|
|
|
| Temperature effect of 2450MHz electromagnetic wave during sludge dewatering |
| LI Dan-yi1, SANG Wen-jiao1, ZHANG Qian1, ZHANG Wan-jun2, FENG Yang-yang3, LI Zhi-xuan1 |
1. School of Civil Engineering & Architecture, Wuhan University of Technology, Wuhan 430070, China;
2. Central and Southern China Municipal Engineering Design & Research Institute Co. Ltd., Wuhan 430010, China;
3. Anhui Urban Construction Design Institute Co. Ltd., Hefei 230051, China |
|
|
|
|
Abstract In this paper, the influence of temperature on residual sludge properties and solubility was studied during the process of sludge dewatering with 2450MHz electromagnetic wave. Results showed that sludge volume index (SVI) decreased from 130.73mL/g to 95.25mL/g at 80℃, which improved the sludge settlement performance. At the same time, the centrifugal water content of the sludge achieved the lowest of 93.52% at 80℃ and the capillary suction time (CST) of the sludge decreased to 23.2s at 60℃. The value of the specific resistance to filtration (SRF), however, was always higher than the initial value of the raw sludge. Therefore, electromagnetic wave treatment of sludge could improve the dewaterability of centrifugal and plate frame filter press of residual sludge, while deteriorated the dewaterability of vacuum filtration. According to the analysis of the extracellular polymeric substances (EPS) and the soluble chemical oxygen demand (SCOD) in the supernatant, higher temperature was beneficial for the solubilization of sludge. The SCOD raised from the initial value of 124.1mg/L to 883.4mg/L at 80℃. The disruption of microbial cell in sludge was more obvious, when the sludge temperature was higher than 60℃. The EPS in the sludge was closely related to the change of dewaterability of the sludge.
|
|
Received: 12 April 2018
|
|
|
|
|
|
| [1] |
张自杰.排水工程下册(第五版)[M]. 北京:中国建筑工业出版社, 2014:448-449.
|
| [2] |
Chen Z, Zhang W J, Wang D S, et al. Enhancement of activated sludge dewatering performance by combined composite enzymatic lysis and chemical re-flocculation with inorganic coagulants:Kinetics of enzymatic reaction and re-flocculation morphology[J]. Water Research, 2015,83:367-376.
|
| [3] |
Yu J, Guo M H, Xu X H, et al. The role of temperature and CaCl2 in activated sludge dewatering under hydrothermal treatment[J]. Water Research, 2014,50:10-17.
|
| [4] |
董立文,汪诚文,张鹤清,等.电导率对城镇污泥电渗透脱水效果的影响[J]. 中国环境科学, 2013,33(2):209-214.
|
| [5] |
Li H, Jin Y Y, Rasool B M, et al. Effects of ultrasonic disintegration on sludge microbial activity and dewaterability[J]. Journal of Hazardous Materials, 2009,161(2/3):1421-1426.
|
| [6] |
张浩,杨艳玲,李星,等.超声声能密度对净水厂污泥脱水性能的影响[J]. 中国环境科学, 2017,37(3):1009:1015.
|
| [7] |
Yu Q, Lei H Y, Li Z, et al. Physical and chemical properties of waste-activated sludge after microwave treatment[J]. Water Research, 2010, 44(9):2841-2849.
|
| [8] |
Wang N N, Wang P. Study and application status of microwave in organic wastewater treatment-A review[J]. Chemical Engineering Journal, 2016,283:193-214.
|
| [9] |
Li L, Yuan S H, Chen J, et al. Removal of ammonia nitrogen in wastewater by microwave radiation[J]. Journal of Hazardous Materials, 2009,161(2/3):1063-1068.
|
| [10] |
乔俊莲,郑广宏,徐文倩,等.微波协同活性炭法处理甲基橙废水的研究[J]. 水处理技术, 2008,34(9):23-25.
|
| [11] |
Yu Q, Lei H Y, Yu G W, et al. Influence of microwave irradition on sludge dewaterability[J]. Chemical Engineering Journal, 2009, 155(1/2):88-93.
|
| [12] |
田禹,方琳,黄君礼.微波辐射预处理对污泥结构及脱水性能的影响[J]. 中国环境科学, 2006,26(4):459-463.
|
| [13] |
Liu J B, Wei Y S, Li K, et al. Microwave-acid pretreatment:A potential process for enhancing sludge dewaterability[J]. Water Research, 2016,90:225-234.
|
| [14] |
龚雅君.电磁波预处理对剩余污泥絮凝脱水效果的影响研究[D]. 武汉:武汉理工大学, 2015.
|
| [15] |
国家环保总局.水和废水监测分析方法(第四版)[M]. 北京:中国环境科学出版社, 2002:105-106.
|
| [16] |
高磊,张诗文,叶蓉,等.生物裂解效应对污泥脱水减量的作用研究[J]. 中国环境科学, 2016,36(12):3717-3723.
|
| [17] |
于洁.热水解联合氯化钙改善污泥脱水性能[D]. 杭州:浙江大学, 2013.
|
| [18] |
刘欢,杨家宽,时亚非,等.不同调理方案下污泥脱水性能评价指标的相关性研究[J]. 环境科学, 2011,32(11):3394-3399.
|
| [19] |
牛中奇,侯建强,王海彬,等.电磁波的生物学窗效应[J]. 中国生物医学工程学报, 2003,22(2):126-132.
|
| [20] |
Claire B, Jean P D, Helene C. Effects of thermal treatments on five different waste activated sludge samples solubilisation, physical properties and anaerobic digestion[J]. Chemical Engineering Journal, 2008,139(2):236-244.
|
| [21] |
Wang L P, Li A M. Hydrothermal treatment coupled with mechanical expression at increased temperature for excess sludge dewatering:The dewatering performance and characteristics of products[J]. Water Research, 2015,68:291-303.
|
| [22] |
Wang Y W, Wei Y S, Liu J X. Effect of H2O2 dosing strategy on sludge pretreatment by microwave-H2O2 advanced oxidation process[J]. Journal of Hazardous Materials, 2009,169(1-3):680-684.
|
| [23] |
Mickael R, Jean V, Jeremy O, et al. Compression dewatering of municipal activated sludge:Effects of salt and pH[J]. Water Research, 2012,46(14):4448-4456.
|
| [24] |
Christopher F F. The rheological and physico-chemical characteristics of sewage sludges[J]. Enzyme and Microbial Technology, 2002,30(3):340-345.
|
|
|
|
