针铁矿强化剩余污泥与烟草废弃物厌氧发酵的研究

李小兰; 周芸; 陈志燕; 黄善松; 李小明; 贾海江; 徐雪芹

PDF(460 KB)

中国环境科学 ›› 2019, Vol. 39 ›› Issue (6) : 2475-2482.

固体废物

针铁矿强化剩余污泥与烟草废弃物厌氧发酵的研究

李小兰¹, 周芸¹, 陈志燕¹, 黄善松¹, 李小明², 贾海江¹, 徐雪芹¹

作者信息 +

Enhanced anaerobic fermentation of waste activated sludge and tobacco waste using Goethite

LI Xiao-lan¹, ZHOU Yun¹, CHEN Zhi-yan¹, HUANG Shan-song¹, LI Xiao-ming², JIA Hai-jiang¹, XU Xue-qin¹

Author information +

文章历史 +

摘要

以剩余污泥和烟草废弃物为研究对象，探究了针铁矿对有机物厌氧消化产甲烷的影响.针铁矿投加能提高消化产气率至359.4mL/g，显著高于空白对照组.针铁矿有助于混合气体中甲烷含量的升高并减少CO₂的体积分数.针铁矿利于剩余污泥和烟草废弃物共消化过程有机物溶出，纤维素减量，从而为产甲烷古菌提供充足的消化底物.针铁矿利于酸化代谢过程，在针铁矿投加组中挥发性脂肪酸的最大产量仅为56.2mg/g，显著低于空白组，此外针铁矿促进丙酸的合成.针铁矿促进乙酸降解，在消化第1d，针铁矿投加实验组中乙酸降解率高达65.5%，较高于空白组中的56.6%.酶活性分析表明针铁矿促进水解，酸化及产甲烷过程关键酶.Methanothrix和Methanobacterium是产甲烷阶段重要微生物，454高通量测序表明针铁矿提高Methanothrix和Methanobacterium的相对丰度至59.6%和23.5%，显著高于空白对照组.

Abstract

The effect of goethite on methane production by anaerobic digestion of organic matter was studied with waste activated sludge and tobacco waste as research objects. The addition of goethite increased digestive gas production rate to 359.4mL/g, which was significantly higher than that in the blank. Goethite contributed to the increase of methane content in mixed gases and reduced the volume fraction of CO₂. Goethite was conducive to the dissolution of organic matter during co-digestion of waste activated sludge and tobacco waste, and cellulose decreases to provide sufficient digestive substrate for methanogenesis Archaea. Goethite was beneficial to acidification metabolism. The maximum yield of volatile fatty acids in goethite group was only 56.2mg/g, which was significantly lower than that in blank. In addition, goethite promoted the synthesis of propionic acid. Goethite promoted the degradation of acetic acid. On the first day of digestion, the degradation rate of acetic acid reached 65.5% in the goethite group, which was higher than 56.6% in the blank. Enzyme activity analysis indicated that goethite promoted the key enzymes of hydrolysis, acidification and methanogenesis. Methanothrix and Methanobacterium are the important microorganisms in methanogenesis stage, and 454high-throughput sequencing showed that goethite increased the relative abundance of Methanothrix and Methanobacterium to 59.6% and 23.5%.

导出引用

李小兰, 周芸, 陈志燕, 黄善松, 李小明, 贾海江, 徐雪芹. 针铁矿强化剩余污泥与烟草废弃物厌氧发酵的研究[J]. 中国环境科学. 2019, 39(6): 2475-2482

LI Xiao-lan, ZHOU Yun, CHEN Zhi-yan, HUANG Shan-song, LI Xiao-ming, JIA Hai-jiang, XU Xue-qin. Enhanced anaerobic fermentation of waste activated sludge and tobacco waste using Goethite[J]. China Environmental Science. 2019, 39(6): 2475-2482

中图分类号： X703

参考文献

[1] Duan X, Wang X, Xie J, et al. Effect of nonylphenol on volatile fatty acids accumulation during anaerobic fermentation of waste activated sludge[J]. Water Research, 2016,105:209-217.
[2] Dai X, Duan N, Dong B, et al. High-solids anaerobic co-digestion of sewage sludge and food waste in comparison with mono digestions:stability and performance[J]. Waste Management, 2013,33(2):308-316.
[3] Wang D, Zhao J, Zeng G, et al. How does poly (hydroxyalkanoate) affect methane production from the anaerobic digestion of waste-activated sludge?[J]. Environmental Science & Technology, 2015, 49(20):12253-12262.
[4] Jain S, Jain S, Wolf I T, et al. A comprehensive review on operating parameters and different pretreatment methodologies for anaerobic digestion of municipal solid waste[J]. Renewable and Sustainable Energy Reviews, 2015,52:142-154.
[5] Caporgno M P, Trobajo R, Caiola N, et al. Biogas production from sewage sludge and microalgae co-digestion under mesophilic and thermophilic conditions[J]. Renewable Energy, 2015,75:374-380.
[6] 郝晓地,唐兴,曹达啓.剩余污泥厌氧共消化技术研究现状及应用趋势[J]. 环境工程学报, 2016,10(12):6809-6818.Hao Xiaodi, Tangxing, Cao Daqi. Research status and application trend of anaerobic co-digestion technology of excess sludge[J]. Journal of Environmental Engineering, 2016,10(12):6809-6818.
[7] Zhao J, Liu Y, Wang D, et al. Potential impact of salinity on methane production from food waste anaerobic digestion[J]. Waste Management, 2017,67:308-314.
[8] Fonoll X, Astals S, Dosta J, et al. Anaerobic co-digestion of sewage sludge and fruit wastes:evaluation of the transitory states when the co-substrate is changed[J]. Chemical Engineering Journal, 2015,262:1268-1274.
[9] Liu Y, Dong J, Liu G, et al. Co-digestion of tobacco waste with different agricultural biomass feedstocks and the inhibition of tobacco viruses by anaerobic digestion[J]. Bioresource Technology, 2015, 189:210-216.
[10] 徐雪芹,李小兰,黄善松,等.游离亚硝酸预处理强化剩余污泥和烟草废物共消化产甲烷[J]. 中国环境科学, 2017,37(9):3423-3430.Xu Xueqin, Li Xiaolan, Huang Shansong, et al. Enhanced co-digestion of excess sludge and tobacco waste by free nitrite pretreatment[J]. China Environmental Science, 2017,37(9):3423-3430.
[11] Yue Z, Ma D, Wang J, et al. Goethite promoted anaerobic digestion of algal biomass in continuous stirring-tank reactors[J]. Fuel, 2015,159:883-886.
[12] Tan J, Wang J, Xue J, et al. Methane production and microbial community analysis in the goethite facilitated anaerobic reactors using algal biomass[J]. Fuel, 2015,145:196-201.
[13] 杨露露,岳正波,陈天虎,等.针铁矿对城市生活垃圾有机组分厌氧发酵的影响[J]. 环境科学, 2014,35(5):1988-1993.Yang Lulu, Yue Zhengbo, Chen Tianhu, et al. Effects of goethite on anaerobic fermentation of organic components in municipal solid waste[J]. Environmental Science, 2014,35(5):1988-1993.
[14] Zhao J, Gui L, Wang Q, et al. Aged refuse enhances anaerobic digestion of waste activated sludge[J]. Water Research, 2017,123:724-733.
[15] Alqaralleh R M, Kennedy K, Delatolla R. Improving biogas production from anaerobic co-digestion of Thickened Waste Activated Sludge (TWAS) and fat, oil and grease (FOG) using a dual-stage hyper-thermophilic/thermophilic semi-continuous reactor[J]. Journal of Environmental Management, 2018,217:416-428.
[16] Angeriz-Campoy R, Fdez-Güelfo L A, Tyagi V K, et al. New criteria to determine the destabilization of the acidogenic anaerobic co-digestion of organic fraction of municipal solid waste (OFMSW) with mixed sludge (MS)[J]. Bioresource Technology, 2018,248:174-179.
[17] Zhao J, Wang D, Li X, et al. Free nitrous acid serving as a pretreatment method for alkaline fermentation to enhance short-chain fatty acid production from waste activated sludge[J]. Water research, 2015,78:111-120.
[18] Zhang D, Fu X, Jia S, et al. Excess sludge and herbaceous plant co-digestion for volatile fatty acids generation improved by protein and cellulose conversion enhancement[J]. Environmental Science and Pollution Research, 2016,23(2):1492-1504.
[19] 胡玉瑛,吴静,王士峰,等.热处理对猪粪高固厌氧消化产甲烷能力的影响[J]. 环境科学, 2015,36(8):3094-3098.Hu Yuying, Wu Jing, Wang Shifeng, et al. Effects of heat treatment on the anaerobic digestion and methanogenesis of pig manure[J]. Environmental Science, 2015,36(8):3094-3098.
[20] 杨光,张光明,张盼月,等.添加三氯化铁对中温污泥厌氧消化优化调理[J]. 环境工程学报, 2017,11(8):4725-4731.Yang Guang, Zhang Guangming, Zhang Panyue, et al. Adding FeCl3to optimize anaerobic digestion of medium-temperature sludge[J]. Journal of Environmental Engineering, 2017,11(8):4725-4731.
[21] 李向明.针铁矿对模拟废水厌氧产甲烷过程的作用研究[D]. 合肥:合肥工业大学, 2017.Li Xiangming. Study on the effect of goethite on anaerobic methane production from simulated wastewater[D]. Hefei:Hefei University of Technology, 2017.
[22] 曹亚莉.固定化甲烷八叠球菌方法探究及其在高浓度有机废水处理中的应用[D]. 北京:首都师范大学, 2003.Cao Yali. Study on Immobilized Methanococcus Octopus and Its Application in the Treatment of High Concentration Organic Wastewater[D]. Beijing:Capital Normal University, 2003.