高温厌氧膜生物反应器处理餐厨废水的启动

姜萌萌; 林敏; 郑晓宇; 乔玮; 侯振; 董仁杰

PDF(742 KB)

中国环境科学 ›› 2020, Vol. 40 ›› Issue (12) : 5318-5324.

水污染与控制

高温厌氧膜生物反应器处理餐厨废水的启动

姜萌萌¹, 林敏¹, 郑晓宇², 乔玮¹, 侯振¹, 董仁杰¹

作者信息 +

Start-up operation of anaerobic membrane bioreactor treating food wastewater under thermophilic condition

JIANG Meng-meng¹, LIN Min¹, ZHENG Xiao-yu², QIAO Wei¹, HOU Zhen¹, DONG Ren-jie¹

Author information +

文章历史 +

摘要

以除油后的实际餐厨废水为原料，在高温（50±1）℃条件下利用浸没式纤维膜生物反应器（AnMBR）进行连续厌氧消化试验，以水力停留时间（HRT）20d启动，HRT 15d运行，直到发生膜污染，试验共进行了50d.研究了反应器启动和运行期间的发酵特性和膜过滤性能.研究表明，反应器30d完成了启动，在HRT 15d条件下，甲烷产量达到578L/kgVS_in，COD和挥发性固体（VS）去除率均达到94%以上，膜出水总挥发性脂肪酸（TVFA）浓度为（103±77） mg/L，其中乙酸浓度为（98±28） mg/L.系统pH 8.26，具有良好的稳定性.膜通量设定为9L/（m²·h），运行30d后发生了明显的膜污染，伴随着反应器内挥发性悬浮固体（VSS）浓度由8.1g/L逐渐增加到18/L.在处理高浓度餐厨废水时，AnMBR可以短时间启动且在8.5kgCOD/（m³·d）的高负荷条件下稳定运行，反应器中污泥浓度和溶解性微生物产物的增加导致膜过滤性能下降是导致膜污染的主要因素.

Abstract

In this study, the actual food wastewater was used as raw material to do experiment with an immersed hollow fiber membrane bioreactor (AnMBR) under thermophilic condition (50±1)℃ for 50days until the membrane fouling occurred. The reactor was started with a hydraulic retention time (HRT) of 20days, and operated at HRT 15days, the system stability and membrane filtration characteristics were studied. The experiment showed that under the above condition, the startup stage can be completed in one month. At HRT 15days, the methane production reached to 578L/kgVS_in, the total chemical oxygen demand (TCOD) and volatile solid (VS) removal rates were both higher than 94%; no volatile fatty acid (VFA) accumulated with a concentration of (103±77) mg/L of the permeate and dominant with acetate ((98±28) mg/L) showed a good stability of the system combined with a pH of 8.26. The membrane flux was set to 9L/(m²·h), membrane occurred parentally after 30days with the volatile suspended solids (VSS) concentration gradually increased from 8.1g/L to 18.0g/L. Research showed that the AnMBR can start in a short time during treating high concentration food wastewater, and run stable under high organic loading rate such as 8.5kgCOD/(m³·d). Long time filtration of the membrane leading to an increasing of VSS and soluble microbial products which may be the main reason causing membrane fouling.

导出引用

姜萌萌, 林敏, 郑晓宇, 乔玮, 侯振, 董仁杰. 高温厌氧膜生物反应器处理餐厨废水的启动[J]. 中国环境科学. 2020, 40(12): 5318-5324

JIANG Meng-meng, LIN Min, ZHENG Xiao-yu, QIAO Wei, HOU Zhen, DONG Ren-jie. Start-up operation of anaerobic membrane bioreactor treating food wastewater under thermophilic condition[J]. China Environmental Science. 2020, 40(12): 5318-5324

中图分类号： X703

参考文献

[1] 王丽华,李宇宸,韩聪.城市餐厨垃圾处理技术分析及思路分析[J]. 中国资源综合利用, 2018,36(12):77-79. Wang L H, Li Y C, Han C. Technical analysis and thinking analysis of urban kitchen waste treatment technology[J]. China Resources Comprehensive Utilization, 2018,36(12):77-79.
[2] 张妍,王元刚,卢志强,等.我国餐厨废物生化处理设施恶臭排放特征分析[J]. 环境科学, 2015,36(10):3603-3610. Zhang Y, Wang Y G, Lu Z Q, et al. Odor emission characteristics from biochemical treatment facilities of kitchen waste in China[J]. Environmental Science, 2015,36(10):3603-3610.
[3] 苏敏,乔玮,Algapani D E,等.餐厨垃圾与污泥厌氧发酵产气动力学特性研究[J]. 新能源进展, 2016,4(1):1-9. Su M, Qiao W, Algapani D E, et al. Kinetics characterization of anaerobic digestion of food waste and sludge[J]. Advances in New and Renewable Energy, 2016,4(1):1-9.
[4] 郭香麟,左剑恶,史绪川,等.餐厨垃圾与秸秆混合中温和高温厌氧消化对比[J]. 环境科学, 2017,38(7):3070-3077. Guo X L, Zuo J E, Shi X C, et al. Mesophilic and thermophilic anaerobic co-digestion of food waste and straw[J]. Environmental Science, 2017,38(7):3070-3077.
[5] Cheng H, Hiro Y, Hojo T, Li YY. Upgrading methane fermentation of food waste by using a hollow fiber type anaerobic membrane bioreactor[J]. Bioresource Technology, 2018,267:386-394.
[6] 彭绪亚,洪俊华,贾传兴,等.磷酸酯酶活性对餐厨垃圾单相厌氧消化抑制的预警作用[J]. 中国环境科学, 2012,32(3):541-546. Peng X Y, Hong J H, Jia C X, et al. Role of phosphatase activity as an early warning indicator of inhibition in a single-phase anaerobic digester treating food waste[J]. China Environmental Science, 2012, 32(3):541-546.
[7] 戴金金,牛承鑫,潘阳,等.基于厌氧膜生物反应器的剩余污泥-餐厨垃圾厌氧共消化性能[J]. 环境科学, 2020,https://doi.org/10.13227/j.hjkx.202001036. Dai J J, Niu C X, Pan Y, et al. Performance of anaerobic membrane bioreactors for co-digestion of sewage sludge and food waste[J]. Environmental Science, 2020.https://doi.org/10.13227/j.hjkx.202001036.
[8] Jiang M M, Westerholm M, Qiao W, et al. High rate anaerobic digestion of swine wastewater in an anaerobic membrane bioreactor[J]. Energy, 2019,193:116783.
[9] 黄振兴,席克忠,肖小兰,等.污泥停留时间对厌氧膜生物反应器处理餐厨废水效能的影响[J]. 环境工程学报, 2016,10(11):6357-6363. Huang Z X, Xi K Z, Xiao X L, et al. Effect of sludge retention time on performance of anaerobic membrane bioreactor treating kitchen wastewater[J]. Chinese Journal of Environmental Engineering, 2016, 10(11):6357-6363.
[10] Clesceri L S, Grenberg A, Eaton A D, et al. Standard methods for the examination of waters and wastewaters[J]. Health Laboratory Science, 2005,4(3):137.
[11] Rieger C, Weiland P. Prozessstörungen frühzeitig erkennen[J]. Biogas Journal, 2006,6(4):18-20.
[12] Algapani D E, Wang J, Qiao W, et al. Improving methane production and anaerobic digestion stability of food waste by extracting lipids and mixing it with sewage sludge[J]. Bioresource Technology, 2017,244:996-1005.
[13] 黄安寿,何永全,曾祖刚.餐厨垃圾高温厌氧消化过程参数研究[J]. 中国沼气, 2019,37(2):36-41. Huang A S, He Y G, Zeng Z G. Study on parameters of high temperature anaerobic digestion of kitchen waste[J]. China biogas, 2019,37(2):36-41.
[14] 野池达野.甲烷发酵[M]. 北京:化学工业出版社, 2014. Tatsuya Noike. Methane Fermentation[M]. Beijing:Chemical Industry Press, 2014.
[15] Seo H, Cho K, Shin J, et al. Linking process performances and core microbial community structures in anaerobic membrane bioreactor with rotatory disk (ARMBR) system fed with high-strength food waste recycling wastewater[J]. Bioresource Technology, 2019,291:121918.
[16] Micolucci F, Gottardo M, Bolzonella D, et al. Automatic process control for stable bio-hythane production in two-phase thermophilic anaerobic digestion of food waste[J]. International journal of hydrogen energy, 2014,39(31):17563-17572.
[17] Yeshanew M M, Frunzo L, Pirozzi F, et al. Production of biohythane from food waste via an integrated system of continuously stirred tank and anaerobic fixed bed reactors[J]. Bioresource Technology, 2016, 220:312-322.
[18] Logan M, Safi M, Lens P, et al. Investigating the performance of internet of things based anaerobic digestion of food waste[J]. Process Safety and Environment Protection, 2019,127:277-287.
[19] Yirong C, Heaven S, Banks C J. Effect of a Trace element addition strategy on volatile fatty acid accumulation in thermophilic anaerobic digestion of food waste[J]. Waste and Biomass Valorization, 2015, 6(1):1-12.
[20] Luna H J, Baêta B E L, Aquino S F, et al. EPS and SMP dynamics at different heights of a submerged anaerobic membrane bioreactor (SAMBR)[J]. Process Biochemistry, 2014,49(12):2241-2248.
[21] Zhang Q, Tan V, Hong G, et al. Optimal biogas sparging strategy, and the correlation between sludge and fouling layer properties in a submerged anaerobic membrane bioreactor (SAnMBR)[J]. Chemical Engineering Journal, 2017,319:248-257.
[22] Mahmoud I, Liao B. Effects of sludge concentration and biogas sparging rate on critical flux in a submerged anaerobic membrane bioreactor[J]. Journal of Water Process Engineering, 2017,20:51-60.
[23] Wandera S M, Qiao W, Jiang M M, et al. Enhanced methanization of sewage sludge using an anaerobic membrane bioreactor integrated with hyperthermophilic biological hydrolysis[J]. Energy Conversion and Management, 2019,196:846-855.
[24] Qiao W, Takayanagi K, Shofie M, et al. Thermophilic anaerobic digestion of coffee grounds with and without sludge as co-substrate using a submerged AnMBR:system amendments and membrane performance[J]. Bioresource Technology, 2013,150:249-258,
[25] Ng K K, Lin C F, Panchangam S C, et al. Reduced membrane fouling in a novel bio-entrapped membrane reactor for treatment of food and beverage processing wastewater[J]. Water Research, 2011,45:4269-4278.
[26] Huang Z, Ong S L, Ng H Y. Submerged anaerobic membrane bioreactor for low-strength wastewater treatment:effect of HRT and SRT on treatment performance and membrane fouling[J]. Water Research, 201,45:705-713.
[27] 王盼.平板膜污泥浓缩工艺中污染膜的膜清洗方式[J]. 净水技术, 2015,(1):82-87. Wang P, Membrane cleaning patterns of fouled membrane for flat-sheet membrane sludge thickening process[J]. Water Purification Technology, 2015,(1):82-87.
[28] 乔玮,姜萌萌,Wandera S M,等.厌氧平板膜生物反应器连续处理猪场废水研究[J]. 中国环境科学, 2018,38(12):104-110. Qiao W, Jiang M M, Wandera S M, et al. Continuous methane fermentation of swine wastewater using a flat sheet membrane bio-reactor[J]. China Environmental Science, 2018,38(12):104-110.