Study on the effect of online cleaning with NaClO on CE-HLMBR operation
WANG Wen-chao1,2, HE Cong-hui1, XU Heng2, FANG Kuo1, GAO Fang3, XUE Xiao-fei3, LIU Mu4, SUN Kai4, WANG Kai-jun1
1. State Key Joint Laboratory of Environmental Simulation and Pollution Control, School of Environment, Tsinghua University, Beijing 100084, China; 2. School of Chemical and Environmental Engineering, China University of Mining and Technology(Beijing), Beijing 100083, China; 3. Beijing Enterprises Water Group(China) Investment Limited, Beijing 100102, China; 4. GreenTech Environmental Co., Ltd, Beijing 100102, China
Abstract:In an already built chemically enhanced high load membrane bioreactor (CE-HLMBR), NaClO online cleaning strategy was applied. The impacts on filtration resistance, effluent quality and sludge characteristics were evaluated. Results indicated that NaClO online cleaning could remove the chemical cake layer as well as recover the filtration resistance efficiently. At different stages of resistance growth, the filtration resistance after cleaning could be recovered to a similar level (less than 5×1012m-1). In terms of effluent quality, the concentration of chemical oxygen demand (COD) increased after NaClO cleaning (from 6.3mg/L to 28.16mg/L), which was caused by the release and the increased permeability of dissolved organic matter (DOM). However, it had little impact on the removal of total phosphorus (TP) and ammonium. What’s more, after 12h of cleaning, the particle size distribution and nitrification activity of the sludge were basically unchanged, but the concentration of EPS increased significantly, which was supposed to cause changes in the structure of reversible membrane fouling.
王文超, 贺聪慧, 徐恒, 房阔, 高放, 薛晓飞, 刘牡, 孙凯, 王凯军. NaClO在线清洗对CE-HLMBR运行影响研究[J]. 中国环境科学, 2023, 43(2): 638-647.
WANG Wen-chao, HE Cong-hui, XU Heng, FANG Kuo, GAO Fang, XUE Xiao-fei, LIU Mu, SUN Kai, WANG Kai-jun. Study on the effect of online cleaning with NaClO on CE-HLMBR operation. CHINA ENVIRONMENTAL SCIENCECE, 2023, 43(2): 638-647.
Xiao K, Liang S, Wang X, et al. Current state and challenges of full-scale membrane bioreactor applications: A critical review [J]. Bioresource Technology, 2019,271:473-481.
[2]
Le-Clech P, Chen V, Fane T A.G. Fouling in membrane bioreactors used in wastewater treatment [J]. Journal of Membrane Science, 2006, 284(1/2):17-53.
[3]
Wang Z, Ma J, Tang C Y, et al. Membrane cleaning in membrane bioreactors: A review [J]. Journal of Membrane Science, 2014,468: 276-307.
[4]
刘清华,朱奕静,曹丽娟,等.膜生物反应器PVDF膜和尼龙膜污染特性 [J]. 中国环境科学, 2020,40(3):1089-1096. Liu Q H, Zhu Y J, Cao L J, et al. Membrane fouling characteristics of PVDF membrane and nylon mesh in Anammox-MBRs [J]. China Environmental Scienc, 2020,40(3):1089-1096.
[5]
Lee E J, Kwon J S, Park H S, et al. Influence of sodium hypochlorite used for chemical enhanced backwashing on biophysical treatment in MBR [J]. Desalination, 2013,316:104-109.
[6]
Wei C H, Huang X, Aim R B, et al. Critical flux and chemical cleaning-in-place during the long-term operation of a pilot-scale submerged membrane bioreactor for municipal wastewater treatment [J]. Water Research, 2011,45(2):863-871.
[7]
Cai W, Liu Y. Enhanced membrane biofouling potential by on-line chemical cleaning in membrane bioreactor [J]. Journal of Membrane Science, 2016,511:84-91.
[8]
Cai W, Liu J, Zhang X, et al. Generation of dissolved organic matter and byproducts from activated sludge during contact with sodium hypochlorite and its implications to on-line chemical cleaning in MBR [J]. Water Research, 2016,104:44-52.
[9]
Wang H, Liu Z, Luo S, et al. Membrane autopsy deciphering keystone microorganisms stubborn against online NaOCl cleaning in a full-scale MBR [J]. Water Research, 2020,171:115390.
[10]
Liu J, Liang X, Yang C, et al. Tracing membrane biofouling to the microbial community structure and its metabolic products: An investigation on the three-stage MBR combined with worm reactor process [J]. Bioresource Technology, 2019,278:165-174.
[11]
Sun Y, Fang Y, Liang P, et al. Effects of online chemical cleaning on removing biofouling and resilient microbes in a pilot membrane bioreactor [J]. International Biodeterioration & Biodegradation, 2016, 112:119-127.
[12]
Mozia S, Tomaszewska M, W.Morawski A. Studies on the effect of humic acids and phenol on adsorption–ultrafiltration process performance [J]. Water Research, 2005,39(2/3):501-509.
[13]
万立国,林 巧,张文华,等. HLB-MR反应器直接处理城市污水及回收有机物 [J]. 中国环境科学, 2019,39(4):1596-1601. Wan L G, Lin Q, Zhang W H, et al. Direct treatment and organics recovery of municipal wastewater via high loaded bioflocculation membrane reactor [J]. China Environmental Science, 2019,39(4): 1596-1601.
[14]
王文超,贺聪慧,房 阔,等.基于化学强化HLMBR的城市污水处理中试性能研究 [J]. 给水排水, 2022,48(9):37-43,50. Wang W C, He C H, Fang K, et al. Chemically enhanced HLMBR for municipal wastewater treatment: A pilot-scale evaluation [J]. Water &Wastewater Engineering, 2022,48(9):37-43,50.
[15]
Gong H, Jin Z Y, Wang Q, et al. Effects of adsorbent cake layer on membrane fouling during hybrid coagulation/adsorption microfiltration for sewage organic recovery [J]. Chemical Engineering Journal, 2017, 317:751-757.
[16]
Gong H, Jin Z Y, Wang X, et al. Membrane fouling controlled by coagulation/adsorption during direct sewage membrane filtration (DSMF) for organic matter concentration [J]. Journal of Environmental Sciences, 2015,32:1-7.
[17]
Gong H, Jin Z Y, Xu H, et al. Enhanced membrane-based pre-concentration improves wastewater organic matter recovery: Pilot-scale performance and membrane fouling [J]. Journal of Cleaner Production, 2019,206:307-314.
[18]
宫 徽.基于“碳源浓缩-氮源回收”的新型污水资源化工艺研究 [D]. 北京:清华大学, 2017. Gong H. Novel sustainable sewage treatment by "organic concentrating -nitrogens recovery" process [D]. Beijing: Tsinghua University, 2017.
[19]
国家环境保护总局《水和废水监测分析方法》编委会.水和废水监测分析方法(第4版) [M]. 北京:中国环境科学出版社, 2002:38-47. The State Environmental Protection Administration The Water and Wastewater Monitoring Analysis Method Editorial Board. Water and Wastewater monitoring analysis method [M]. 4th Edition. Beijing: China Environmental Science Press, 2002:38-47.
[20]
Teng J, Wu M, Chen J, et al. Different fouling propensities of loosely and tightly bound extracellular polymeric substances (EPSs) and the related fouling mechanisms in a membrane bioreactor [J]. Chemosphere, 2020,255:126953.
[21]
Mauro M. Estimation of total carbohydrate amount in environmental samples by the phenol–sulphuric acid method assisted by multivariate calibration [J]. Chemometrics and Intelligent Laboratory Systems, 2005,79(1/2):84-90.
[22]
Shen Y X, Xiao K, Liang P, et al. Improvement on the modified Lowry method against interference of divalent cations in soluble protein measurement [J]. Applied Microbiology and Biotechnology, 2013, 97(9):4167-4178.
[23]
安 莹,王志伟,李彬,等.盐度冲击下MBR污泥SMP和EPS的三维荧光光谱解析 [J]. 中国环境科学, 2014,34(7):1754-1762. An Y, Wang Z W, Li B, et al. Analysis of the EEM fluorescence Spectra of the SMP and EPS in MBR sludge under salinity shock. [J]. China Environmental Scienc, 2014,34(7):1754-1762.
[24]
Chen W, Westerhoff P, Leenheer J A, et al. Fluorescence excitation-emission matrix regional integration to quantify spectra for dissolved organic matter [J]. Environmental Science & Technology, 2003,37(24): 5701-5710.
[25]
宫 徽,金正宇,王凯军.混凝/膜过滤过程中泥饼层对膜污染的影响研究 [J]. 中国给水排水, 2014,30(11):81-85. Gong H, Jin Z Y, Wang K J. Effect of cake layer on membrane fouling in coagulation/membrane filtration process [J]. China Water & Wastewater, 2014,30(11):80-85.
[26]
Zhang J, Chua H C, Zhou J, et al. Factors affecting the membrane performance in submerged membrane bioreactors [J]. Journal of Membrane Science, 2006,284(1/2):54-66.
[27]
Zhang Y, Wang X, Ye H, et al. Effect and mechanism of reduced membrane bioreactor fouling by powdered activated carbon [J]. Water Science and Technology, 2021,83(5):1005-1016.
[28]
Strugholtz S, Sundaramoorthy K, Panglisch S, et al. Evaluation of the performance of different chemicals for cleaning capillary membranes [J]. Desalination, 2005,179(1-3):191-202.
[29]
Cui Z, Wang J, Zhang H W, et al. Investigation of backwashing effectiveness in membrane bioreactor (MBR) based on different membrane fouling stages [J]. Bioresource Technology: Biomass, Bioenergy, Biowastes, Conversion Technologies, Biotransformations, Production Technologies, 2018:269355-362.
[30]
Zhang J, Padmasiri S I, Fitch M, et al. Influence of cleaning frequency and membrane history on fouling in an anaerobic membrane bioreactor [J]. Desalination, 2007,207(1-3):153-166.
[31]
Song K G, Kim Y, Ahn K H. Effect of coagulant addition on membrane fouling and nutrient removal in a submerged membrane bioreactor [J]. 2008:8.
[32]
Li Y S, Zhang H M, Meng F G, et al. A new method for estimating cake layer permeability ol membrane fouling [J]. Future of Urban Wastewater Systems-Decentralisation and Reuse, 2005:603-609.
[33]
周淼.次氯酸钠在线反洗工艺在MBR系统中的应用和研究 [D]. 西安:西安建筑科技大学, 2017. Zhou miao Application and optimization of sodium hypochlorite online backwashing process in MBR system [D]. Xi'an: Xi’an University of Architecture and Technology, 2017.
[34]
Kim H S, Katayama H, Takizawa S, et al. Development of a microfilter separation system coupled with a high dose of powdered activated carbon for advanced water treatment [J]. Desalination, 2005,186(1-3):215-226.
[35]
Lee W. Sludge characteristics and their contribution to microfiltration in submerged membrane bioreactors [J]. Journal of Membrane Science, 2003,216(1/2):217-227.
[36]
Guo L, Lu M, Li Q, et al. Three-dimensional fluorescence excitation– emission matrix (EEM) spectroscopy with regional integration analysis for assessing waste sludge hydrolysis treated with multi-enzyme and thermophilic bacteria [J]. Bioresource Technology, 2014,171:22-28.
[37]
Cai W, Han J, Zhang X, et al. Formation mechanisms of emerging organic contaminants during on-line T membrane cleaning with NaOCl in MBR [J]. Journal of Hazardous Materials, 2020,386:12.
[38]
Cai W. Comparative study of dissolved organic matter generated from activated sludge during exposure to hypochlorite, hydrogen peroxide, acid and alkaline: Implications for on-line chemical cleaning of MBR [J]. Chemosphere, 2018,193:295-303.
[39]
Kim J S, Lee C H, Chang I S. Effect of pump shear on the performance of a crossflow membrane bioreactor [J]. Water Research, 2001,35(9):2137-2144.
[40]
Sun M, Hou B, Wang S, et al. Effects of NaClO shock on MBR performance under continuous operating conditions [J]. Environmental Science: Water Research & Technology, 2021,2DOI:10.1039/ D0EW00760A.
[41]
Huang C, Liu H, Meng S, et al. Effect of PAC on the behavior of dynamic membrane bioreactor filtration layer based on the analysis of mixed liquid properties and model fitting [J]. Membranes, 2020,10(12):420.
[42]
Masse A, Sperandio M, Cabassud C. Comparison of sludge characteristics and performance of a submerged membrane bioreactor and an activated sludge process at high solids retention time [J/OL]. Water Research, 2006,40(12):2405-2415.
[43]
Nagaoka H, Ueda S, Miya A . Influence of bacterial extracellular polymers on the membrane separation activated sludge process [J]. Water Science & Technology, 1996,34(9):165-172.
[44]
Wu Z, Wang Z, Zhou Z, et al. Sludge rheological and physiological characteristics in a pilot-scale submerged membrane bioreactor [J]. Desalination, 2007,212(1-3):152-164.