基于颗粒污泥的短程反硝化USB反应器启动和运行研究

摘要
图/表
参考文献
相关文章 (13)

全文: PDF (0 KB) HTML (0 KB)
输出: BibTeX | EndNote (RIS)

摘要在2个相同的USB反应器(R1无载体,R2采用多孔生物填料为载体)中构建了短程反硝化工艺,对R1和R2NO₃^--N→NO₂^--N转化性能、短程反硝化颗粒污泥物化特性、胞外聚合物(EPS)产生特性以及微生物功能菌群主要特征进行差异分析.结果表明,反应器运行81d,氮负荷(NLR)为1.2kg/(m³·d)时,NO₃^--N→NO₂^--N转化率(NTR) R2(85%)高于R1(80%);载体颗粒污泥(R2)沉降性能优于自固定化颗粒污泥(R1)且载体颗粒污泥(R2)更容易截留EPS,PN/PS值R1(1.29)>R2(1.15),污泥体积指数(SVI) R1(27.07mL/g MLSS)>R2(19.36mL/g MLSS);扫描电镜发现R1污泥表面聚集长杆菌,R2污泥表面聚集短杆菌和球菌,与R1相比R2颗粒污泥结构更加规则密实.微生物高通量测序结果表明,R2物种丰富度和多样性高于R1,变形菌门、拟杆菌门和绿弯菌门在短程反硝化系统中占主导地位,R1和R2主要NO₂^--N积累功能菌属均为Acinetobacter属(R1-59.18%、R2-46.04%)和Thauera属(R1-6.81%、R2-5.99%).

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	马瑞婕
	刘永红
	梁继东
	王宁
	解凤霞

关键词 ：短程反硝化(PDN), 厌氧氨氧化(Anammox), 亚硝酸盐积累, PDN颗粒污泥, 生物载体

Abstract：In this study, the partial denitrification process was constructed in two identical Up-flow Sludge Bed reactors (R1 without the carrier, R2 with porous biological carrier). The transformation performance of nitrate-to-nitrite, the physicochemical characteristics of partial denitrification granular sludge, the production characteristics of extracellular polymeric substances (EPS), and the dominant characteristics of functional bacteria genera were compared and analyzed. The NO₃^--N→NO₂^--N transformation ratio(NTR) in R2 (85%) was higher than that of R1(80%) when the reactors ran for 81 days and the nitrogen loading rates (NLR) was 1.2kg/(m³·d). The sedimentation performance of carrier granular sludge (R2) was better than that of self-immobilized granular sludge (R1), and the carrier granular sludge in R2 was easier to capture EPS. The PN/PS value of R1 (1.29) was greater than that of R2 (1.15), and the sludge volume index (SVI) of R1(27.07mL/g MLSS) was also greater than that of R2 (19.36mL/g MLSS). Under scanning electron microscopy, it was found that Long bacillus gathered on the surface of R1 sludge, while short-bacillus and coccus were observed on the surface of R2 sludge. In comparison, the structure of granular sludge in R2 was more regular and dense than that in R1. Microbial high throughput sequencing showed that the species richness and diversity of R2 were higher than that of R1. Proteobacteria, Bacteroides, and Chlorocurvate were dominant in the partial denitrification system. The main NO₂^--N accumulating genera in both R1 and R2 were Acinetobacter(R1 accounted for 59.18% and R2 accounted for 46.04%) and Thaurea (R1 accounted for 6.81% and R2 accounted for 5.99%).

Key words： partial denitrification (PDN) anaerobic ammonia oxidation (anammox) nitrite accumulation PDN granular sludge biological carrier

收稿日期: 2021-10-15

PACS:

X703

基金资助:国家自然科学基金青年科学基金资助项目(22008188);陕西省重点研发计划项目(2018ZDXM-SF-023,2019GY-154,2020SF-413);西安工程大学2021年度研究生创新基金资助项目(chx2021023)

通讯作者: 刘永红,教授,liuyhxa@hotmail.com E-mail: liuyhxa@hotmail.com

作者简介: 马瑞婕(1996-),女,山西大同人,西安工程大学硕士研究生,主要从事污水处理技术研究.

引用本文:

马瑞婕, 刘永红, 梁继东, 王宁, 解凤霞. 基于颗粒污泥的短程反硝化USB反应器启动和运行研究[J]. 中国环境科学, 2022, 42(5): 2129-2135. MA Rui-jie, LIU Yong-hong, LIANG Ji-dong, WANG Ning, XIE Feng-xia. Study on start-up and operation of USB reactor for partial denitrification based on granular sludge. CHINA ENVIRONMENTAL SCIENCECE, 2022, 42(5): 2129-2135.

链接本文:

http://www.zghjkx.com.cn/CN/ 或 http://www.zghjkx.com.cn/CN/Y2022/V42/I5/2129

[1]	赵鑫磊,邢嘉伟,付雪,等.NO2--N/NH4+-N及COD/NH4+-N对厌氧氨氧化耦合反硝化脱氮除碳的影响 [J]. 中国环境科学, 2021,41(6): 2586-2594. Zhao X L, Xing J W, Fu X, et al. Effect of NO2--N/NH4+-N and COD/NH4+-N on anaerobic ammonia oxidation coupled denitrification nitrogen and carbon removal [J]. China Environmental Science, 2021, 41(6):2586-2594.
[2]	毛佩玥,付雪,赵鑫磊,等.短程反硝化的启动及多参数优化下NO2--N积累特性 [J]. 中国环境科学, 2021,41(3):1189-1198. Mao P Y, Fu X, Zhao X L, et al.Start-up of partial denitrification and characteristics of nitrite accumulation by multiple factors [J]. China Environmental Science, 2021,41(3):1189-1198.
[3]	Cao S B, Wang S Y, Peng Y Z, et al. Achieving partial denitrification with sludge fermentation liquid as carbon source: the effect of seeding sludge [J]. Bioresource Technology, 2013,149:570-574.
[4]	陈凯琦,张亮,孙事昊,等.新型PD/A工艺同步处理低C/N生活原水和二级出水 [J]. 中国环境科学, 2020,40(4):1515-1522. Chen K Q, Zhang L, Sun S H, et al. Novel PD/A process to treat low C/N domestic wastewater and secondary effluent simultaneously [J]. China Environmental Science, 2020,40(4):1515-1522.
[5]	Wang J X, Liang J D, Sun L, et al. Achieving reliable partial nitrification and anammox process using polyvinyl alcohol gel beads to treat low-strength ammonia wastewater [J]. Bioresource Technology, 2021,324:124669.
[6]	Cao S B, Peng Y Z, Du R, et al. Characterization of partial denitrification (PD) granular sludge producing nitrite: effect of loading rates and particle size [J]. Science of the Total Environment, 2019, 671:510-518.
[7]	Du R, Cao S B, Zhang H Y, et al. Formation of partial-denitrification (PD) granular sludge from low-strength nitrate wastewater: The influence of loading rates [J]. Journal of Hazardous Materials, 2020, 384:121273.
[8]	周锋,刘勇弟,厉巍.同步短程硝化-厌氧氨氧化-短程反硝化颗粒污泥培育过程及其性能 [J]. 环境科学, 2021,42(10):4864-4871. Zhou F, Liu Y D, Li W. Cultivation and performance analysis of simultaneous partial nitrification, ANAMMOX, and denitratation granular sludge [J]. Environmental Science, 2021,42(10):4864-4871.
[9]	梁家豪,王庆宏,傅达理,等.加速厌氧污泥颗粒化研究进展 [J]. 工业水处理, 2017,37(1):18-22. Liang J H, Wang Q H, Fu D L, et al. Research progress in the acceleration of anaerobic sludge granulation process [J]. Industrial Water Treatment, 2017,37(1):18-22.
[10]	郝伟,刘永军,刘喆,等.低有机负荷下不同载体对好氧污泥颗粒化的影响 [J]. 化工进展, 2018,37(8):3222-3230. Hao W, Liu Y J, Liu Z, et al. Effects of different carriers on the process of aerobic activated sludge granulation with low-strength wastewater [J]. Chemical Industry and Engineering Progress, 2018, 37(8):3222-3230.
[11]	操沈彬.基于短程反硝化的厌氧氨氧化脱氮工艺与菌群特性 [D]. 哈尔滨:哈尔滨工业大学, 2018. Cao S B. Nitrogen removal via ANAMMOX process based on partial- denitrification and microbial characteristics [D]. Harbin: Harbin Institute of Technology, 2018.
[12]	刘永红,党康,王宁,等.基于新型载体AMC/UASB-SCMBBR生物工艺处理印染废水的中试研究 [J]. 环境科学学报, 2019,39(10): 3350-3355. Liu Y H, Dang K, Wang N, et al.Pilot study on dyeing wastewater treatment by using AMC /UASB-SCMBBR biological process based on novel carriers [J]. Acta Scientiae Circumstantiae, 2019,39(10): 3350-3355.
[13]	Qian W T, Ma B, Li X Y, et al. Long-term effect of pH on denitrification: High pH benefits achieving partial-denitrification [J]. Bioresource Technology, 2019,278:444-449.
[14]	Wang J X, Liang J D, Sun L, et al. Granule-based immobilization and activity enhancement of anammox biomass via PVA/CS and PVA/CS/Fe gel beads [J]. Bioresource Technology, 2020,309:123448.
[15]	陈茂霞,周后珍,朱晓华,等.考马斯亮蓝法检测活性污泥中蛋白质含量优化 [J]. 环境科学与技术, 2015,38(4):1-5. Chen M X, Zhou H Z, Zhu X H, et al. Optimization of determination of protein in activated sludge by bradford method [J]. Environmental Science & Technology, 2015,38(4):1-5.
[16]	张星星,王超超,王垚,等.基于不同废污泥源的短程反硝化快速启动及稳定性 [J]. 环境科学, 2020,41(8):3715-3724. Zhang X X, Wang C C, Wang Y, et al. Rapid start-up and stability of partial denitrification based on different waste sludge sources [J]. Environmental Science, 2020,41(8):3715-3724.
[17]	Zhang Z Z, Zhang Y, Chen Y G, et al. Recent advances in partial denitrification in biological nitrogen removal: from enrichment to application [J]. Bioresource Technology, 2020,298:122444.
[18]	Pan Y T, Ye L, Ni B J, et al. Effect of pH on N2O reduction and accumulation during denitrification by methanol utilizing denitrifiers [J]. Water Research, 2012,46(15):4832-4840.
[19]	Si Z, Peng Y Z, Yang A M, et al. Rapid nitrite production via partial denitrification: pilot-scale operation and microbial community analysis [J]. Environmental Science: Water Research & Technology, 2018,4(1):80-86.
[20]	Qian W T, Ma B, Li X L, et al. Long-term effect of pH on denitrification: High pH benefits achieving partial denitrification [J]. Bioresource Technology, 2019,278:444-449.
[21]	Suja E, Nancharaiah Y V, Mohan T V K, et al. Denitrification accelerates granular sludge formation in sequencing batch reactors [J]. Bioresource Technology, 2015,176:32–37.
[22]	Zhang P, Fang F, Chen Y P, et al. Composition of EPS fractions from suspended sludge and biofilm and their roles in microbial cell aggregation [J]. Chemosphere, 2014,117:59-65.
[23]	彭永臻,王锦程,李翔晨,等.氮负荷对短程反硝化耦合厌氧氨氧化生物膜系统脱氮性能的影响 [J]. 北京工业大学学报, 2021,47(12): 1367-1376. Peng Y Z, Wang J C, Li X C, et al. Effect of nitrogen loading rates on nitrogen removal performance of partial-denitrification coupling with Anammox biofilm system [J]. Journal of Beijing University of Technology, 2021,47(12):1367-1376.
[24]	李鸿,张立秋,张绍青,等.Cd2+胁迫对短程反硝化的影响与微生物群落变化 [J]. 中国给水排水, 2021,37(5):10-16,25. Li H, Zhang L Q, Zhang S Q, et al. Effects of Cd2+ stress on partial denitrification and change of microbial community [J]. China Water & Wastewater, 2021,37(5):10-16,25.
[25]	Sheng G P, Yu H Q, Li X Y. Extracellular polymeric substances (EPS) of microbial aggregates in biological wastewater treatment systems: a review [J]. Biotechnology Advances, 2010,28(6):882-894.
[26]	Yan L, Liu Y, Wen Y, et al. Role and significance of extracellular polymeric substances from granular sludge for simultaneous removal of organic matter and ammonia nitrogen [J]. Bioresource Technology, 2015,179:460-466.
[27]	Liu C S, Li W Fi, Li X C, et al. Nitrite accumulation in continuous- flow partial autotrophic denitrification reactor using sulfide as electron donor [J]. Bioresource Technology, 2017,243:1237–1240.
[28]	张小玲,张萌,陈紫薇,等.内碳源短程反硝化启动及EPD- ANAMMOX耦合工艺性能 [J]. 中国环境科学, 2022,42(2): 601-611. Zhang X L, Zhang M, Chen Z W, et al. Start-up of endogenous partial denitrification and performance of EPD-ANAMMOX coupling process [J]. China Environmental Science, 2022,42(2):601-611.
[29]	Cao S B, Du R, Li B K, et al. Nitrite production from partial- denitrification process fed with low carbon /nitrogen(C/N) domestic wastewater: performance, kinetics and microbial community [J]. Chemical Engineering Journal, 2017,326:1186-1196.
[30]	张星星,张钰,王超超,等.短程反硝化耦合厌氧氨氧化工艺及其应用前景研究进展 [J]. 化工进展, 2020,39(5):1981-1991. Zhang X X, Zhang Y, Wang C C, et al. Research advances in application prospect of partial denitrification coupled with anammox: a review [J]. Chemical Industry and Engineering Progress, 2020,39 (5):1981-1991.