Batch experiments were conducted to investigate the dissolution of excess sludge organic matter (SCOD) to understand the physical and chemical properties and dissolution characteristics of excess sludge under low temperature heat treatment. The dissolution rate of soluble carbohydrate (SC), soluble protein(SP) and the fluorescence properties of the dissolved organic matter (DOM) were also investigated. With the increase of heat treatment temperature, the cracking degree of SCOD achieved its highest level at 80℃, while the dissolution rate reached its peak value at 90℃ and the SC was the highest at 70℃. Along with the treatment the mass concentration maximized at 90℃, that of the SP was on its top at 60℃, while the content of VFAs was the largest at 60℃. The results of the liquid chromatography with online organic carbon (LC-OCD) analysis demonstrated that the biopolymer fraction got its highest proportion in DOM at 80℃. The results of fluorescence analysis showed that the DOM contained C1organics (Ex/Em, 282/324nm), metabolic proteins C2(310/364nm), visible humic acids C3(278,338,358/424nm), and soil fumarates C4 (270,318,354/476,524nm) after heat treatment of excess sludge. For the sludge handled by hot water decomposition pretreatment, its protein-like organics presented maximum fluorescence intensity at 80℃ while corresponding metabolic protein has its maximum fluorescence intensity at 60℃. According to the above results, the optimzed operational condition for the dissolution of organic matter from sludge could be set as treatment duration of 60minutes under 80℃.
Yang G, Zhang G M, Wang H C. Current state of sludge production, management,treatment and disposal in China[J]. Water Research, 2015,78:60-73.
[2]
李天国,王利军,徐晓军,等.西安市市政污水厂剩余污泥中重金属形态特及潜在生态风险评价[J]. 城市环境与城市生态, 2014,27(4):6-10. Li T G, Wang L J, Xu X J, et al. Morphological characteristics of heavy metals in sewage sludge and their potential ecological risk assessment in Xi'An[J]. Urban Environment & Urban Ecology, 2014,27(4):6-10.
[3]
董滨,刘晓光,戴翎翎,等.低温短时热水解对剩余污泥厌氧消化的影响[J]. 同济大学学报(自然科学版), 2013,41(5):80-85. Dong B, Liu X G, Dai L L, et al. Effect of short time low temperature thermal pretreatment on sludge anaerobic digestion[J]. Journal of Tongji University (natural science), 2013,41(5):80-85.
[4]
Kim J, Park C, Kim T H, et al. Effects of various pretreatments for enhanced anaerobic digestion with waste activated sludge[J]. Journal of Bioence & Bioengineering, 2003,95(3):271-275.
[5]
Appels L, Jan Baeyens, Jan Degrève, et al. Principles and potential of the anaerobic digestion of waste-activated sludge[J]. Progress in Energy & Combustion Science, 2010,34(6):755-781.
[6]
Kor-Bicakci G, Eskicioglu C. Recent developments on thermal municipal sludge pretreatment technologies for enhanced anaerobic digestion[J]. Renewable and Sustainable Energy Reviews, 2019,110(AUG.):423-443.
[7]
Bougrier C, Jean Philippe Delgenès, Hélène Carrère. Effects of thermal treatments on five different waste activated sludge samples solubilisation, physical properties and anaerobic digestion[J]. Chemical Engineering Journal, 2008,139(2):236-244.
[8]
王治军,王伟.热水解预处理改善污泥的厌氧消化性能[J]. 环境科学, 2005,26(1):68-71. Wang Z J, Wang W. Enhancement of sewage sludge anaerobic digestibility by thermal hydrolysis pretreatment[J]. Chinese Journal of Environmental Science, 2005,26(1):68-71.
[9]
Xue Y G, Liu H J, Chen S S, et al. Effects of thermal hydrolysis on organic matter solubilization and anaerobic digestion of high-solid sludge[J]. Chemical Engineering Journal, 2015,264:174-180.
[10]
Climent M, Ferrer I, Baeza M D M, et al. Effects of thermal and mechanical pretreatments of secondary sludge on biogasproduction under thermophilic conditions[J]. Chemical Engineering Journal, 2007,133(1-3):335-342.
[11]
Appels L, Jan Degrève, Bruggen B V D, et al. Influence of low temperature thermal pre-treatment on sludge solubilisation,heavy metalrelease and anaerobic digestion[J]. Bioresource Technology, 2010,101(15):5743-5748.
[12]
Kepp U, Machenbach I, Weisz N, et al. Enhanced stabilisation of sewage sludge through thermal hydrolysis-Three years of experience with full scale plant[J]. Water ence & Technology, 2000,42(9):89-96.
[13]
Barjenbruch M, Hoffmann H, Kopplow O, et al. Minimising of foaming in digesters by pre-treatment of the surplus-sludge[J]. Water Science and Technology, 2000,42(9):235-241.
[14]
彭永臻,郭思宇,李夕耀,等.低温热处理对剩余污泥有机物溶出及脱水性能改变的影响[J]. 北京工业大学学报, 2017,43(3):473-479. Peng Y Z, Guo S Y, Li X Y, et al. Effect of low temperature thermal treatment on organic matter solubilization and dewaterability changeof waste activited sludge[J]. Journal of Beijing University of Technology, 2017,43(3):473-479.
[15]
Liao X, Li H, Zhang Y, et al. Accelerated highsolids anaerobic digestion of sewage sludge using lowtemperature thermal pretreatment[J]. International Biodeterioration & Biodegradation, 2016,106:141-149.
[16]
代勤,张文哲,于潘芬,等.热、热碱处理对污泥溶胞和溶解性有机物影响[J]. 环境科学, 2018,39(5):315-320. Dai Q, Zhang W Z, Yu P F, et al. Effects of heat and heat-alkine treatment on disintegration and dissolved orgnic matters in sludget[J]. Enviromental Science, 2018,39(5):315-320.
[17]
国家环境保护总局.水和废水监测分析方法[M]. 北京:中国环境科学出版社, 2002. State Environmental protection administration. Water and wastewatermonitoring and analysis methods[M]. China Environmental Science Press, 2002.
[18]
徐慧敏,何国富,戴晓虎,等.超声联合低温热水解促进剩余污泥破解和厌氧消化的研究[J]. 中国环境科学, 2016,36(9):2703-2708. Xu H M, He G F, Dai X H, et al. The effects of combined ultrasound and low temperature thermal pretreatments on disintegration and anaerobic digestion of waste activated sludge[J]. China Environmental Science, 2016,36(9):2703-2708.
[19]
吴林杰.有机钛吸附与电催化组合工艺处理冷却塔排污水[D]. 西安:西安理工大学, 2019. Wu L J. Treatment of cooling tower blowdown water by organic titanium adsorption and electrocatalysis combined process[D]. Xi'an:Xi'an University of Technology, 2019.
[20]
童文锦,孙水裕,郑莉,等.城市污水污泥超声波预处理的研究[J]. 环境科学与技术, 2010,33(5):133-135,139. Tong W J, Sun S Y, Zheng L, et al. Ultrasonic pretreatment of municipal sewage sludg[J]. Enuivonmental Science and Technology, 2010,33(5):133-135,139.
[21]
Zhang Y, Zhang P, Zhang G, et al. Sewage sludge disintegration by combined treatment of alkaline plus high pressure homogenization[J]. Bioresource Technology, 2012,123:514-519.
[22]
Kim J, Park C, Kim T H, et al. Effects of various pretreatments for enhanced anaerobic digestion with waste activated sludge[J]. Journal of Bioscience and Bioengineering, 2003,95(3):271-275.
[23]
肖本益,阎鸿,魏源送,等.污泥热处理及其强化污泥厌氧消化的研究进展[J]. 环境科学学报, 2009,29(4):673-682. Xiao B Y, Yan H, Wei Y S, et al. State of theart of thermal sludge pretreatment and its enhancemen tfor anaerobic sludge digestion[J]. Acta Scientiae Circumstantiae, 2009,29(4):673-682.
[24]
Hamer A, Mason C A, Hamer G. Death and lysis during aerobic thermophilic sludge treatment:Characterization of recalcitrant products[J]. Water Research, 1994,28(4):863-869.
[25]
李卫华,刘怡心,王伟,等.污水处理厂及受纳水体样品的三维荧光光谱解析[J]. 光谱学与光谱分析, 2015,35(4):78-83. Li W H, Liu Y X, Wang W, et al. Anlysis of samples from wastewaster treatment plant and receiving waters using EEM Fluorescence spectroscopy[J]. Spectroscopy and Spectral Anlysis, 2015,35(4):78-83.
[26]
Li X W, Dai X H, Takahashi J, et al. New insight into chemical changes of dissolved organic matter during anaerobic digestion of dewatered sewage sludge using EEM-PARAFAC and two dimensional FTIR correlation spectroscopy[J]. Bioresource Technology, 2014,159:412-420.
[27]
Li W T, Chen S Y, Xu Z X, et al. Characterization of dissolved organic matter in municipal wastewater using fluorescence parafac analysis and chromatography multi-excitation/emission scan:a comparative study[J]. Environmental Science & Technology, 2014,48(5):2603-2609.
[28]
Zhou Z, Qiao W M, Xing C, et al. Characterization of dissolved organic matter in the anoxic-oxic-settling-anaerobic sludge reduction process[J]. Chemical Engineering Journal, 2015,259:357-363.
[29]
Ishii S K L, Boyer T H. Behavior of Reoccurring PARAFAC Components in Fluorescent Dissolved Organic Matter in Natural and Engineered Systems:A Critical Review[J]. Environmental Science & Technology, 2012,(4):2006-2017.
[30]
Coble P G. Marine Optical Biogeochemistry:The Chemistry of Ocean Color[J]. Chemical Reviews, 2007,107(2):402-418.
[31]
Zhou Z, Qiao W M, Xing C, et al. Characterization of dissolvedorganic matter in the anoxic-oxic-settling-anaerobic sludge reduction process[J]. Chemical Engineering Journal, 2015,259:357-363.
