基于秸秆后发酵产沼气的一次发酵时间优化

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (646 KB) HTML (0 KB)
输出: BibTeX | EndNote (RIS)

摘要采用“一次发酵+ NaOH处理+二次发酵”工艺,以稻秸为原料,研究一次发酵时间对稻秸沼气发酵的影响.结果表明,一次发酵后的稻秸仍有一定的产气能力,干物质(TS)产气量为28.11~50.73mL/g TS,产气量大小与一次发酵时间成反比;一次发酵后的稻秸经NaOH处理后,稻秸物质结构受到明显破坏,有机物大量溶出,稻秸浸提液COD、总氮、铵态氮和硝态氮浓度分别较未经NaOH处理的稻秸提高128.56%~213.62%、93.92%~110.59%、53.90%~73.78%和112.08%~188.98%;NaOH处理并不能破坏稻秸的骨架结构,但稻秸官能团相对含量发生变化,加剧了纤维素、半纤维素和木质素结构的破坏.将一次发酵15,25和35d的稻秸经NaOH处理后用于沼气发酵,产气量较相应的对照分别提高了77.37%,119.41%和159.94%,一次发酵时间越长NaOH处理促进秸秆产气的效果越好.实验结束时,一次发酵15,25和35d的稻秸总产气量分别为202.78,205.15,210.21mL/g TS,三者间差异不显著,但较对照(CK)显著提高了11.89%、13.20%、15.99%,发酵周期较CK分别增加了-12,-2,8d.综上所述,采用“一次发酵+ NaOH处理+二次发酵”工艺时,一次发酵时间选择15d更合适.

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	陈广银
	曹海南
	黄艳
	汪玉
	王静
	常志州
	董金竹
	吴佩
	方彩霞

关键词 ：后发酵, 厌氧消化, 一次发酵时间, NaOH处理, 稻秸, 沼气

Abstract：To solve the problems of low chemical treatment efficiency and high treatment cost caused by entanglement of cellulose, hemicellulose and lignin in straw, the process of "first fermentation + NaOH treatment + secondary fermentation (PNS)" was adopted, and the effect of primary fermentation time on biogas production of straw was studied. The results indicated that the digested rice straw could still be used for biogas production with total solid (TS) biogas yield of 28.11-50.73mL/g TS, and the biogas yield was inversely proportional to first fermentation time. After the NaOH treatment, the material structure of digested rice straw was obviously damaged and a large amount of organic matter was leached out. The concentrations of COD, TN, NH₄⁺-N and NO₃^--N in the rice straw leachate were significantly increased by 128.56%~213.62%, 93.92%~110.59%, 53.90%~73.78% and 112.08%~188.98%, respectively, compared with those without NaOH treatment. NaOH treatment did not destroy the skeletal structure of digested rice straw, but changed the relative content of functional groups of digested rice straw, which intensified the destruction of cellulose, hemicellulose and lignin. After first fermentation of 15, 25, 35d and NaOH-treatment, the digested rice straw were reused for biogas production. The TS biogas production of digested rice straw were increased by 77.37%, 119.41% and 159.94%, respectively, compared with that under control treatment. The longer primary fermentation time, the better effect of promoting biogas production. After the experiment, the total biogas yield of rice straw of the treatment of primary fermentation time with 15, 25 and 35d were 202.78, 205.15 and 210.21mL/g TS, respectively, which were significantly increased by 11.89%, 13.20% and 15.99% compared with that of correspending control, and the total fermentation time were extended by -12, -2 and 8days. In summary, when adopting the process of PNS, the primary fermentation time of 15d is suitable.

Key words： post-fermentation anaerobic digestion primary fermentation time NaOH treatment rice straw biogas

收稿日期: 2021-09-24

PACS:

X705

基金资助:安徽高校协同创新项目(GXXT-2019-010);安徽省自然科学基金资助项目(1808085ME132);安徽师范大学博士科研启动金资助项目(2017XJJ40);国家自然科学基金资助项目(21707001)

通讯作者: 陈广银,副研究员,xzcf2004@163.com E-mail: xzcf2004@163.com

作者简介: 陈广银(1981-),男,江苏盐城人,副研究员,博士,主要从事有机固体沼气化及畜禽养殖污染治理方面的研究.发表论文60余篇.

引用本文:

陈广银, 曹海南, 黄艳, 汪玉, 王静, 常志州, 董金竹, 吴佩, 方彩霞. 基于秸秆后发酵产沼气的一次发酵时间优化[J]. 中国环境科学, 2022, 42(4): 1780-1787. CHEN Guang-yin, CAO Hai-nan, HUANG Yan, WANG Yu, WANG Jing, CHANG Zhi-zhou, DONG Jin-zhu, WU Pei, FANG Cai-xia. Optimization of the first fermentation time based on biogas post-fermentation with rice straw. CHINA ENVIRONMENTAL SCIENCECE, 2022, 42(4): 1780-1787.

链接本文:

http://www.zghjkx.com.cn/CN/ 或 http://www.zghjkx.com.cn/CN/Y2022/V42/I4/1780

[1]	孔军军,牛子一,于同金,等.水热预处理过程中pH值对玉米秸秆水解特性的影响[J]. 中国造纸, 2020,39(11):30-36. Kong J J, Niu Z Y, Yu T J, et al. Effect of pH value on hydrolysis performance of corn stover during hydrothermal pretreatment[J]. China Pulp & Paper, 2020,39(11):30-36.
[2]	杨淑蕙.植物纤维化学(第三版)[M]. 北京:中国轻工业出版社, 2001:5-8. Yang S H. Lignocellulosic chemistry (3rd ed.)[M]. Beijing:China Light Industry Press, 2001:5-8.
[3]	Komilis D P, Ham R K. The effect of lignin and sugars to the aerobic decomposition of solid wastes[J]. Waste Management, 2003,23(5):419-423.
[4]	Hendriks A T W M, Zeeman G. Pretreatments to enhance the digestibility of lignocellulosic biomass[J]. Bioresource Technology, 2009,100(1):10-18.
[5]	Zieliński M, Dębowski M, Kisielewska M, et al. Comparison of ultrasonic and hydrothermal cavitation pretreatments of cattle manure mixed with straw wheat on fermentative biogas production[J]. Springer Netherlands, 2019,10(4):747-754.
[6]	Taherzadeh M, Karimi K. Pretreatment of lignocellulosic wastes to improve ethanol and biogas production:a review[J]. International Journal of Molecular Sciences, 2008,9(9):1621-1651.
[7]	Zheng Y, Zhao J, Xu F Q, et al. Pretreatment of lignocellulosic biomass for enhanced biogas production[J]. Progress in Energy and Combustion Science, 2014,42:35-53.
[8]	陈广银.互花米草厌氧发酵新工艺及其机理研究[D]. 南京:南京大学, 2010. Chen G Y. New anaerobic fermentation process of Spartina Alterniflora and its mechanism[D]. Nanjing:Nanjing University, 2010.
[9]	陈广银,马慧娟,常志州,等.堆肥预处理温度控制促进麦秸厌氧发酵产沼气[J]. 农业工程学报, 2013,29(23):179-185. Chen G Y, Ma H J, Chang Z Z, et al. Promotion of biogas production of wheat straw by controlling composting pretreatment temperature[J]. Transactions of the Chinese Society of Agricultural Engineering, 2013,29(23):179-185.
[10]	罗艳.互花米草沼渣二次发酵特性研究[D]. 南京:南京大学, 2011. Luo Y. Study of anaerobic digestion of Spartina Alterniflora's biogas residue[D]. Nanjing:Nanjing University, 2011.
[11]	陈广银,郑正,罗艳,等.碱处理对秸秆厌氧消化的影响[J]. 环境科学, 2010,31(9):2208-2213. Chen G Y, Zheng Z, Luo Y, et al. Effect of alkaline treatment on anaerobic digestion of rice straw[J]. Environmental Science, 2010, 31(9):2208-2213.
[12]	罗艳,陈广银,罗兴章,等. NaOH溶液间歇式处理对互花米草厌氧发酵特性的影响[J]. 环境科学学报, 2010,30(10):2017-2021. Luo Y, Chen G Y, Luo XZ, et al. Effect of intermittent treatment with NaOH solution on anaerobic digestion with Spartina alterniflora[J]. Acta Scientiae Circumstantiae, 2010, 30(10):2017-2021.
[13]	Cesaro A, Velten S, Belgiorno V, et al. Enhanced anaerobic digestion by ultrasonic pretreatment of organic residues for energy production[J]. Journal of Cleaner Production, 2014,74:119-124.
[14]	Sambusiti C, Monlau F, Ficara E, et al. Comparison of various post-treatments for recovering methane from agricultural digestate[J]. Fuel Processing Technology, 2015,137:359-365.
[15]	国家环境保护总局. 水和废水监测分析方法(第四版)[M]. 北京:中国环境科学出版社, 2002:254-284. State Environmental Protection Administration. Water and wastewater monitoring and analysis methods[M]. Beijing:China Environmental Science Press, 2002:254-284.
[16]	鲍士旦.土壤农化分析[M]. 北京:中国农业出版社, 2000:30-110. Bao S D. Analysis of soil agrochemistry[M]. Beijing:Beijing China Agricultural Press, 2000:30-110.
[17]	杨胜.饲料分析及饲料质量检测技术[M]. 北京:北京农业大学出版社, 1983:58-63. Yang S. Feed analysis and quality test technology[M]. Beijing:Beijing Agricultural University Press, 1983:58-63.
[18]	王振旗,张敏,沈根祥,等.不同黄贮预处理对稻秸干法厌氧发酵特性的影响[J]. 农业环境科学学报, 2021,40(4):894-901. Wang Z Q, Zhang M, Shen G X, et al. Effects of different yellow- storage pretreatments on the dry anaerobic digestion characteristics of rice straw[J]. Journal of Agro-Environment Science, 2021,40(4):894-901.
[19]	Yao Y Q, Zhou J Y, An L Z, et al. Role of soil in improving process performance and methane yield of anaerobic digestion with corn straw as substrate[J]. Energy, 2018,151:998-1006.
[20]	李轶,宫兴隆,郭敬阳,等.不同预处理玉米秸秆对猪粪厌氧发酵重金属镉钝化效果[J]. 农业工程学报, 2020,36(11):254-260. Li Y, Gong X L, Guo J Y, et al. Effects of various pretreated maize stovers on the passivation of cadmium by anaerobic fermentation of pig manure[J]. Transactions of the Chinese Society of Agricultural Engineering, 2020,36(11):254-260.
[21]	梁越敢,郑正,汪龙眠,等.干发酵对稻草结构及产沼气的影响[J]. 中国环境科学, 2011,31(3):417-422. Liang Y G, Zheng Z, Wang L M, et al. Effect of dry digestion on structure changes and biogas production from rice straw[J]. China Environmental Science, 2011,31(3):417-422.
[22]	Kumar V, Rawat J, Patil, R C, et al. Exploring the functional significance of novel cellulolytic bacteria for the anaerobic digestion of rice straw[J]. Renewable Energy, 2021,169:485-497.
[23]	王景,魏俊岭,章力干,等.厌氧和好气条件下油菜秸秆腐解的红外光谱特征研究[J]. 中国生态农业学报, 2015,23(7):892-899. Wang J, Wei J L, Zhang L G, et al. FTIR characteristic of rapeseed straw decomposition under anaerobic and aerobic conditions[J]. Chinese Journal of Eco-Agriculture, 2015,23(7):892-899.
[24]	陈广银,郑正,常志州,等.NaOH处理对互花米草深度气化利用的影响[J]. 环境科学, 2011,32(8):2485-2491. Chen G Y, Zheng Z, Chang Z Z, et al. Effect of NaOH-treatment on advanced anaerobic biogasification of Spartina Alterniflora[J]. Environmental Science, 2011,32(8):2485-2491.
[25]	任海伟,沈佳莉,朱晓倩,等.菊芋秸秆制备微晶纤维素的工艺优化及结构表征[J]. 中国食品学报, 2018,18(1):119-127. Ren H W, Shen J L, Zhu X Q, et al. Structural characterization and optimization of extraction of microcrystalline cellulose from Jerusalem Artichoke stalk[J]. Journal of Chinese Institute of Food Science and Technology, 2018,18(1):119-127.
[26]	罗娟,赵立欣,孟海波,等.NaOH预处理提高甘蔗叶产甲烷性能及其机理分析[J]. 农业工程学报, 2019,35(24):262-270. Luo J, Zhao L X, Meng H B, et al. Improving methane production performance via NaOH pretreatment of sugarcane leaves and its mechanism analysis[J]. Transactions of the Chinese Society of Agricultural Engineering, 2019,35(24):262-270.
[27]	杜静,陈广银,黄红英,等.秸秆批式和半连续式发酵物料浓度对沼气产率的影响[J]. 农业工程学报, 2015,31(15):201-207. Du J, Chen G Y, Huang H Y, et al. Effect of fermenting material concentration on biogas yield in batch and continuous biogas fermentation with straws[J]. Transactions of the Chinese Society of Agricultural Engineering, 2015,31(15):201-207.