敏化剂特性及其耦合微波强化污泥破解研究

王子文; 张正豪; 王燕; 杨叙军; 杨汉文; 李冲; 王瑞; 陈安怡; 王硕; 李激

PDF(610 KB)

中国环境科学 ›› 2020, Vol. 40 ›› Issue (4) : 1586-1593.

水污染与控制

敏化剂特性及其耦合微波强化污泥破解研究

王子文¹, 张正豪¹, 王燕¹, 杨叙军², 杨汉文², 李冲², 王瑞², 陈安怡², 王硕^1,3, 李激^1,3

作者信息 +

Sensitizer characteristics and its enhancement performance to sludge decomposition associated with microwave

WANG Zi-wen¹, ZHANG Zheng-hao¹, WANG Yan¹, YANG Xu-jun², YANG Han-wen², LI Chong², WANG Rui², CHEN An-yi², WANG Shuo^1,3, LI Ji^1,3

Author information +

文章历史 +

摘要

采用污泥活性炭（SAC）、TiO₂/SAC、Fe₃O₄/SAC作为敏化剂，结合微波处理技术对污泥进行了预处理，通过分析滤液中COD、DNA、氮、磷、有机物的含量及组分，探索微波+敏化剂的最佳处理条件.SAC负载TiO₂和Fe₃O₄后强化了其对电磁波的介电损耗和磁滞损耗，tan δ_ε分别增加了1.8和1.3倍，tan δ_μ分别增加到0.26和0.67.TiO₂/SAC投加量为0.25g/gSS时，样品滤液的COD浓度是1900mg/L，是原污泥和单独微波处理的4.52倍和1.86倍；Fe₃O₄/SAC投加量为0.35g/gSS时，样品滤液的COD浓度是2540mg/L，是原污泥和单独微波处理的6.05倍和2.45倍，Fe₃O₄/SAC强化污泥破壁效果更好.此时，样品滤液中TN、TP、蛋白质、多糖浓度分别为原污泥的7.7倍、16倍、7.49倍和71.69倍，微生物胞内和胞外聚合物中的物质大量释放，滤液中的溶解性有机物大大增加.微波+敏化剂的预处理方法有利于对污泥中氮、磷及有机物进行资源化利用与回收.

Abstract

Sludge activated carbon (SAC), TiO₂/SAC and Fe₃O₄/SAC were used as the sensitizers to enhance the decomposition of excess sludge associated with microwave. Based on the analysis of chemical oxygen demand (COD), DNA, nitrogen, phosphorus and organic matters from the filtrate, the optimal conditions were investigated. After loading TiO₂ and Fe₃O₄ on SAC, the dielectric loss and hysteresis loss of electromagnetic wave were enhanced. When the dosage of TiO₂/SAC was 0.25g/gSS, the filtrate COD concentration was 1900mg/L, which increased by factors of 4.52 and 1.86 to the excess sludge and sludge treated by microwave, however, the addition of Fe₃O₄ is more conducive to the decomposition of excess sludge, the filtrate COD content was up to 2540mg/L, which was 6.05 times and 2.45 times higher than that of excess sludge and sludge treated by microwave. In addition, the filtrate total phosphorus (TP), total nitrogen (TN), protein and polysaccharides concentrations increased by factors of 7.7, 16, 7.49 and 71.69, indicating that a large amount of intracellular and extracellular polymeric substances released to filtrate and further greatly increased the soluble content of organic matters. The pretreatment method of microwave + sensitizer is beneficial to resource utilization and recovery of nitrogen, phosphorus and organic matters in excess sludge.

导出引用

王子文, 张正豪, 王燕, 杨叙军, 杨汉文, 李冲, 王瑞, 陈安怡, 王硕, 李激. 敏化剂特性及其耦合微波强化污泥破解研究[J]. 中国环境科学. 2020, 40(4): 1586-1593

WANG Zi-wen, ZHANG Zheng-hao, WANG Yan, YANG Xu-jun, YANG Han-wen, LI Chong, WANG Rui, CHEN An-yi, WANG Shuo, LI Ji. Sensitizer characteristics and its enhancement performance to sludge decomposition associated with microwave[J]. China Environmental Science. 2020, 40(4): 1586-1593

中图分类号： X703.5

参考文献

[1] Sándor B, Zsuzsanna L, Zsuzsanna H H, et al. Comparison of the effects of microwave irradiation with different intensities on the biodegradability of sludge from the dairy- and meat-industry[J]. Bioresource Technology, 2011,102(2):814-821.
[2] Bing T, Lin F Y, Shao S H, et al. Energy efficiency of pre-treating excess sewage sludge with microwave irradiation[J]. Bioresource Technology, 2010,101(14):5092-5097.
[3] Tai HS, Jou CJG. Application of granular activated carbon packed-bed reactor in microwave radiation field to treat phenol[J]. Chemosphere, 1999,38(11):2667-2680.
[4] 吴慧英.微波辐射联用活性炭强化有毒物质去除及再生活性炭研究[D]. 湖南:湖南大学, 2011. Wu H Y. The study on microwave radiation combined with activated carbon to strengthen the removal of poisonous substance and regenerate activated carbon[D]. Hunan:Hunan University, 2011.
[5] 吴艳凤.二氧化钛基复合纤维的力学性能与吸波性能[D]. 哈尔滨:哈尔滨工业大学, 2018. Wu Y F. Mechanical and microwave absorbing properties of titania-based composite fibers[D]. Harbin:Harbin Institute of Technology, 2018.
[6] Liu P, Yao Z, Ng V M H, et al. Facile synthesis of ultrasmall Fe₃O₄ nanoparticles on mxenes for high microwave absorption performance[J]. Composites Part A:Applied Science and Manufacturing, 2018, 115:371-382.
[7] Cheng Y, Zhao H, Yang Z, et al. An unusual route to grow carbon shell on Fe₃O₄ microspheres with enhanced microwave absorption[J]. Journal of Alloys and Compounds, 2018,762:463-472.
[8] Guan B Y, Yu L, Li J, et al. A universal cooperative assembly-directed method for coating of mesoporous TiO₂ nanoshells with enhanced lithium storage properties[J]. Science Advances, 2016,2(3):e1501554.
[9] 马放,周家晖,郭海娟,等.磁性活性炭的制备及其吸附性能[J]. 哈尔滨工业大学学报, 2016,48(2):50-56. Ma F, Zhou J H, Guo H J, et al. Study on preparation and adsorption properties of magnetic activated carbon[J]. Journal of Harbin Institute of Technology, 2016,48(2):50-56.
[10] Qiang Y, Heng Y L, Zhong L, et al. Physical and chemical properties of waste-activated sludge after microwave treatment[J]. Water Research, 2010,44(9):2841-2849.
[11] 国家环境保护总局.水和废水监测分析方法[M]. 4版.北京:中国环境科学出版社, 2002:120-246. State Environmental Protection Administration. Water and wastewater monitoring and analysis methods (Fourth Edition)[M]. Beijing:China Environmental Science Press, 2002:120-246.
[12] Tarayre, Cédric, Clercq L D, et al. New perspectives for the design of sustainable bioprocesses for phosphorus recovery from waste[J]. Bioresource Technology, 2016,206:264-274.
[13] 党琦,于涌杰,程谊,等.过硫酸钾氧化法测定溶解性有机氮含量和¹⁵N丰度方法研究[J]. 土壤, 2013,45(6):999-1002. Dang Q, Yu Y J, Cheng Y, et al. Persulfate digestion method for analyzing dissolved organic nitrogen concentration and ¹⁵N excess in soils extracts[J]. Soils, 2013,45(6):999-1002.
[14] Chen W, Westerhoff P, Leenheer J A, et al. Fluorescence excitation-Emission matrix regional integration to quantify spectra for dissolved organic matter[J]. Environmental Science & Technology, 2003,37(24):5701-5710.
[15] Liu Y, Liu Z, Zhang A, et al. The role of EPS concentration on membrane fouling control:Comparison analysis of hybrid membrane bioreactor and conventional membrane bioreactor[J]. Desalination, 2012,305(5):38-43.
[16] Saini P. Intrinsically conducting polymer-based blends and composites for electromagnetic interference shielding:Theoretical and experimental aspects[M]//Fundamentals of conjugated polymer blends, copolymers and composites:synthesis, properties and applications. John Wiley & Sons, Inc, 2015:449-518.
[17] Peng S, Zhan C G. Preparation of steel slag porous sound-absorbing material using coal powder as pore former[J]. Journal of Environmental Sciences, 2015,36(10):67-75.
[18] 张刚.活性炭负载二氧化钛去除水中锑(Sb)的研究[D]. 昆明:昆明理工大学, 2017. Zhang G. Removal of antimony from raw water by activated carbon supported titanium dioxide[D]. Kuming:Kunming University of Science And Technology, 2017.
[19] Zhang Y, Xiong X, Han Y, et al. Application of titanium dioxide-loaded activated carbon fiber in a pulsed discharge reactor for degradation of methyl orange[J]. Chemical Engineering Journal, 2010, 162(3):1045-1049.
[20] Wang L, Li J, Wang Y, et al. Preparation of nanocrystalline Fe₃O₄ ferrite and their adsorption capability for Congo red[J]. Journal of Hazardous Materials, 2011,196:342-349.
[21] Zhang Y, Nan Z. Preparation of magnetic ZnLa_0.02Fe_1.98O₄/MWCNTs composites and investigation on its adsorption of methyl orange from aqueous solution[J]. Materials Research Bulletin, 2015,66:176-185.
[22] 李妤婕.生物模板法制备竹炭(BC)基复合材料及吸波性能研究[D]. 西安:西安建筑科技大学, 2018. Li J Y. Study on bamboo charcoal(BC)-based composites prepared by biological template method and their wave absorbing properties[D]. Xi'an:Xi'an University of Architecture and Technology, 2018.
[23] Lew A, Krutzik P O, Hart M E, et al. Increasing rates of reaction:Microwave-assisted organic synthesis for combinatorial chemistry. Journal of Combinatorial Chemistry[J]. 2002,4(2):95-105.
[24] Xu D C, Zhong C Q, Yin K H, et al. Alkaline solubilization of excess mixed sludge and the recovery of released phosphorus as magnesium ammonium phosphate[J]. Bioresource Technology, 2018,249:783-790.
[25] Fatma S, Susana G L, Daniel S, et al. Microwave characterization of activated carbons[J]. Journal of Computer and Communications, 2018,6(1):112-123.
[26] Shao Y D, Bin Q, et al. Comparison of pretreatment methods for phosphorus release from waste activated sludge[J]. Chemical Engineering Journal, 2019,368:754-763.
[27] Yun F X, Fei Y, Liang Z, et al. Migration and transformation of phosphorus in municipal sludge by the hydrothermal treatment and its directional adjustment[J]. Waste Management, 2018,81:196-201.
[28] Zhuang X, Huang Y, Song Y, et al. The transformation pathways of nitrogen in sewage sludge during hydrothermal treatment[J]. Bioresource Technology, 2017,245:463-470.
[29] Dhar B R, Nakhla G, Ray M B. Techno-economic evaluation of ultrasound and thermal pretreatments for enhanced anaerobic digestion of municipal waste activated sludge[J]. Waste Management, 2012, 32(3):542-549.
[30] 王治军,王伟.剩余污泥的热水解试验[J]. 中国环境科学, 2005,25(S):56-60. Wang Z J, Wang W. Thermal hydrolysis test of surplus sludge[J]. China Environmental Science, 2005,25(S):56-60.
[31] Ke K X, Yun C, Xie J, et al. Comparison of different treatment methods for protein solubilisation from waste activated sludge[J]. Water Research, 2017,122:492-502.