硅铝比对Cu/SSZ-13SCR活性位的影响

摘要
图/表
参考文献(48)
相关文章 (15)

全文: PDF (670 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要

采用固态离子交换法制备了不同硅铝比（Si/Al=5，10，25）的Cu/SSZ-13分子筛催化剂，探究硅铝比对其NH₃选择性催化还原（NH₃-SCR）活性位的影响规律，并通过X射线衍射（XRD），H₂程序升温还原（H₂-TPR），NO_x程序升温脱附（NO_x-TPD），NH₃程序升温脱附（NH₃-TPD），原位红外实验（in situ DRIFTS）等手段进行物化性质表征.活性测试结果表明，当Cu负载量为4wt%时，不同硅铝比的Cu/SSZ-13具有显著差异的SCR活性；其中，Cu/SSZ-13（10）的SCR活性最佳，200~450℃温度范围内NO转化率均大于80%.XRD和H₂-TPR结果表明，硅铝比会影响Cu/SSZ-13的Cu物种的分布和氧化还原性.NO_x-TPD和NH₃-TPD结果表明，3种催化剂中Cu/SSZ-13（10）具有最多Cu²⁺离子，Cu²⁺离子可以为Cu/SSZ-13（10）提供更多的NO_x吸附位点和Lewis酸性位点，而Lewis酸性位是Cu/SSZ-13主要的低温SCR活性位点，因此有利于NH₃_-SCR反应的进行.当硅铝比增加到25时，Cu/SSZ-13（25）的Lewis酸性位大量损失，导致其SCR活性明显下降.

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	秦萱
	尹德嘉
	余丽泽
	张涛
	常化振
	朱燕
	刘国华
	李俊华

关键词 ：氮氧化物, NH₃-SCR, Cu/SSZ-13, 硅铝比, 活性位点

Abstract：

Cu/SSZ-13catalysts with different Si/Al ratio were prepared by a solid-state ion exchange method, which were used for selective catalytic reduction of NO_x with NH₃ (NH₃-SCR) reaction. Various characterization methods, including X-ray diffraction (XRD), temperature programmed reduction with H₂ (H₂-TPR), temperature programmed desorption (TPD) of NO_x, temperature programmed desorption (TPD) of NH₃, and in situ diffuse reflectance FTIR spectroscopy (in situ DRIFTS), were used to elucidate the different catalytic performance over these Cu/SSZ-13catalysts. Compared with Cu/SSZ-13(25) and Cu/SSZ-13(5), Cu/SSZ-13(10) showed relatively superior SCR activity, with more than 80% NO conversion between 200 and 450℃. The XRD and H₂-TPR results suggested that Si/Al ratio could influence the dispersion of Cu species and redox property of Cu/SSZ-13 catalysts. The XRD and H₂-TPR results indicated that there were the most isolated Cu²⁺ ions existed in Cu/SSZ-13(10). Cu²⁺ ions could provide NO_x-adsorbed sites and Lewis acid sites over Cu/SSZ-13, which mainly account for its low-temperature SCR activity. However, the NO conversion of Cu/SSZ-13(25) decreased obviously in the whole temperature range, due to the significant loss of Lewis acid sites.

Key words： nitrogen oxide NH₃-SCR Cu/SSZ-13 Si/Al ratio active site

收稿日期: 2019-07-18

PACS:

X505

基金资助:

中国人民大学2019年度‘中央高校建设世界一流大学（学科）和特色发展引导专项资金’资助项目

通讯作者: 张涛,讲师,zhangt@ruc.edu.cn;朱燕,高级工程师,zhuyan@ruc.edu.cn E-mail: zhangt@ruc.edu.cn;zhuyan@ruc.edu.cn

作者简介: 秦萱(1996-),女,河北辛集人,中国人民大学硕士研究生,主要从事柴油车尾气NO_x控制研究.发表论文1篇.

引用本文:

秦萱, 尹德嘉, 余丽泽, 张涛, 常化振, 朱燕, 刘国华, 李俊华. 硅铝比对Cu/SSZ-13SCR活性位的影响[J]. 中国环境科学, 2020, 40(2): 591-599. QIN Xuan, YIN De-jia, YU Li-ze, ZHANG Tao, CHANG Hua-zhen, ZHU Yan, LIU Guo-hua, LI Jun-hua. Effect of Si/Al ratio on the SCR active sites of Cu/SSZ-13. CHINA ENVIRONMENTAL SCIENCECE, 2020, 40(2): 591-599.

链接本文:

http://www.zghjkx.com.cn/CN/ 或 http://www.zghjkx.com.cn/CN/Y2020/V40/I2/591

[1]	中华人民共和国环境保护部.中国机动车环境管理年报[R]. 2018. Ministry of Environmental Protection. China motor vehicle environmental management annual report[R]. 2018.
[2]	Busca G, Lietti L, Ramis G, et al. Chemical and mechanistic aspects of the selective catalytic reduction of NOx by ammonia over oxide catalysts:A review[J]. Applied. Catalysis. B:Environmental, 1998,18:1-36.
[3]	戴波,张松,顾明言,等. Ce改性钒磷氧催化剂的制备及其脱硝性能研究[J]. 中国环境科学, 2019,39(1):126-133. Dai B, Zhang S, Gu M, et al. Preparation of supported VPO catalyst modified by Ce and the investigation of its denitration performance[J]. China Environmental Science, 2019,39(1):126-133.
[4]	刘晶,熊志波,周飞,等.新型铈钨钛复合氧化物催化还原脱硝机理[J]. 中国环境科学, 2018,38(5):1670-1676. Liu J, Xiong Z, Zhou F, et al. The NH3-SCR mechanism of a novel cerium-tungsten-titanium mixed oxide catalyst prepared through the hydrothermal co-precipitation method modified by H2O2complex[J]. China Environmental Science, 2018, 38(5):1670-1676.
[5]	胡强,熊志波,白鹏,等.铈钛掺杂促进铁氧化物低温SCR脱硝性能的机理[J]. 中国环境科学, 2016,36(8):2304-2310. Hu Q, Xiong Z, Bai P, et al. Promotional mechanism of cerium oxide and titanium oxide doping on the low-temperature NH3-SCR activity of iron oxide[J]. China Environmental Science, 2016,36(8):2304-2310.
[6]	熊志波,金晶,路春美,等.铁基催化剂的微波水热处理对其SCR脱硝性能的影响[J]. 中国环境科学, 2014,34(7):1785-1789. Xiong Z, Jin J, Lu C, et al. Effect of microwave hydrothermal treatment for iron-based catalyst on its selective catalytic reduction of NO with NH3[J]. China Environmental Science, 2014,34(7):1785-1789.
[7]	Nova I, Epling B, Peden C. Challenges for catalytic exhaust after treatment[J]. Catalysis Today, 2014,231:1-2.
[8]	Li J, Chang H, Ma L, et al. Low-temperature selective catalytic reduction of NOx with NH3over metal oxide and zeolite catalysts-A review[J]. Catalysis Today, 2011,175(1):147-156.
[9]	翁端,王蕾,吴晓东,等.铜基小孔分子筛柴油车尾气脱硝催化材料研究进展[J]. 科技导报, 2013,31:68-73. Weng D, Wang L, Wu X, et al. Progress for Cu-based small pore molecular sieves as disel de-NOx catalysts[J]. Science Technology Review, 2013,31:68-73.
[10]	周子正,王智华,刘志明.小孔分子筛催化剂上氨选择性还原NOx的研究进展[J]. 中国科学:化学, 2018,48(6):562-573. Zhou Z, Wang Z, Liu Z. Recent advances in the selective catalytic reduction of NOx by NH3 over small-pore zeolite catalysts[J]. Science China (Chemistry), 2018,48:562-573.
[11]	Wang J, Zhao H, Haller G, et al. Recent advances in the selective catalytic reduction of NOx with NH3on Cu-Chabazite catalysts[J]. Applied Catalysis B:Environmental, 2017,202:346-354.
[12]	Wang D, Jang Y, Liu Y, et al. A comparison of hydrothermal aging effects on NH3-SCR of NOx over Cu-SSZ-13and Cu-SAPO-34catalysts[J]. Applied Catalysis B:Environmental, 2015,165:438-445.
[13]	Kim Y J, Lee J K, Min K M, et al. Hydrothermal stability of Cu-SSZ-13 for reducing NOx by NH3[J]. Journal of Catalysis, 2014,311:447-457.
[14]	Ye Q, Wang L, Yang R T. Activity, propene poisoning resistance and hydrothermal stability of copper exchanged chabazite-like zeolite catalysts for SCR of NO with ammonia in comparison to Cu/ZSM-5[J]. Applied Catalysis A:General, 2012,427-428:24-34.
[15]	Borfecchia E, Beato P, Svelle S, et al. Cu-CHA-a model system for applied selective redox catalysis[J]. Chemical Society Reviews, 2018, 47(22):8097-8133.
[16]	Kwak J H, Tonkyn R G, Kim D H, et al. Excellent activity and selectivity of Cu-SSZ-13in the selective catalytic reduction of NOx with NH3[J]. Journal of Catalysis, 2010,275(2):187-190.
[17]	Kwak J H, Tran D, Burton S D, et al. Effects of hydrothermal aging on NH3-SCR reaction over Cu/zeolites[J]. Journal of Catalysis, 2012, 287:203-209.
[18]	Paolucci C, Verma A A, Bates S A, et al. Isolation of the copper redox steps in the standard selective catalytic reduction on Cu-SSZ-13[J]. Angewandte Chemie International Edition, 2014,53(44):11828-11833.
[19]	Szanyi J, Kwak J H, Zhu H, et al. Characterization of Cu-SSZ-13NH3-SCR catalysts:an in situ FTIR study[J]. Phys Chem Chem Phys, 2013,15(7):2368-2380.
[20]	Tarot M, Iojoiu E E, Lauga V, et al. Influence of Na, P and (Na + P) poisoning on a model copper-ferrierite NH3-SCR catalyst[J]. Applied Catalysis B:Environmental, 2019,250:355-368.
[21]	Wang D, Zhang L, Li J, et al. NH3-SCR over Cu/SAPO-34-Zeolite acidity and Cu structure changes as a function of Cu loading[J]. Catalysis Today, 2014,231:64-74.
[22]	刘思远,郝瑞霞,刘航,等.硅铝比对分子筛吸附氨氮性能的影响[J] 中国环境科学, 2019,39:1026-1033. Liu S, Hao R, Liu H, Impact of silica-alumina ratio on ammonium adsorption by molecular sieves.[J]. China Environmental Science, 2019,39:1026-1033.
[23]	Deka U, Juhin A, Eilertsen E A, et al. Confirmation of isolated Cu2+ ions in SSZ-13zeolite as active sites in NH3-selective catalytic reduction[J]. The Journal of Physical Chemistry C, 2012,116(7):4809-4818.
[24]	Andersen C W, Bremholm M, Vennestrøm P N R, et al. Location of Cu2+ in CHA zeolite investigated by X-ray diffraction using the Rietveld/maximum entropy method[J]. IUCrJ, 2014,1(6):382-386.
[25]	周飞翔,汪俊,钱定利,等.金属阳离子对高硅分子筛催化氧化NO的影响[J]. 中国环境科学, 2018,38(4):1287-1294. Zhou F, Wang J, Qian D, et al. Influence of metal cations on catalytic oxidation of NO over high-silica zeolites.[J]. China Environmental Science, 2018,38(4):1287-1294.
[26]	Xie L, Liu F, Ren L, et al. Excellent performance of one-Pot synthesized Cu-SSZ-13catalyst for the selective catalytic reduction of NOx with NH3[J]. Environmental Science & Technology, 2013,48(1):566-572.
[27]	Liu J, Yu F, Liu J, et al. Synthesis and kinetics investigation of meso-microporous Cu-SAPO-34catalysts for the selective catalytic reduction of NO with ammonia[J]. Journal of Environmental Sciences, 2016,48:45-58.
[28]	Liu X, Wu X, Weng D, et al. Durability of Cu/SAPO-34catalyst for NOx reduction by ammonia:potassium and sulfur poisoning[J]. Catalysis Communications, 2015,59:35-39.
[29]	Gao F, Walter E D, Karp E M, et al. Structure-activity relationships in NH3-SCR over Cu-SSZ-13as probed by reaction kinetics and EPR studies[J]. Journal of Catalysis, 2013,300:20-29.
[30]	Cui X, Zhou J, Ye Z, et al. Selective catalytic oxidation of ammonia to nitrogen over mesoporous CuO/RuO2 synthesized by co-nanocasting-replication method[J]. Journal of Catalysis, 2010,270(2):310-317.
[31]	Wang A, Wang Y, Walter E D, et al. NH3-SCR on Cu, Fe and Cu + Fe exchanged beta and SSZ-13catalysts:Hydrothermal aging and propylene poisoning effects[J]. Catalysis Today, 2019,320:91-99.
[32]	Zhang T, Qiu F, Chang H, et al. Identification of active sites and reaction mechanism on low-temperature SCR activity over Cu-SSZ-13 catalysts prepared by different methods[J]. Catalysis Science & Technology, 2016,16:6294-6304.
[33]	Zhang T, Liu J, Wang D, et al. Selective catalytic reduction of NO with NH3 over HZSM-5-supported Fe-Cu nanocomposite catalysts:The Fe-Cu bimetallic effect[J]. Applied Catalysis B:Environmental, 2014, 148-149:520-531.
[34]	Gao F, Wang Y, Washton N M, et al. Effects of alkali and alkaline earth Co cations on the activity and hydrothermal stability of Cu/SSZ-13NH3-SCR catalysts[J]. ACS Catalysis, 2015,5(11):6780-6791.
[35]	Ma J, Si Z, Weng D, et al. Potassium poisoning on Cu-SAPO-34 catalyst for selective catalytic reduction of NOx with ammonia[J]. Chemical Engineering Journal, 2015,267:191-200.
[36]	Gao F, Walter E D, Washton N M, et al. Synthesis and evaluation of Cu/SAPO-34 catalysts for NH3-SCR 2:Solid-state ion exchange and one-pot synthesis[J]. Applied Catalysis B:Environmental, 2015,162:501-514.
[37]	Richter M, Fait M, Eckelt R, et al. Gas-phase carbonylation of methanol to dimethyl carbonate on chloride-free Cu-precipitated zeolite Y at normal pressure[J]. Journal of Catalysis, 2007,245(1):11-24.
[38]	Cao Y, Lan L, Feng X, et al. Cerium promotion on the hydrocarbon resistance of a Cu-SAPO-34NH3-SCR monolith catalyst[J]. Catalysis Science & Technology, 2015,5(9):4511-4521.
[39]	Zhang T, Qu R, Su W, et al. A novel Ce-Ta mixed oxide catalyst for the selective catalytic reduction of NOx with NH3[J]. Applied Catalysis B:Environmental, 2015,176-177:338-346.
[40]	Chen L, Li J, Ge M, et al. Enhanced activity of tungsten modified CeO2/TiO2 for selective catalytic reduction of NOx with ammonia[J]. Catalysis Today, 2010,153(3/4):77-83.
[41]	Fan C, Chen Z, Pang L, et al. The influence of Si/Al ratio on the catalytic property and hydrothermal stability of Cu-SSZ-13 catalysts for NH3-SCR[J]. Applied Catalysis A:General, 2018,550:256-265.
[42]	Wang D, Jangjou Y, Liu Y, et al. A comparison of hydrothermal aging effects on NH3-SCR of NOx over Cu-SSZ-13 and Cu-SAPO-34 catalysts[J]. Applied Catalysis B:Environmental, 2015,165:438-445.
[43]	Giordanino F, Borfecchia E, Lomachenko K A, et al. Interaction of NH3 with Cu-SSZ-13 catalyst:a complementary FTIR, XANES, and XES Study[J]. The Journal of Physical Chemistry Letters, 2014,5(9):1552-1559.
[44]	Luo J, Gao F, Kamasamudram K, et al. New insights into Cu/SSZ-13SCR catalyst acidity. Part I:nature of acidic sites probed by NH3titration[J]. Journal of Catalysis, 2017,348:291-299.
[45]	Zhang T, Chang H, You Y, et al. Excellent activity and selectivity of one-Pot Synthesized Cu-SSZ-13 Catalyst in the selective catalytic oxidation of ammonia to nitrogen[J]. Environmental Science & Technology, 2018,52(8):4802-4808.
[46]	Yu T, Hao T, Fan D, et al. Recent NH3-SCR Mechanism Research over Cu/SAPO-34 Catalyst[J]. The Journal of Physical Chemistry C, 2014,118(13):6565-6575.
[47]	Delahay G, Valade D, Guzmanvargas A, et al. Selective catalytic reduction of nitric oxide with ammonia on Fe-ZSM-5catalysts prepared by different methods[J]. Applied Catalysis B:Environmental, 2005,55(2):149-155.
[48]	Su W, Chang H, Peng Y, et al. Reaction pathway investigation on the selective catalytic reduction of NO with NH3 over Cu/SSZ-13 at low temperatures[J]. Environmental Science & Technology, 2015,49(1):467-473.