by Fe(II)Cit/Fe(II)EDTA absorption[J]. Bioresource Technology, 2011,102:7707-7712. [19] Zhang S H, Li W, Wu C Z, et al. Reduction of Fe(II)EDTA-NO by a newly isolated Pseudomonas sp. strain DN-2 in NOx scrubber solution[J]. Applied Microbiology and Biotechnology, 2007,76:1181-1187. [20] 刘芸.一氧化氮络合吸收产物的测定及其微生物还原特性的研究[D]. 杭州:浙江大学, 2011. Liu Y. Determination of Nitric Oxide Complex Absorption Products and Study on Microbial Reduction Characteristics[D]. Hangzhou:Zhejiang University, 2011. [21] 杨朋兵,林兴,李祥,等.邻菲罗啉分光光度法测定含EDTA溶液中Fe3+的改进[J]. 实验室研究与探索, 2016,35(12):22-25. Yang P B, Lin X, Li X, et al. Improvement of o-phenanthroline spectrophotometric method for the determination of Fe3+in EDTA-containing solutions[J]. Laboratory Research and Exploration, 2016,35(12):22-25. [22] 冉雅郡,周云,杨潇潇,等.MBfR处理水中氧化性污染物的研究进展[J]. 中国环境科学, 2018,38(12):4484-4493. Ran Y X, Zhou Y, Yang X X, et al. Research progress of MBfR treatment of oxidative pollutants in water[J]. China Environmental Science, 2018,38(12):4484-4493. [23] 王晨辉,徐晓茵,夏四清.氢基质生物膜反应器去除水中硒酸盐研究[J]. 中国环境科学, 2014,34(6):1442-1447. Wang C H, Xu X Y, Xia S Q. Study on the removal of selenate from water by a hydrogen substrate biofilm reactor[J]. China Environmental Science, 2014,34(6):1442-1447. [24] Li N, Zhang Y, Li Y, et al. Reduction of Fe(II)EDTA-NO using Paracoccus denitrificans and changes of Fe(II)EDTA in the system[J]. Journal of Chemical Technology & Biotechnology, 2013,88(2):311- 316. [25] Xia Y F, Zhao J K, Li M F, et al. Bio-electrochemical reduction of Fe(II)EDTA-NO in a biofilm electrode reactor:Performance, mechanism and kinetics[J]. Environmental Science & Technology, 2016,50:3846-3851. [26] Li K P, Hu H, Fan M H, et al. Simultaneous removal of NO and SO2 by Fe(II)/peracetic acid oxidation system:Operating conditions, removal efficiency and removal mechanism[J]. Fuel, 2023,342:127793. [27] He F, Zhu X, Chen X, et al. Simultaneous removal of NO and SO2 from flue gas by Fe(II)EDTA/sodium dithionite solutions[J]. Journal of Chemical Technology & Biotechnology, 2020,95(5):1392-1399. [28] Ma L W, Zhang G J, Li G Q, et al. NaHS regenerated Fe(II)EDTA denitrification mechanism and kinetics investigation[J]. Fuel, 2023,343:127964. [29] He F Q, Deng X H, Chen M. Mechanism and kinetics of Fe(II)EDTA-NO reduction by iron powder under anaerobic condition[J]. Fuel, 2016,186:605-612. [30] Zhou T, Huang Y. Fe(III)EDTA and Fe(II)EDTA-NO reduction by supported (nano)ZVI in Fe(II)EDTA complexation denitrification technology:Performance, kinetics, and pathway[J]. Journal of Environmental Chemical Engineering, 2022,10(6):108547. [31] Zhao J K, Zhang C Y, Sun C, et al. Electron transfer mechanism of biocathode in a bioelectrochemical system coupled with chemical absorption for NO removal[J]. Bioresource Technology:Biomass, Bioenergy, Biowastes, Conversion Technologies, Biotransformations, Production Technologies, 2018,254:16-22. [32] 殷祥男,房晶瑞,王俊杰,等. Fe(Ⅱ)EDTA溶液脱除NO实验研究[J]. 工业安全与环保, 2017,43(10):88-92. Yin X N, Fang J R, Wang J J, et al. Experimental study of NO removal by Fe(II)EDTA solution[J]. Industrial Safety and Environmental Protection, 2017,43(10):88-92. [33] 张文勃,李晓玲,刘心怡,等.EDTA-2Na/Fe(II)对自养生物体系下硝酸盐还原过程的影响[J]. 中国环境科学, 2022,42(7):3149-3155. Zhang W B, Li X L, Liu X Y, et al. Effect of EDTA-2Na/Fe(II) on nitrate reduction process under autotrophic biological system[J]. Chinese Environmental Science, 2022,42(7):3149-3155. [34] Liang C, Liang C P, Chen C C. pH dependence of persulfate activation by EDTA/Fe(III) for degradation of trichloroethylene[J]. Journal of Contaminant Hydrology, 2009,106(3/4):173-182. [35] 王禹. SO2共存下FeII(EDTA)-黄铁矿浆法烟气脱硝研究[D]. 青岛:青岛大学, 2017. Wang Y. Research on flue gas denitrification using FeII(EDTA)- pyrite slurry method under the coexistence of SO2[D]. Qingdao:Qingdao University, 2017. [36] Wu J, Yin Y, Wang J. Hydrogen-based membrane biofilm reactors for nitrate removal from water and wastewater[J]. International Journal of Hydrogen Energy, 2018,43(1):1-15. [37] 梁岑.亚铁络合吸收-硫自养生物还原耦合脱除NO实验研究[D]. 北京:北京化工大学, 2018. Liang C. Experimental study on coupled ferrous complex absorption-sulfur autotrophic bioreduction for NO removal[D]. Beijing:Beijing University of Chemical Technology, 2018. [38] LI L, YAN G, WANG H, et al. Denitrification and microbial community in MBBR using A.donax as carbon source and biofilm carriers for reverse osmosis concentrate treatment[J]. Journal of Environmental Sciences, 2019,84:133-143. [39] 白倩倩,刘永红,王宁,等. PBG-MBBR系统启动过程中生物膜特性变化研究[J]. 化学工程师, 2022,36(3):77-82. Bai Q Q, Liu Y H, Wang N, et al. Study of biofilm property changes during startup of PBG-MBBR system[J]. Chemical Engineer, 2022,36(3):77-82. [40] 孙博雅,程永毅,肖广全,等.典型气田土壤铁还原活性与微生物群落关系研究[J]. 环境科学学报, 2021,41(10):4170-4178. Sun B Y, Cheng Y Y, Xiao G Q, et al. Relationship between iron reduction activity and microbial community in typical gas field soils[J]. Journal of Environmental Science, 2021,41(10):4170-4178. [41] 肖青阳.基于CABR的烟道尾气同步脱硫脱硝及单质硫回收技术的运行效能研究[D]. 哈尔滨:哈尔滨工业大学, 2021. Xiao Q Y. Performance study of simultaneous desulfurization and denitrification and elemental sulfur recovery technology based on CABR in flue gas[D]. Harbin:Harbin Institute of Technology, 2021. [42] 张春燕.络合吸收-生物电化学还原烟气脱硝系统-新型电极制备及系统性能测试[D]. 杭州:浙江大学, 2019. Zhang C Y. Complexation and absorption-bioelectrochemical reduction system for flue gas denitrification:novel electrode preparation and system performance test[D]. Hangzhou:Zhejiang University, 2019. [43] 张艺鸣.基于微生物群体感应的氢基质生物膜反应器生物膜富集特性研究[D]. 桂林:桂林理工大学, 2021. Zhang Y M. Characterisation of biofilm enrichment in hydrogen substrate biofilm reactor based on microbial community sensing[D]. Guilin:Guilin University of Technology, 2021. [44] Xiong M Y, Shelobolinae S, Rodene E. Potential for microbial oxidation of ferrous iron in basaltic glass[J]. Astrobiology, 2015,15(5):331-340. [45] Franks A E, Nevin K P. Microbial Fuel Cells, A Current Review[J]. Energies, 2010,3(5):899-919. [46] Sun L, Toyonaga M, Ohashi A, et al. Lentimicrobium saccharophilum gen. nov., sp. nov., a strictly anaerobic bacterium representing a new family in the phylum Bacteroidetes, and proposal of Lentimicrobiaceae fam.nov[J]. International Journal of Systematic and Evolutionary Microbiology, 2016,66(7):2635-2642. |
|
|
|