Preparation of chitosan-alginate adsorbent contained Fe-Mn sludge and its potential for As(V) removal
ZENG Hui-ping1, WANG Fan-shuo1, YU Ya-ping1, LI-Dong1, ZHANG-Jie1,2
1. Key Laboratory of Beijing for Water Quality Science and Water Environment Recovery Engineering, Beijing University of Technology, Beijing 100124, China;
2. State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin 150090, China
A chitosan alginate Fe-Mn sludge bead (CAFB) with high mechanical strength and stability was prepared by chitosan alginate hydrogel, embedding iron-manganese sludge from the backwashing wastewater of biofilter for iron and manganese removal. The results of characterization showed that it had mesoporous structure with rough surface morphology and large specific surface area (117.20m2/g), and the content of Fe and Mn were as high as 69.31% by EDS. The data of adsorption kinetics fitted pseudo-second kinetic model (R2=0.963) well. The Langmuir adsorption isotherm model could better describe the As(V) adsorption behavior with R2=0.969. Maximum adsorption capacity was 15.80mg/g at 25℃.The acidic condition was favorable for the adsorption of As(V), and in the range of pH=3~7,the As(V) removal rate could reach up to 80%. H2PO4-, SiO32- had obvious suppression on As(V) adsorption. After 4times of regeneration with 0.1mol/L NaOH solution, the adsorption amount could still reach up to 70.68% of the initial value. In conclusion, CAFB has the prospect of application in engineering.
Sherlala A I A, Raman A A A, Bello M M, et al. Adsorption of arsenic using chitosan magnetic graphene oxide nanocomposite[J]. Journal of Environmental Management, 2019,246:547-556.
[2]
张明月,曾辉平,吕育锋,等.高铁盐与亚铁盐混凝除As(III)性能的对比研究[J]. 中国环境科学, 2017,37(5):1798-1804. Zhang M Y, Zeng H P, Lv Y F, et al. Comparison of arsenite removal processes by ferric salts and ferrous salts[J]. China Environmental Science, 2017,37(5):1798-1804.
[3]
曾辉平,吕赛赛,杨航,等.铁锰泥除砷颗粒吸附剂对As(Ⅴ)的吸附去除[J]. 环境科学, 2018,39(1):170-178. Zeng H P, Lv S S, Yang H, et al. Arsenic(Ⅴ) Removal by granular adsorbents made from bBackwashing residuals from biofilters for iron and manganese removal[J]. Environmental Science, 2018,39(1):170-178.
[4]
Karthikeyan P, Banu H A T, Meenakshi S. Synthesis and characterization of metal loaded chitosan-alginate biopolymeric hybrid beads for the efficient removal of phosphate and nitrate ions from aqueous solution[J]. International Journal of Biological Macromolecules, 2019,130:407-418.
[5]
Qi J, Zhang G, Li H. Efficient removal of arsenic from water using a granular adsorbent:Fe-Mn binary oxide impregnated chitosan bead[J]. Bioresource Technology, 2015,193:243-249.
[6]
Zhang H, Omer A M, Hu Z, et al. Fabrication of magnetic bentonite/carboxymethyl chitosan/sodium alginate hydrogel beads for Cu (II) adsorption[J]. International Journal of Biological Macromolecules, 2019,135:490-500.
[7]
李冬,孙宇,曾辉平,等.铁锰生物污泥吸附磷[J]. 中国环境科学, 2014,34(10):2528-2535. Li D, Sun Y, Zeng H P, et al. Phosphorus adsorption oniron and manganese biological sludge.[J]. China Environmental Science, 2014, 34(10):2528-2535.
[8]
程丽杰,黄廷林,程亚,等.不同挂膜方式成熟滤料去除地下水中As(Ⅲ)研究[J]. 中国环境科学, 2018,38(12):4524-4529. Cheng L J, Huang T L, Cheng Y, et al. A comparative study on removal of As(III) in groundwater by mature filter media formed in different ways[J]. China Environmental Science, 2018,38(12):4524-4529.
[9]
曾辉平,于亚萍,吕赛赛,等.基于铁锰泥的除砷颗粒吸附剂制备及其比较[J]. 环境科学, 2019,40(11):5002-5008. Zeng H P, Yu Y P, Lv S S, et al. Preparation and comparison of arsenic removal granular adsorbent based on iron-manganese sludge[J]. Environmental Science, 2019:1-10.
[10]
Ociński D, Jacukowicz-Sobala I, Kociolek-Balawejder E. Alginate beads containing water treatment residuals for arsenic removal from water-formation and adsorption studies[J]. Environmental Science and Pollution Research, 2016,23(24):24527-24539.
[11]
陶虎春,李硕,张丽娟,等.一种新型磁性壳聚糖/海藻酸钠复合凝胶球的制备与性能研究[J]. 北京大学学报(自然科学版), 2018,54(4):899-906. Tao H C, Li S, Zhang L J, et al. Preparation and optimization of a novel magnetic chitosan/sodium alginate composite gel bead[J]. Acta Scientiarum Naturalium Universitatis Pekinensis, 2018,54(4):899-906.
[12]
黄佳丽,蒙君荣,周树辉,等.改性壳聚糖除砷材料的研究进展[J]. 山东化工, 2017,46(21):67-69. Huang J L, Meng R J, Zhou S H, et al. The research progress of modified chitosan material for removal of arsenic[J]. Shandong Chemical Industry, 2017,46(21):67-69.
[13]
Kwon O, Kurade M B, Jeon B, et al. Adsorption of As(III),As(V) and Cu(II) on zirconium oxide immobilized alginate beads in aqueous phase[J]. Chemosphere:Environmental toxicology and risk assessment, 2016,160(10):126-133.
[14]
刘琼琼.海藻酸钠-壳聚糖聚离子复合物水凝胶的制备与性能研究[D]. 广州:华南理工大学, 2018. Liu Q Q, Preparation and properties of sodium alginate-chitosan ion complex hydrogel[D]. Guanghzou:South China University of Technology, 2018.
[15]
Facchi D P, Cazetta A L, Canesin E A, et al. New magnetic chitosan/alginate/Fe3O4@SiO2 hydrogel composites applied for removal of Pb(II) ions from aqueous systems[J]. Chemical Engineering Journal, 2018,337:595-608.
[16]
Lalhmunsiama, Pawar R R, Hong S, et al. Iron-oxide modified sericite alginate beads:A sustainable adsorbent for the removal of As(V) and Pb(II) from aqueous solutions[J]. Journal of Molecular Liquids, 2017,240:497-503.
[17]
Sigdel A, Park J, Kwak H, et al. Arsenic removal from aqueous solutions by adsorption onto hydrous iron oxide-impregnated alginate beads[J]. Journal of industrial and engineering chemistry, 2016,35:277-286.
[18]
Bezbaruah A N, Kalita H, Almeelbi T, et al. Ca-alginate-entrapped nanoscale iron:arsenic treatability and mechanism studies[J]. Journal of nanoparticle research:An interdisciplinary forum for nanoscale science and technology, 2014,16(1):2171-2175.
[19]
Zhang W, Wang H, Hu X, et al. Multicavity triethylenetetraminechitosan/alginate composite beads for enhanced Cr(VI) removal[J]. Journal of Cleaner Production, 2019,231:733-745.
[20]
Pan S, Zhang X, Qian J, et al. A new strategy to address the challenges of nanoparticles in practical water treatment:mesoporous nanocomposite beads via flash freezing[J]. Nanoscale, 2017,9(48):19154-19161.
[21]
Yi X, He J, Guo Y, et al. Encapsulating Fe3O4 into calcium alginate coated chitosan hydrochloride hydrogel beads for removal of Cu (II) and U (VI) from aqueous solutions[J]. Ecotoxicology and environmental safety, 2018,147:699.
[22]
Karzar Jeddi M, Mahkam M. Magnetic nano carboxymethyl cellulosealginate/chitosan hydrogel beads as biodegradable devices for controlled drug delivery[J]. International Journal of Biological Macromolecules, 2019,135:829-838.
[23]
Shim J, Kumar M, Mukherjee S, et al. Sustainable removal of pernicious arsenic and cadmium by a novel composite of MnO2 impregnated alginate beads:A cost-effective approach for wastewater treatment[J]. Journal of Environmental Management, 2019,234:8-20.
[24]
陈翀宇,付广义,赵媛媛,等.给水厂残泥-海藻酸钠胶珠对磷的吸附特性[J]. 环境化学, 2019,38(3):599-606. Chen C Y, Fu G Y, Zhao Y Y, et al. Adsorption characteristics of phosphorus on drinking water treatment residuals-sodiumalginate beads[J]. Environmental Chemistry, 2019,50(4):787-795.
[25]
Kang S, Park S, Park J, et al. Enhanced adsorption of arsenic using calcined alginate bead containing alum sludge from water treatment facilities[J]. Journal of Environmental Management, 2019,234:181-188.
Zeng H P, Zhao Y X, Lv Y F, et al. Arsenic adsorption behaviors of backwash sludge from waterworks for iron and manganese removal[J]. Journal of Harbin Institute of Technology, 2018,50(2):19-26.
[28]
赵运新,曾辉平,吕育锋,等.生物除铁除锰滤池反冲洗铁锰泥除As(Ⅴ)研究[J]. 中国给水排水, 2017,33(11):1-6. Zhao Y X, Zeng H P, Lv Y F, et al. As() Removal with Ⅴ iron and manganese oxide sludge from biological iron and manganese removal filter[J]. China Water & Wastewater, 2017,33(11):1-6.
[29]
曾辉平,尹灿,李冬,等.基于铁锰泥的除砷吸附剂性能比较及吸附机理[J]. 中国环境科学, 2018,38(9):3373-3379. Zeng H, Yin C, Li D, et al. Performance comparison and adsorption mechanism of arsenic removal adsorbents made of backwashing sludge from biofilter for iron and manganese removal.[J]. China Environmental Science, 2018,38(9):3373-3379.
[30]
Zeng H, Yin C, Qiao T, et al. As(V) Removal from water using a novel magnetic particle adsorbent prepared with iron-containing water treatment residuals[J]. ACS Sustainable Chemistry & Engineering, 2018,6(11):14734-14742.
[31]
曾辉平,尹灿,盛加宝,等.基于反冲洗铁泥制备的磁性吸附剂除砷及再生[J]. 中南大学学报(自然科学版), 2019,50(4):787-795. Zeng H P, Yin C, Sheng J B, et al. Arsenic removal and regeneration of magnetic adsorbent prepared from backwashing iron sludge[J]. Journal of Central South University (Science and Technology), 2019, 50(4):787-795.
