A.ferrooxidans对高硫煤矸石去除酸性水体中Cr(VI)的强化作用

宋永伟; 刘也琳; 王蕊; 王鹤茹; 曹艳晓

PDF(795 KB)

中国环境科学 ›› 2020, Vol. 40 ›› Issue (9) : 3879-3886.

水污染与控制

A.ferrooxidans对高硫煤矸石去除酸性水体中Cr(VI)的强化作用

宋永伟¹, 刘也琳^1,2, 王蕊¹, 王鹤茹¹, 曹艳晓¹

作者信息 +

The enhancement of Acidithiobacillus ferrooxidans on the removal of Cr(VI) from acid coal mine drainage by high-sulfur coal gangue

SONG Yong-wei¹, LIU Ye-lin^1,2, WANG Rui¹, WANG He-ru¹, CAO Yan-xiao¹

Author information +

文章历史 +

摘要

本研究考察了Acidithiobacillus ferrooxidans（A.ferrooxidans）联合高硫煤矸石（富含FeS₂）对模拟煤矿酸性水体中Cr（VI）的去除效果.结果表明，处理Cr（VI）初始浓度为50mg/L的模拟煤矿酸性废水（pH=2.5）时，投配率为6.67~33.33g/L高硫煤矸石可使Cr（VI）去除达到良好效果.50mg/LCr（VI）在24h内即可完全被高硫煤矸石中的FeS₂还原成Cr（III），且在反应终点时（120h），6.67，13.33，33.33g/L高硫煤矸石对还原产物Cr（III）的吸附去除率分别为7.1%、20.2%、29.1%.然而，在高硫煤矸石的还原和吸附作用下，大部分的Cr仍以Cr（III）形式残留在酸性水体中，且高硫煤矸石的大量投加也给水体带来了Fe²⁺、Fe³⁺、SO₄^2-等二次污染物.在高硫煤矸石-Cr（VI）体系中引入A.ferrooxidans和9K培养基后，A.ferrooxidans介导的Fe²⁺生物氧化及产物Fe³⁺水解矿化过程可促进部分Fe²⁺、Fe³⁺、SO₄^2-等向次生铁矿物（包括施氏矿物和黄钾铁矾）转变，从而使模拟酸性水体中残留的Cr（III）通过次生铁矿物的吸附或共沉淀作用被清除.在A.ferrooxidans强化作用下，模拟煤矿酸性废水中Cr（VI）在96h即可达到99.4%的去除率.

Abstract

The removal efficiency of Cr(VI) in simulated acid coal mine drainage (ACMD) was investigated through Acidithiobacillus ferrooxidans combined with high-sulfur coal gangue (rich in FeS₂). Results showed that in stimulated ACMD (pH=2.5) with 50mg/L Cr(VI), and 6.67~33.33g/L of high-sulfur coal gangue could achieve the ideal effect on Cr(VI) removal. 50mg/L of Cr (VI) could be completely reduced to Cr (III) by FeS₂ at 24h. 7.1%, 20.2% and 29.1% of Cr(III) was removed via absorption by 6.67, 13.33, and 33.33g/L high-sulfur coal gangue at 120h, respectively. However, after the reduction and adsorption of high-sulfur coal gangue, most of Cr remains in simulated ACMD as Cr(III), and large amount of high-sulfur coal gangue also led to secondary pollutants (Fe²⁺, Fe³⁺ or SO₄^2-). After the introduction of A.ferrooxidans and 9K medium into high-sulfur coal gangue and Cr(VI) system, A.ferrooxidans mediated Fe²⁺ biooxidation and Fe³⁺ hydrolytic mineralization promoted the conversion of Fe²⁺, Fe³⁺ or SO₄^2- to secondary iron minerals (including schwertmannite and jarosite), so that residual Cr(III) was removed by adsorption or co-precipitation. Under the enhancement of A.ferrooxidans, the removal efficiency of Cr(VI) in simulated ACMD could reached as high as 99.4% in 96h.

导出引用

宋永伟, 刘也琳, 王蕊, 王鹤茹, 曹艳晓. A.ferrooxidans对高硫煤矸石去除酸性水体中Cr(VI)的强化作用[J]. 中国环境科学. 2020, 40(9): 3879-3886

SONG Yong-wei, LIU Ye-lin, WANG Rui, WANG He-ru, CAO Yan-xiao. The enhancement of Acidithiobacillus ferrooxidans on the removal of Cr(VI) from acid coal mine drainage by high-sulfur coal gangue[J]. China Environmental Science. 2020, 40(9): 3879-3886

中图分类号： X703

参考文献

[1] Chen Y W, Liu G J, Gong Y M, et al. Release and enrichment of 44elements during coal pyrolysis of Yima coal, China[J]. Journal of Analytical and Applied Pyrolysis, 2007,80(2):283-288.
[2] Vhahangwele M. A novel technology for neutralizing acidity and attenuating toxic chemical species from acid mine drainage using cryptocrystalline magnesite tailings[J]. Journal of Water Process Engineering, 2016,10(6):67-77.
[3] Cheng Y J, Yan F B, Huang F, et al. Bioremediation of Cr(VI) and immobilization as Cr(III) by ochrobactrum anthropic[J]. Environmental Science and Technology, 2010,44(16):6357-6363.
[4] Saikia J, Saha B, Das G. Efficient removal of chromate and arsenate from individual and mixed system by malachite nanoparticles[J]. Journal of Hazardous Materials, 2011,186(1):575-582.
[5] Kiser J R, Manning B A. Reduction and immobilization of chromium (VI) by iron(II)-treated faujasite[J]. Journal of Hazardous Materials, 2010,174(1-3):167-174.
[6] 李尉卿,崔淑敏.煤矸石活化制作吸附材料的初步研究[J]. 环境工程, 2004,22(1):53-56. Li W Q, Cui S M. Elementary study on making adsorptive material by activation of gangue[J]. Environmental Engineering, 2004,22(1):53-56.
[7] Jabłońska B. Sorption of phenol on rock components occurring in mine drainage water sediments[J]. International Journal of Mineral Processing, 2012,104-105:71-79.
[8] Jabłońska B, Siedlecka E. Removing heavy metals from wastewaters with use of shales accompanying the coal beds[J]. Journal of Environmental Management, 2015,155:58-66.
[9] Lu X W, Shi D Q, Chen J L. Sorption of Cu²⁺ and Co²⁺ using zeolite synthesized from coal gangue:isotherm and kinetic studies[J]. Environmental Earth Sciences, 2017,76:591. DOI:10.1007/s12665-017-6923-z.
[10] 张战营,李冬.改性煤矸石吸附Cr(VI)的研究[J]. 非金属矿, 2007,30(1):54-56. Zhang Z Y, Li D. Study on adsorption of Cr(VI) from wastewater by modified gangue[J]. Non-Metallic Mines, 2007,30(1):54-56.
[11] 陈莉荣,赵林凯,张铁军,等.煤矸石复合吸附剂对Cr⁶⁺的吸附性能[J]. 煤炭技术, 2017,(1):293-296. Chen L R, Zhao L K, Zhang T J, et al. Adsorption capability of coal gangue adsorbent to Cr⁶⁺[J]. Coal Technology, 2017,(1):293-296.
[12] Kantar C, Ari C, Keskin S, et al. Cr(VI) removal from aqueous systems using pyrite as the reducing agent:Batch, spectroscopic and column experiments[J]. Journal of Contaminant Hydrology, 2015,174:28-38.
[13] Graham A M, Bouwer E J. Oxidative dissolution of pyrite surfaces by hexavalent chromium:Surface site saturation and surface renewal[J]. Geochimica et Cosmochimica Acta, 2012,83:379-396.
[14] Gan M, Li J, Sun S, et al. The enhanced effect of Acidithiobacillus ferrooxidans on pyrite based Cr(VI) reduction[J]. Chemical Engineering Journal, 2018,341:27-36.
[15] Lin Y T, Huang C P. Reduction of chromium(VI) by pyrite in dilute aqueous solutions[J]. Separation and Purification Technology, 2008, 63(1):191-199.
[16] Williams A G B, Scherer M M. Kinetics of Cr(VI) reduction by carbonate green rust[J]. Environmental Science & Technology, 2001, 35(17):3488-3494.
[17] Kantar C, Bulbul M S. Effect of pH-buffering on Cr(VI) reduction with pyrite in the presence of various organic acids:Continuous-flow experiments[J]. Chemical Engineering Journal, 2016,287:173-180.
[18] Silverman M P, Lundgren D G. Studies on the chemoautotrophic iron bacterium Ferrobacillus ferrooxidans:I. An improved medium and a harvesting procedure for securing high cell yields[J]. Journal of Bacteriology, 1959,77(5):642-647.
[19] Liao Y H, Zhou L X, Liang J R, et al. Biosynthesis of schwertmannite by Acidithiobacillus ferrooxidans cell suspensions under different pH condition[J]. Materials Science and Engineering C, 2009,29(1):211-215.
[20] 王世梅,周立祥.提高氧化亚铁硫杆菌和氧化硫硫杆菌平板检出率的方法:双层平板法[J]. 环境科学学报, 2005,25(10):1418-1420. Wang S M, Zhou L X. A renovated approach for increasing colony count efficiency of Thiobacillus ferrooxidans and Thiobacillus thiooxidans:Double-layer plates[J]. Acta Scientiae Circumstantiae, 2005,25(10):1418-1420.
[21] 宋永伟,王鹤茹,曹艳晓,等.NH₄⁺对次生铁矿物形成及重金属去除的影响[J]. 中国环境科学, 2018,38(6):2116-2123. Song Y W, Wang H R, Cao Y X, et al. Effect of NH₄⁺ on the formation of secondary iron minerals and the removal of heavy metals[J]. China Environmental Science, 2018,38(6):2116-2123.
[22] Accornero M, Marini L, Ottonello G, et al. The fate of major constituents and chromium and other trace elements when acid waters from the derelict Libiola mine (Italy) are mixed with stream waters[J]. Applied Geochemistry, 2005,20(7):1368-1390.
[23] Sand W, Gehrke T, Jozsa P G, et al. (Bio)chemistry of bacterial leaching-Direct vs. indirect bioleaching[J]. Hydrometallurgy, 2001, 59(2):159-175.
[24] 苏贵珍,陆建军,陆现彩,等.微生物-矿物接触作用对金属硫化物溶解的影响-氧化亚铁硫杆菌参与黄铜矿溶解的初步研究[J]. 地学前缘, 2008,15(6):100-106. Su G Z, Lu J J, Lu X C, et al. Effects of microbe-mineral contacting on the dissolution of metal sulfides:a preliminary study on chalcopyrite dissolution mediated by Acidothiobacillus ferrooxidans[J]. Earth Science Frontiers, 2008,15(6):100-106.
[25] 蒋磊,周怀阳,彭晓彤.氧化亚铁硫杆菌对黄铁矿的氧化作用初探[J]. 矿物学报, 2007,27(1):25-30. Jiang L, Zhou H Y, Peng X T. Preliminary study on bio-oxidation of pyrite by Acidithiobacillus ferrooxidans[J]. Acta Mineralogica Sinica, 2007,27(1):25-30.
[26] 张德伟,周立祥,杨新萍,等.不同底物驯化氧化亚铁硫杆菌的差异及对煤炭生物脱硫效率的影响[J]. 环境科学, 2011,27(1):25-30. Zhang D W, Zhou L X, Yang X P, et al. Difference in acclimation of Acidithiobacillus ferrooxidans by various substrates and its effect on coal desulfurization efficiency[J]. Chinese Journal of Environmental Science, 2011,27(1):25-30.
[27] Song Y W, Zhang J Y, Wang H R. Initial pH and K⁺ concentrations jointly determine the types of biogenic ferric hydroxysulfate minerals and their effect on adsorption removal of Cr(VI) in simulated acid mine drainage[J]. Water Science and Technology, 2018,78(10):2183-2192.
[28] Zhu J, Gan M, Zhang D, et al. The nature of Schwertmannite and Jarosite mediated by two strains of Acidithiobacillus ferrooxidans with different ferrous oxidation ability[J]. Materials Science and Engineering:C, 2013,33(5):2679-2685.
[29] 熊慧欣,梁剑茹,徐轶群,等.不同因素影响下Fe(Ⅲ)水解中和法制备FeOOH矿相的光谱分析[J]. 光谱学与光谱分析, 2009,29(7):2005-2009. Xiong H X, Liang J R, Xu Y Q, et al. Spectral analysis of FeOOH prepared through hydrolysis and neutralization of ferric solutions under different conditions[J]. Spectroscopy and Spectral Analysis, 2009,29(7):2005-2009.
[30] Wang H, Bigham J M, Tuovinen O H. Formation of schwertmannite and its transformation to jarosite in the presence of acidophilic iron-oxidizing microorganisms[J]. Materials Science and Engineering:C, 2006,26(4):588-592.
[31] Bigham J M, Schwertmann U, Pfab G. Influence of pH on mineral speciation in a bioreactor simulating acid mine drainage[J]. Applied Geochemistry, 1996,11(6):845-849.
[32] 曹丽娜,陈炳辉,苟习颖,等.不同条件下形成的黄钾铁矾微形貌对比研究[J]. 高校地质学报, 2019,25(3):333-340. Cao L N, Chen B H, Gou X Y, et al. A comparative study on microtopography of jarosite formed in different conditions[J]. Geological Journal of China Universities, 2019,25(3):333-340.
[33] Regenspurg S, Brand A, Peiffer S. Formation and stability of schwertmannite in acidic mining lakes[J]. Geochimica Et Cosmochimica Acta, 2004,68(6):1185-1197.
[34] Gagliano W B, Brill M R, Bigham J M, et al. Chemistry and mineralogy of ochreous sediments in a constructed mine drainage wetland[J]. Geochimica Et Cosmochimica Acta, 2004,68(9):2119-2128.
[35] JCPDS (Joint Committee on Powder Diffraction Standards). Mineral Powder Diffraction Files[Z]. International Center for Diffraction Data, Swarthmore:Pennsyvania, 2002.
[36] 隋智慧,刘安军,赵欣.煤矸石基混凝剂在制革废水处理中的应用[J]. 化工矿物与加工, 2007,(3):18-21. Sui Z H, Liu A J, Zhao X. Application of coal gangue-based coagulant in the treatment of tanning wastewater[J]. Industrial Minerals and Processing, 2007,(3):18-21.
[37] 陈建龙,卢新卫,张萌萌,等.矸石基X型分子筛对水中Co²⁺、Cu²⁺、Cd²⁺和Cr³⁺的去除[J]. 环境工程学报, 2014,8(9):3625-3632. Chen J L, Lu X W, Zhang M M, et al. Removal of Co²⁺, Cu²⁺, Cd²⁺ and Cr³⁺ from aqueous solution by zeolite X prepared from coal gangue[J]. Chinese Journal of Environmental Engineering, 2014,8(9):3625-3632.
[38] 柏双友,梁剑茹,王敏,等.Fe(Ⅲ)供应速率对无定型施氏矿物形成的影响[J]. 矿物学报, 2011,31(2):99-105. Bai S Y, Liang J R, Wang M, et al. Effect of Fe(Ⅲ) supply rate on the formation of amorphous schwertmannite[J]. Acta Mineralogica Sinica, 2011,31(2):99-105.
[39] Sánchez-España J, Yusta I. Low-crystallinity products of trace-metal precipitation in neutralized pit-lake waters without ferric and aluminous adsorbent:Geochemical modelling and mineralogical analysis[J]. Mineralogical Magazine, 2015,79(3):781-798.
[40] 周顺桂,周立祥,陈福星.施氏矿物Schwertmannite的微生物法合成、鉴定及其对重金属的吸附性能[J]. 光谱学与光谱分析, 2007,27(2):161-164. Zhou S G, Zhou L X, Chen F X. Characterization and heavy metal adsorption properties of schwertmannite synthesized by bacterial oxidation of ferrous sulfate solutions[J]. Spectroscopy and Spectral Analysis, 2007,27(2):161-164.
[41] 王长秋,马生凤,鲁安怀,等.黄钾铁矾的形成条件研究及其环境意义[J]. 岩石矿物学杂志, 2005,24(6):607-611. Wang C Q, Ma S F, Lu A H, et al. The formation conditions of jarosite and its environmental significance[J]. Acta Petrologica Et Mineralogica, 2005,24(6):607-611.
[42] Lee G, Bigham J, Faure G. Removal of trace metals by coprecipitation with Fe, Al and Mn from natural waters contaminated with acid mine drainage in the Ducktown Mining District, Tennessee[J]. Applied Geochemistry, 2002,17(5):569-581.
[43] 周顺桂,周立祥.污泥生物淋滤过程中黄铁矾对重金属离子的吸附与共沉淀作用的模拟研究[J]. 光谱学与光谱分析, 2006,26(5):966-970. Zhou S G, Zhou L X. Adsorption and coprecipitation of dissolved metals with jarosite under conditions simulating sewage sludge bioleaching[J]. Spectroscopy and Spectral Analysis, 2006,26(5):966-970.
[44] Song Y W, Wang M, Liang J R, et al. High-rate precipitation of iron as jarosite by using a combination process of electrolytic reduction and biological oxidation[J]. Hydrometallurgy, 2014,143(3):23-27.
[45] Lee W C, Lee S W, Yun S T, et al. A novel method of utilizing permeable reactive kiddle (PRK) for the remediation of acid mine drainage[J]. Journal of Hazardous Materials, 2016,301:332-341.