Optimization of nitrogen removal performance of partial nitrification AO process based on PVA-SA immobilized particles
LI Xiang1, PAN Zheng-wei2, HOU Lian-gang2, TANG Peng1, SHI Tian-hao2,3, LI Jun1, ZHENG Zhao-ming1
1. National Engineering Laboratory of Deep Treatment and Resource Utilization Technology of Municipal Wastewater, Beijing University of Technology, Beijing 100124, China; 2. China Construction First Group Construction & Development Co. LTD, Beijing 100102, China; 3. China Construction First Group Corporation Limited, Beijing 100161, China
Abstract:Partial nitrification activated sludge immobilized with polyvinyl alcohol-sodium alginate (Polyving Akohol-Sodium Alginate, PVA-SA) was used to treat domestic wastewater and achieve stable partial nitrification in a continuous flow AO (Anaerobic/Oxic) reactor. Using the response surface method, the effects of hydraulic retention time (HRT), internal recirculation ratio and filling rate on nitrite accumulation ratio (NAR) and total nitrogen removal nitrogen removal efficiency (NRE) were investigated, and a quadratic regression model was successfully established. The results showed that the system had the best performance in nitrogen removal with NAR and NRE reaching 86.22% and 86.56% when HRT, internal recirculation ratio and filling rate of aerobic section were controlled as 6.43h, 2.93, and 25%, respectively. In addition, it was observed by live and dead bacteria and Fluorescence In Situ Hybridization (FISH) that the live cells were mainly distributed in the range of 0~500μm on the surface of the particles, while the dead bacteria were distributed in the range of 0~300μm. FISH fluorescence was gradually decreased in intensity with the increase of depth. Finally, 16S rRNA sequencing results showed that the relative abundance of Nitrosomonas increased from 0.013% to 5.02% and Nitrospira increased from 0.055% to 1.99% in the immobilized particles of the long-term run compared with that of the partial nitrification activated sludge. The proportion of NOB in the nitrifying bacteria was reduced, while the proportion of AOB was increased, which contributed to the stabilization of nitrogen removal effect of partial nitrification. This study provides a promising technology for the engineering application of partial nitrification in municipal wastewater plants.
李享, 潘政伟, 侯连刚, 唐鹏, 石天浩, 李军, 郑照明. 基于PVA-SA包埋颗粒的短程硝化AO工艺脱氮性能优化[J]. 中国环境科学, 2024, 44(9): 4883-4892.
LI Xiang, PAN Zheng-wei, HOU Lian-gang, TANG Peng, SHI Tian-hao, LI Jun, ZHENG Zhao-ming. Optimization of nitrogen removal performance of partial nitrification AO process based on PVA-SA immobilized particles. CHINA ENVIRONMENTAL SCIENCECE, 2024, 44(9): 4883-4892.
[1] Yu Y, Chen G, Yu D, et al. Novel nitrogen removal process in marine aquaculture wastewater treatment using Enteromorpha ferment liquid as carbon [J]. Bioresource Technology, 2023,377:128913. [2] Rahimi S, Modin O, Mijakovic I. Technologies for biological removal and recovery of nitrogen from wastewater [J]. Biotechnology Advances, 2020,43:107570. [3] Jiang H, Li X, Zhang F, et al. Advanced nitrogen removal from mature landfill leachate based on novel step-draining partial nitrification-denitrification and Anammox process: Significance of low volume exchange ratio [J]. Bioresource Technology, 2022,364:128025. [4] Rong C, Luo Z, Wang T, et al. Biomass retention and microbial segregation to offset the impacts of seasonal temperatures for a pilot-scale integrated fixed-film activated sludge partial nitritation-anammox (IFAS-PN/A) treating anaerobically pretreated municipal wastewater [J]. Water Research, 2022,225:119194. [5] 方小月,杨宏,刘旭妍,等.基于包埋填料的短程硝化反硝化工艺的脱氮性能优化[J]. 环境工程学报, 2022,16(6):1979-1990. Fang X Y, Yang H, Liu X, et al. Optimization of nitrogen removal performance of a partial nitrification denitrification process based on embedded packing [J]. Journal of Environmental Engineering, 2022, 16(6):1979-1990. [6] Wang J, Peng Y, Zhang Q, et al. Advanced nitrogen removal in a single return anaerobic/aerobic/anoxic/aerobic (AnOAO) bioreactor treating municipal wastewater through hydroxylamine addition: Performance and microbial community [J]. Bioresource Technology, 2022,351: 126926. [7] Kim J, Guo X, Park H. Comparison study of the effects of temperature and free ammonia concentration on nitrification and nitrite accumulation [J]. Process Biochemistry, 2008,43(2):154-160. [8] Pedrouso A, Rí;o À V D, Morales N, et al. Nitrite oxidizing bacteria suppression based on in-situ free nitrous acid production at mainstream conditions [J]. Separation and Purification Technology, 2017,186:55-62. [9] Laureni M, Weissbrodt D G, Villez K, et al. Biomass segregation between biofilm and flocs improves the control of nitrite-oxidizing bacteria in mainstream partial nitritation and anammox processes [J]. Water Research, 2019,154:104-116. [10] Arnaldos M, Amerlinck Y, Rehman U, et al. From the affinity constant to the half-saturation index: Understanding conventional modeling concepts in novel wastewater treatment processes [J]. Water Research, 2015,70:458-470. [11] Yu C, Zhang X, Zhao S, et al. Sludge granulation and microbial activity in a stable CANON process by DO controlling and operating parameter optimization [J]. Biochemical Engineering Journal, 2021, 174:108126. [12] Guo J, Peng Y, Peng C, et al. Energy saving achieved by limited filamentous bulking sludge under low dissolved oxygen [J]. Bioresource Technology, 2010,101(4):1120-1126. [13] Gu X, Huang Y, Hu Y, et al. Inhibition of nitrite-oxidizing bacteria in automatic recycling PN/ANAMMOX under mainstream conditions [J]. Bioresource Technology, 2021,342:125935. [14] Miao Y, Zhang L, Yang Y, et al. Start-up of single-stage partial nitrification-anammox process treating low-strength swage and its restoration from nitrate accumulation [J]. Bioresource Technology, 2016,218:771-779. [15] Zhao J, Lei S, Cheng G, et al. Comparison of inhibitory roles on nitrite-oxidizing bacteria by hydroxylamine and hydrazine during the establishment of partial nitrification [J]. Bioresource Technology, 2022,355:127271. [16] Ahmad H A, Ni S, Ahmad S, et al. Gel immobilization: A strategy to improve the performance of anaerobic ammonium oxidation (anammox) bacteria for nitrogen-rich wastewater treatment [J]. Bioresource Technology, 2020,313:123642. [17] Xu X, Jin Z, Wang B, et al. Treatment of high-strength ammonium wastewater by polyvinyl alcohol–sodium alginate immobilization of activated sludge [J]. Process Biochemistry, 2017,63:214-220. [18] Bae H, Choi M, Chung Y, et al. Core-shell structured poly(vinyl alcohol)/sodium alginate bead for single-stage autotrophic nitrogen removal [J]. Chemical Engineering Journal, 2017,322:408-416. [19] Chou W, Tseng S, Ho C, et al. Highly efficient partial nitrification by polyvinyl alcohol-alginate immobilized cells [J]. Journal of the Chinese Institute of Engineers, 2012,35(6):793-801. [20] Liu C, Yu D, Wang Y, et al. A novel control strategy for the partial nitrification and anammox process (PN/A) of immobilized particles: Using salinity as a factor [J]. Bioresource Technology, 2020,302: 122864. [21] Rice E W, Bridgewater L, American P H A. Standard methods for the examination of water and wastewater [M]. American public health association Washington, DC, 2012. [22] Chen G H, Li J, Tabassum S, et al. Anaerobic ammonium oxidation (ANAMMOX) sludge immobilized by waterborne polyurethane and its nitrogen removal performance-a lab scale study [J]. Rsc Advances, 2015,5(32):25372-25381. [23] Cescut J, Severac E, Molina-Jouve C, et al. Optimizing pressurized liquid extraction of microbial lipids using the response surface method [J]. Journal of Chromatography A, 2011,1218(3):373-379. [24] 马勇,王淑莹,曾薇,等.A/O生物脱氮工艺处理生活污水中试(一)短程硝化反硝化的研究[J]. 环境科学学报, 2006,(5):703-709. MA Y, WANG S Y, ZENG W, et al. Study on partial nitrification and denitrification of domestic wastewater by A/O biological denitrification process [J]. Journal of Environmental Science, 2006,(5): 703-709. [25] 张新波,宋姿,祁丽,等.聚氨酯海绵载体填充率对MBBR脱氮的影响[J]. 中国给水排水, 2017,33(15):78-81. Zhang X B, Song Z, Qi L, et al. Effect of polyurethane sponge carrier filling rate on nitrogen removal in MBBR [J]. China Water Supply and Drainage, 2017,33(15):78-81. [26] Minh N T, Choi M, Park N, et al. Critical design factors for polyvinyl alcohol hydrogel entrapping ammonia-oxidizing bacteria: biomass loading, distribution of dissolved oxygen, and bacterial liability [J]. Environmental Engineering Research, 2020,26(2):200010-0. [27] Song Y, Ishii S, Rathnayake L, et al. Development and characterization of the partial nitrification aerobic granules in a sequencing batch airlift reactor [J]. Bioresource Technology, 2013,139:285-291. [28] He Q, Zhang W, Zhang S, et al. Enhanced nitrogen removal in an aerobic granular sequencing batch reactor performing simultaneous nitrification, endogenous denitrification and phosphorus removal with low superficial gas velocity [J]. Chemical Engineering Journal, 2017, 326:1223-1231. [29] 陈燕,刘国华,范强,等.不同溶解氧条件下A/O系统的除碳脱氮效果和细菌群落结构变化[J]. 环境科学, 2015,36(7):2610-2616. Chen Y, Liu G H, Fan Q, et al. Effect of carbon removal and denitrogenation and change of bacterial community structure in A/O system under different dissolved oxygen conditions [J]. Environmental Science, 2015,36(7):2610-2616. [30] Hill V R, Kahler A M, Jothikumar N, et al. Multistate evaluation of an ultrafiltration-based procedure for simultaneous recovery of enteric microbes in 100-liter tap water samples [J]. Applied & Environmental Microbiology, 2007,73(13):4218. [31] Du S, Yu D, Zhao J, et al. Achieving deep-level nutrient removal via combined denitrifying phosphorus removal and simultaneous partial nitrification-endogenous denitrification process in a single-sludge sequencing batch reactor [J]. Bioresource Technology, 2019,289: 121690. [32] Wang X J D G. Stable nitrite accumulation and phosphorous removal from nitrate and municipal wastewaters in a combined process of endogenous partial denitrification and denitrifying phosphorus removal (EPDPR)[J]. Chemical engineering journal. 2019,355:560-571. [33] Rongsayamanont C, Limpiyakorn T, Khan E. Effects of inoculum type and bulk dissolved oxygen concentration on achieving partial nitrification by entrapped-cell-based reactors [J]. Bioresource Technology, 2014,164:254-263. [34] Rongsayamanont C, Limpiyakorn T, Law B, et al. Relationship between respirometric activity and community of entrapped nitrifying bacteria: Implications for partial nitrification [J]. Enzyme and Microbial Technology, 2010,46(3):229-236.