硫自养反硝化系统运行效能和微生物群落结构研究

马潇然; 郑照明; 卞伟; 李军; 周荣煊; 杨京月

PDF(868 KB)

中国环境科学 ›› 2020, Vol. 40 ›› Issue (10) : 4335-4341.

水污染与控制

硫自养反硝化系统运行效能和微生物群落结构研究

马潇然¹, 郑照明¹, 卞伟², 李军¹, 周荣煊¹, 杨京月¹

作者信息 +

Study on operation efficiency and microbial community structure of sulfur-based autotrophic denitrification system

MA Xiao-ran¹, ZHENG Zhao-ming¹, BIAN Wei², LI Jun¹, ZHOU Rong-xuan¹, YANG Jing-yue¹

Author information +

文章历史 +

摘要

启动了单质硫自养反硝化反应器并研究其脱氮性能，通过血清瓶批式实验测定了污泥的反硝化活性，并采用扫描电镜和高通量测序手段揭示了系统内微生物群落结构特征.结果表明，SBR反应器进水NO₃^--N浓度为80mg/L，随水力停留时间由12h逐渐缩短为6h，反应器的自养脱氮性能逐渐增强，稳定期反应器的总无机氮去除率达99.1%，总无机氮去除负荷平均值为0.158kg N/（m³·d）；SBR周期内NO₂^--N浓度最大值为13.3mg/L，NO₃^--N还原为NO₂^--N过程pH值由7.38降低至6.94，NO₂^--N还原为N₂过程pH值基本不变；批式实验结果表明，硫自养反硝化和异养反硝化NO₃^--N去除速率分别为0.515，0.196kg N/（kg VSS·d），硫自养反硝化污泥NO₂^--N降解速率为0.117kg N/（kg VSS·d），污泥同时具有自养反硝化和异养反硝化活性；扫描电镜显示，污泥中存在大量的杆状细菌和球状菌；污泥中主要的硫反硝化细菌分别为Thiobacillus、Sulfurimonas和Thermomonas属，其相对丰度分别为14.5%、7.6%和6.0%.

Abstract

The sulfur-based autotrophic denitrification reactor was set up and its denitrification performance was evaluated in this study. The denitrification activity of the sludge was determined by batch tests, and the microbial community structure was revealed by scanning electron microscopy(SEM) and high-throughput sequencing. The influent NO₃^--N concentration of the reactor operated with sequencing batch mode was 80mg/L. The autotrophic denitrification performance increased with the hydraulic retention time (HRT) gradually shortened from 12h to 6h, the total inorganic nitrogen(TIN) removal efficiency and the average TIN removal loading rate of the reactor during the stable period were 99.1% and 0.158kg N/(m³·d), respectively. The maximum NO₂^--N concentration during the SBR cycle was 13.3mg/L, the pH value decreased from 7.38 to 6.94 during the reduction process from NO₃^--N to NO₂^--N, and the pH value remained stable during the process of reducing NO₂^--N to N₂. The batch test results showed that the NO₃^--N removal rate of sulfur autotrophic denitrifying bacteria and heterotrophic denitrifying bacteria were 0.515and 0.196kg N/(kg VSS·d), respectively, and the NO₂^--N removal rate of sulfur autotrophic denitrifying bacteria was 0.117kg N/(kg VSS·d), the sludge had both autotrophic denitrification activity and heterotrophic denitrification activity. SEM images showed that both rod-shaped bacteria and spherical bacteria were observed in the sludge. The dominant sulfur autotrophic denitrifying bacteria in the sludge were Thiobacillus, Sulfurimonas and Thermomonas, with relative abundance of 14.5%, 7.6% and 6.0%, respectively.

导出引用

马潇然, 郑照明, 卞伟, 李军, 周荣煊, 杨京月. 硫自养反硝化系统运行效能和微生物群落结构研究[J]. 中国环境科学. 2020, 40(10): 4335-4341

MA Xiao-ran, ZHENG Zhao-ming, BIAN Wei, LI Jun, ZHOU Rong-xuan, YANG Jing-yue. Study on operation efficiency and microbial community structure of sulfur-based autotrophic denitrification system[J]. China Environmental Science. 2020, 40(10): 4335-4341

中图分类号： X703.1

参考文献

[1] 王亚宜,黎力,马骁,等.厌氧氨氧化菌的生物特性及CANON厌氧氨氧化工艺[J]. 环境科学学报, 2014,34(6):1362-1374. Wang Y Y, Li L, Ma X, et al. Bio-characteristics of anammox bacteria and CANON anammox process[J]. Acta Scientiae Circumstantiae, 2014,34(6):1362-1374.
[2] 邓旭亮,王爱杰,荣丽丽,等.硫自养反硝化技术研究现状与发展趋势[J]. 工业水处理, 2008,28(3):13-16. Deng X L, Wang A J, Rong L L, et al. Present state of the sulfur-autotrophic denitrification technique and its developing trend[J]. Industrial Water Treatment, 2008,28(3):13-16.
[3] Campos J L, Carvalho S, Portela R, et al. Kinetics of denitrification using sulphur compounds:Effects of S/N ratio, endogenous and exogenous compounds[J]. Bioresource Technology, 2008,99(5):1293-1299.
[4] Tallec G, Garnier J, Gousailles M. Nitrogen removal in a wastewater treatment plant through biofilters:nitrous oxide emissions during nitrification and denitrification[J]. Bioprocess and Biosystems Engineering, 2006,29(5/6):323-333.
[5] Qian J, Lu H, Cui Y, et al. Investigation on thiosulfate-involved organics and nitrogen removal by a sulfur cycle-based biological wastewater treatment process[J]. Water Research, 2015,69:295-306.
[6] Sahinkaya E, Yurtsever A, Ucar D. A novel elemental sulfur-based mixotrophic denitrifying membrane bioreactor for simultaneous Cr(VI) and nitrate reduction[J]. Journal of Hazardous Materials, 2017,324:15-21.
[7] Batchelor B, Lawrence A W. Autotrophic denitrification using elemental sulfur[J]. Journal Water Pollution Control Federation, 1978,50(8):1986-2001.
[8] Sun Y, Nemati M. Evaluation of sulfur-based autotrophic denitrification and denitritation for biological removal of nitrate and nitrite from contaminated waters[J]. Bioresource Technology, 2012, 114:207-216.
[9] Du R, Cao S, Li B, et al. Performance and microbial community analysis of a novel DEAMOX based on partial-denitrification and anammox treating ammonia and nitrate wastewaters[J]. Water Research, 2017,108:46-56.
[10] 周健,黄勇,刘忻,等.硫自养反硝化耦合厌氧氨氧化脱氮条件控制研究[J]. 环境科学, 2016,37(3):1061-1069. Zhou J, Huang Y, Liu X, et al. Element Sulfur Autotrophic Denitrification Combined Anaerobic Ammonia Oxidation[J]. Environmental Science, 2016,37(3):1061-1069.
[11] Chen F, Li X, Gu C, et al. Selectivity control of nitrite and nitrate with the reaction of S0and achieved nitrite accumulation in the sulfur autotrophic denitrification process[J]. Bioresource Technology, 2018,266:211-219.
[12] Liu C, Li W, Li X, et al. Nitrite accumulation in continuous-flow partial autotrophic denitrification reactor using sulfide as electron donor[J]. Bioresource Technology, 2017,243:1237-1240.
[13] Huang S, Zheng Z, Wei Q, et al. Performance of sulfur-based autotrophic denitrification and denitrifiers for wastewater treatment under acidic conditions[J]. Bioresource Technology, 2019,294:122176.
[14] 郑照明,杨函青,马静,等. SNAD反应器中颗粒污泥和絮体污泥脱氮特性[J]. 中国环境科学, 2015,35(10):2996-3002. Zheng Z M, Yang H Q, Ma J, et al. The nitrogen removal performance of granules and flocs in SNAD reactor[J]. China Environmental Science, 2015,35(10):2996-3002.
[15] 国家环保总局.水与废水监测分析方法(第四版)[M]. 北京:中国环境出版社, 2002. General Administration of Environmental Protection of the People's Republic of China. Standard methods for the examination of water and wastewater[M]. Beijing:China Environmental Science Press, 2002.
[16] 陈重军,张海芹,汪瑶琪,等.基于高通量测序的ABR厌氧氨氧化反应器各隔室细菌群落特征分析[J]. 环境科学, 2016,37(7):2652-2658. Chen C J, Zhang H Q, Wang Y Q, et al. Characteristics of microbial community in each compartment of ABR ANAMMOX reactor based on high-throughput sequencing[J]. Environmental Science, 2016, 37(7):2652-2658.
[17] Sierra-Alvarez R, Beristain-Cardoso R, Salazar M, et al. Chemolithotrophic denitrification with elemental sulfur for groundwater treatment[J]. Water Research, 2007,41(6):1253-1262.
[18] Kucera I, Matyasek R, Dvorakova J, et al. Anaerobic adaptation of paracoccus-denitrificans-sequential formation of denitrification pathway and changes in activity of 5-aminolevulinate synthase and catalase[J]. Current Microbiology, 1986,13(2):107-110.
[19] 车轩,罗国芝,谭洪新,等.脱氮硫杆菌的分离鉴定和反硝化特性研究[J]. 环境科学, 2008,29(10):2931-2937. Che X, Luo G Z, Tan H X, et al. Isolation, Identification and Denitrification Characterization of Thiobacillus denitrificans[J]. Environmental Science, 2008,29(10):2931-2937.
[20] 马航,李祥,黄勇,等.基于协同反硝化脱氮的光伏废水处理[J]. 中国环境科学, 2016,36(12):3672-3677. Ma H, Li X, Huang Y, et al. Photovoltaic wastewater treatment based on a combined heterotrophic and sulfur-based autotrophic denitrification technology[J]. China Environmental Science, 2016,36(12):3672-3677.
[21] 刘玲花,王占生,王志石.硫/石灰石滤柱去除地下水中硝酸盐的研究[J]. 环境工程, 1995,13(3):11-15. Liu L H, Wang Z S, Wang Z S. Nitrate removal from groundwater by sulfur/limestone filter column[J]. Environmental Engineering, 1995, 13(3):11-15.
[22] 牛建敏,李睿华.理化因素对脱氮硫杆菌自养反硝化的影响[J]. 中国环境科学, 2010,30(1):76-81. Niu J M, Li R H. Effects of the physicochemical factors on autotrophic denitrification by Thiobacillus denitrificans[J]. China Environmental Science, 2010,30(1):76-81.
[23] 赵晴,杨伟明,王瑶,等.硫化物自养反硝化细菌颗粒污泥及其物化特征[J]. 环境工程学报, 2017,11(6):3884-3890. Zhao Q, Yang W M, Wang Y, et al. Granulation and physical-chemical characterization of sulfur-oxidizing bacteria sludge[J]. Chinese Journal of Environmental Engineering, 2017,11(6):3884-3890.
[24] 周娅,买文宁,代吉华,等.硫代硫酸钠联合硫铁矿自养反硝化脱氮性能[J]. 中国环境科学, 2020,40(5):2081-2086. Zhou Y, Mai W N, Dai J H, et al. Study on autotrophic denitrification performance of sodium thiosulfate combined with pyrite system[J]. China Environmental Science, 2020,40(5):2081-2086.
[25] 张晨晓,郭延凯,杜海峰,等.硫自养反硝化反应器脱氮特性研究[J]. 河北科技大学学报, 2016,37(1):96-101. Zhang C X, Guo Y K, Du H F, et al. Denitrification characteristics of a sulfur autotrophic denitrification reactor[J]. Journal of Hebei University of Science and Technology, 2016,37(1):96-101.