环境因素交互影响下可降解塑料PBAT的老化行为

蒋晖; 朱丽帆; 杨超; 刘秀丽; 刘欣; 孙姣霞

PDF(2002 KB)

中国环境科学 ›› 2023, Vol. 43 ›› Issue (12) : 6530-6538.

环境生态

环境因素交互影响下可降解塑料PBAT的老化行为

蒋晖^1,2, 朱丽帆^1,2, 杨超³, 刘秀丽^1,2, 刘欣^1,2, 孙姣霞^1,2

作者信息 +

The aging behavior of degradable plastic PBAT under the interaction of environmental factors

JIANG Hui^1,2, ZHU Li-fan^1,2, YANG Chao³, LIU Xiu-li^1,2, LIU Xin^1,2, SUN Jiao-xia^1,2

Author information +

文章历史 +

摘要

为研究不同环境因素交互影响下可降解塑料的老化行为,以聚对苯二甲酸-己二酸丁二酯 (PBAT)为目标物,通过温度、湿度、光照为因素设置均匀和交互实验,探究不同因素交互影响下PBAT老化过程及潜在机理.多因素交互实验结合扫描电镜(SEM)、电子能谱面(EDS)的分析结果表明湿度对PBAT老化行为的影响最大,温度对PBAT老化行为的影响最小,且温度30.0℃、湿度60%、紫外光条件下老化效果最明显.通过X射线光谱(XPS)和X射线衍射(XRD)进一步分析PBAT在不同老化过程中化学键和结晶度的变化,其结果表明:在湿度和紫外光交互作用下,PBAT的碳氧双键减少而碳氧单键增加,碳氧双键被破坏形成了羧基,部分官能团中氧原子置换氢原子,有得失电子的行为出现,在其表面生成小分子物质CO₂和π-π键;在此交互老化过程中,PBAT的结晶度增大.

Abstract

In order to study the aging behavior of degradable plastics under the interaction of different environmental factors, poly (butyleneadipate-co-terephthalate) (PBAT) was used as the target. The aging process and potential mechanism of PBAT under the interaction of different factors were investigated by setting uniform and interactive experiments with temperature, humidity and light as factors. The results of multi-factor interaction experiments combined with scanning electron microscopy (SEM) and energy dispersive spectroscopy (EDS) showed that humidity had the greatest influence on the aging behavior of PBAT, and temperature had the least influence on the aging behavior of PBAT. The aging effect was the most obvious under the conditions of temperature 30.0 °C, humidity 60% and ultraviolet light. The changes of chemical bonds and crystallinity of PBAT during different aging processes were further analyzed by X-ray spectroscopy (XPS) and X-ray diffraction (XRD). The results showed that under the interaction of humidity and ultraviolet light, the carbon-oxygen double bond of PBAT decreased and the carbon-oxygen single bond increased. The carbon-oxygen double bond was destroyed to form a carboxyl group. The oxygen atoms in some functional groups replaced the hydrogen atoms, and the behavior of gain and loss of electrons appeared. The small molecule CO₂ and π-π bonds were formed on the surface; in this interactive aging process, the crystallinity of PBAT increased.

导出引用

蒋晖, 朱丽帆, 杨超, 刘秀丽, 刘欣, 孙姣霞. 环境因素交互影响下可降解塑料PBAT的老化行为[J]. 中国环境科学. 2023, 43(12): 6530-6538

JIANG Hui, ZHU Li-fan, YANG Chao, LIU Xiu-li, LIU Xin, SUN Jiao-xia. The aging behavior of degradable plastic PBAT under the interaction of environmental factors[J]. China Environmental Science. 2023, 43(12): 6530-6538

中图分类号： X171

参考文献

[1] Magnin A, Pollet E, Perrin R, et al. Enzymatic recycling of thermoplastic polyurethanes: Synergistic effect of an esterase and an amidase and recovery of building blocks[J]. Waste Management, 2019,85:141-150.
[2] 刘金为,张红英,曾琳.废弃塑料污染现状及治理策略研究[J]. 云南化工, 2021,48(6):14-15. Liu J W, Zhang H Y, Zeng L. Study on the pollution status and control strategy of waste plastics[J]. Yunnan Chemical Industry, 2021,48(6): 14-15.
[3] 杨光蓉,陈历睿,林敦梅.土壤微塑料污染现状、来源、环境命运及生态效应[J]. 中国环境科学, 2021,41(1):353-365. Yang G R, Chen L R, Lin D M. Pollution status, sources, environmental fate and ecological effects of soil microplastics[J]. China Environmental Science, 2021,41(1):353-365.
[4] 张宗飞,王锦玉,谢鸿洲,等.可降解塑料的发展现状及趋势[J]. 化肥设计, 2021,59(6):10-14,41. Zhang Z F, Wang J Y, Xie H Z, et al. Development status and trend of degradable plastics[J]. Fertilizer Design, 2021,59(6):10-14,41.
[5] Zuo L, Li H, Lin L, et al. Sorption and desorption of phenanthrene on biodegradable poly (butylene adipate co-terephtalate) microplastics[J]. Chemosphere, 2019,215:25-32.
[6] Phongam N, Dangtungee R, Siengchin S. Comparative studies on the mechanical properties of nonwoven- and woven-flax-fiber- reinforced poly (Butylene adipate-co-terephthalate)-based composite laminates[J]. Mechanics of Composite Materials, 2015,51(1):17-24.
[7] P T H, Carolin V, Johanna K, et al. Plastics of the future? The impact of biodegradable polymers on the environment and on society[J]. Angewandte Chemie (International ed. in English), 2019,58(1):50-62.
[8] 联合国新报告:生物可降解塑料的危害不比传统塑料小[J]. 环境与生活, 2022,(5):12-13. New United Nations report: Biodegradable plastics are no less harmful than traditional plastics[J]. Environment and Life, 2022,(5):12-13.
[9] 张小兵.我国生物可降解高分子新材料PBAT市场和产能分析[J]. 四川化工, 2021,24(4):4-7,25. Zhang X B. Analysis of the market and production capacity of PBAT, a new biodegradable polymer material in China[J]. Sichuan Chemical Industry, 2021,24(4):4-7,25.
[10] 尚晓煜,刘晓南,谢锦辉,等.PLA/PBAT复合材料研究进展[J]. 工程塑料应用, 2021,49(6):157-164. Shang X Y, Liu X N, Xie J H, et al. Research progress of PLA /PBAT composites[J]. Engineering Plastics Applications, 2021,49(6):157-164.
[11] 晏永祥,贺哲,张跃飞,等.可生物降解塑料PBAT共混改性研究进展[J]. 工程塑料应用, 2021,49(5):158-161. Yan Y X, He Z, Zhang Y F, et al. Research progress on blending modification of biodegradable plastic PBAT[J].Engineering Plastics Applications, 2021,49(5):158-161.
[12] 郭佳,张爽,黎万丽.生物降解树脂PBAT地膜应用的研究[J]. 聚酯工业, 2021,34(4):17-20. Guo J, Zhang S, Li W L. Study on the application of biodegradable resin PBAT mulch[J]. Polyester Industry, 2021,34(4):17-20.
[13] 马思睿,李舒行,郭学涛.微塑料的老化特性、机制及其对污染物吸附影响的研究进展[J]. 中国环境科学, 2020,40(9):3992-4003. Ma S R, Li S X, Guo X T. Research progress on the aging characteristics and mechanism of microplastics and their effects on pollutant adsorption[J]. China Environmental Science, 2020,40(9): 3992-4003.
[14] Wang C, Xian Z, Jin X, et al. Photo-aging of polyvinyl chloride microplastic in the presence of natural organic acids[J]. Water Research, 2020,183:116082.
[15] Green D S, Boots B, Sigwart J, et al. Effects of conventional and biodegradable microplastics on a marine ecosystem engineer (Arenicola marina) and sediment nutrient cycling[J]. Environmental pollution, 2016,208:426-434.
[16] Zhu K, Jia H, Sun Y, et al. Long-term phototransformation of microplastics under simulated sunlight irradiation in aquatic environments: Roles of reactive oxygen species[J]. Water Research, 2020,173:115564.
[17] Liu P, Zhan X, Wu X, et al. Effect of weathering on environmental behavior of microplastics: Properties, sorption and potential risks[J]. Chemosphere, 2020,242:125193.
[18] Sun Y, Yuan J, Zhou T, et al. Laboratory simulation of microplastics weathering and its adsorption behaviors in an aqueous environment: A systematic review[J]. Environmental Pollution, 2020,265:114864.
[19] K A Ppler A, Windrich F, L O Der M G, et al. Identification of microplastics by FTIR and Raman microscopy: a novel silicon filter substrate opens the important spectral range below 1300cm- 1for FTIR transmission measurements[J]. Analytical and bioanalytical chemistry, 2015,407(22):6791-6801.
[20] Ding L, Mao R, Ma S, et al. High temperature depended on the ageing mechanism of microplastics under different environmental conditions and its effect on the distribution of organic pollutants[J]. Water Research, 2020,174:115634.
[21] Kedzierski M, D'Almeida M, Magueresse A, et al. Threat of plastic ageing in marine environment. Adsorption/desorption of micropollutants[J]. Marine Pollution Bulletin, 2018,127:684-694.
[22] Upadhyay K R, Naicker S, Barman A, et al. Fabrication of free-standing graphene oxide films using a facile approach toluene swollen paraffin peeling and green reduction of these films into highly conductive reduced graphene oxide films[J]. Chemical Engineering Journal, 2018,354:149-161.
[23] Kartik B, C A B, Kimya R, et al. Aging of microplastics increases their adsorption affinity towards organic contaminants[J]. Chemosphere, 2022,298:134238.
[24] 曹卓华,鲁姣,应雨婷,等.响应面法优化微波辅助黄酒酒糟木糖提取工艺[J]. 食品工业, 2023,44(2):72-76. Cao Z H, Lu J, Ying Y T, et al. Optimization of microwave-assisted xylose extraction from rice wine lees by response surface methodology[J]. Food Industry, 2023,44(2):72-76.
[25] 李莉,张赛,何强,等.响应面法在试验设计与优化中的应用[J]. 实验室研究与探索, 2015,34(8):41-45. Li L, Zhang S, He Q, et al. Application of response surface methodology in experimental design and optimization[J]. Laboratory Research and Exploration, 2015,34(8):41-45.
[26] Mäkelä M. Experimental design and response surface methodology in energy applications: A tutorial review[J]. Energy Conversion and Management, 2017,151:630-640.
[27] Halle T A, Ladirat L, Martignac M, et al. To what extent are microplastics from the open ocean weathered?[J]. Environmental Pollution, 2017,227:167-174.
[28] Tang J, Li W, Pan R, et al. Synthesis and structure control of a new kind of inelastomer impact modifier with core-shell structure and impact modification to PVC/CPE[J]. Chemical Research in Chinese Universities, 2000,(2):152-155.
[29] Kai Z, Hossein A H, Aleksandra T, et al. Understanding plastic degradation and microplastic formation in the environment: A review[J]. Environmental Pollution, 2021,274:116554.
[30] Zaaba F N, Jaafar M. A review on degradation mechanisms of polylactic acid: Hydrolytic, photodegradative, microbial, and enzymatic degradation[J]. Polymer Engineering & amp; Science, 2020,60(9):2061-2075.
[31] Daichi N, Feng W, K A M, et al. Biodegradable composites developed from PBAT/PLA binary blends and silk powder: compatibilization and performance evaluation[J]. ACS omega, 2018,3(10):12412-12421.
[32] 司鹏,郝妮媛,刘阳,等.PLA/PBAT薄膜的制备及其降解性能研究[J]. 塑料科技, 2015,43(10):68-72. Si P, Hao N Y, Liu Y, et al. Preparation and degradation properties of PLA /PBAT films[J]. Plastic Technology, 2015,43(10):68-72.
[33] Tang C C, Chen H I, Brimblecombe P, et al. Morphology and chemical properties of polypropylene pellets degraded in simulated terrestrial and marine environments[J]. Marine Pollution Bulletin, 2019,149: 110626.
[34] Gardette M, Perthue A, Gardette J, et al. Photo- and thermal-oxidation of polyethylene: Comparison of mechanisms and influence of unsaturation content[J]. Polymer Degradation and Stability, 2013,98(11):2383-2390.
[35] 陈苏,刘颖,张晓莹,等.微塑料老化行为及其对重金属吸附影响的研究进展[J]. 生态与农村环境学报, 2023,39(1):12-19. Chen S, Liu Y, Zhang X Y, et al. Research progress on aging behavior of microplastics and its effect on heavy metal adsorption[J]. Journal of Ecology and Rural Environment, 2023,39(1):12-19.
[36] 张浩,郭锋锋,潘响亮,等.模拟老化对聚丙烯塑料餐盒理化性质的影响[J]. 塑料科技, 2021,49(11):41-44. Zhang H, Guo F F, Pan X L, et al. Effects of simulated aging on the physicochemical properties of polypropylene plastic lunch boxes[J].Plastics Science and Technology, 2021,49(11):41-44.
[37] 郑涵月,孙姣霞,向红,等.生物可降解塑料PBAT/PLA在典型非生物降解环境下的降解[J]. 中国环境科学, 2023,43(8):4247-4254. Zheng H Y, Sun J X, Xiang H, et al. Degradation of biodegradable plastic PBAT /PLA in typical non-biodegradable environment[J]. China Environmental Science, 2023,43(8):4247-4254.
[38] 周隆晋,李佩瑛,程睿智,等.桐酸铁作为光敏剂光降解聚丙烯效果研究[J]. 精细化工中间体, 2023,53(2):64-70. Zhou LJ, Li P Y, Cheng R Z, et al. Study on the effect of iron tungstate as a photosensitizer on the photodegradation of polypropylene[J]. Fine Chemical Intermediates, 2023,53(2):64-70.
[39] 李玉竹,姚利辉,叶世强,等.生物降解材料在水环境中降解性能的研究进展[J]. 中国塑料, 2021,35(7):103-114. Li Y Z, Yao L H, Ye S Q, et al. Research progress on the degradation performance of biodegradable materials in water environment[J]. China Plastics, 2021,35(7):103-114.
[40] 邬学贤,张岩,叶淳懿,等.面向电子应用的聚合物化学镀前表面处理技术[J]. 化学进展, 2023,35(2):233-246. Wu X X, Zhang Y, Ye C Y, et al. Polymer surface treatment before electroless plating for electronic applications[J]. Progress in Chemistry, 2023,35(2):233-246.
[41] 何晓莉,龚芮,杨秀英,等.聚乳酸降解行为和抗老化改性研究进展[J]. 工程塑料应用, 2022,50(6):166-171. He X L, Gong R, Yang X Y, et al. Research progress on degradation behavior and anti-aging modification of polylactic acid[J]. Engineering Plastics Applications, 2022,50(6):166-171.
[42] 陈国栋,刘海成,孟无霜,等.微塑料老化的人工干预及理化特性表征研究进展[J]. 化工进展, 2022,41(12):6443-6453. Chen G D, Liu H C, Meng W S, et al. Research progress on artificial intervention and physicochemical characterization of microplastic aging[J]. Chemical Progress, 2022,41(12):6443-6453.
[43] Li X, Tan D, Xie L, et al. Effect of surface property of halloysite on the crystallization behavior of PBAT[J]. Applied Clay Science, 2018,157:218-226.
[44] 左林子,侯婉儿,王飞,等.微塑料的光老化过程及其携带内源污染物释放的研究进展[J]. 环境化学, 2022,41(7):2245-2255. Zuo L Z, Hou W E, Wang F, et al. Research progress on the photoaging process of microplastics and the release of endogenous pollutants[J]. Environmental Chemistry, 2022,41(7):2245-2255.
[45] Ouyang Z, Li S, Zhao M, et al. The aging behavior of polyvinyl chloride microplastics promoted by UV-activated persulfate process[J]. Journal of Hazardous Materials, 2022,424:127461.
[46] 陈守益.微塑料的老化过程及其对污染物吸附的影响机制[D]. 淮南:安徽理工大学, 2019. Chen S Y. The aging process of microplastics and its influence mechanism on pollutant adsorption[D]. Huainan: Anhui University of Science and Technology, 2019.