垃圾填埋场生化降解指标测试及液气产量评估

柯瀚; 徐兴; 胡杰; 张美兰; 兰盛泽; 徐辉; 张晨晟; 肖电坤

PDF(746 KB)

中国环境科学 ›› 2021, Vol. 41 ›› Issue (9) : 4167-4175.

固体废物

垃圾填埋场生化降解指标测试及液气产量评估

柯瀚¹, 徐兴¹, 胡杰¹, 张美兰², 兰盛泽¹, 徐辉^1,3, 张晨晟¹, 肖电坤¹

作者信息 +

Biochemical degradation index test and liquid-gas production evaluation of waste landfill

KE Han¹, XU Xing¹, HU Jie¹, ZHANG Mei-Lan², LAN Sheng-Ze¹, XU Hui^1,3, ZHANG Chen-Sheng¹, XIAO Dian-Kun¹

Author information +

文章历史 +

摘要

以上海某综合垃圾填埋场作为研究对象，钻取不同龄期的生活垃圾测试固液气生化降解指标，并对全场的渗滤液产量以及填埋气产量进行评估.经过测试和计算，该处区域已开始稳定产甲烷，进入慢速降解阶段.其中，固相垃圾样的C/L（纤维素与木质素的比值）大部分集中在0.72~1.53之间；渗滤液pH值介于7.91~8.92，BOD介于1050~5780mg/L，COD介于2640~15200mg/L，NH₃-N介于2110~4360mg/L.引入固相、液相以及气相归一化指标β₁、β₂、β₃，用于评估填埋场降解阶段.其中，β₁介于0.56~0.83，β₂介于0.65~0.76，β₃介于0.97~1.02.β₁与β₂能够作为判定垃圾场降解阶段的指标，但β₃只能作为判定垃圾场是否处于稳定产甲烷阶段的指标.另外，建立考虑垃圾压缩-渗流耦合作用的渗滤液产量计算方法，垃圾自身渗滤液产率在70%~80%左右；采用垃圾两阶段降解模型计算填埋气产量，随着垃圾停止入场填埋，填埋气可收集量快速降低，至2025a降至峰值的3.88%，至2040a降至峰值的0.08%.

Abstract

Taking a comprehensive waste landfill in Shanghai as the research object, the municipal solid waste samples were drilled for testing of biochemical degradation index. The results showed that the waste in the testing area has begun to produce methane stably, and it entered the slow degradation stage. Among them, the C/L(the ratio of cellulose and lignin) values of solid waste samples range from 0.72 and 1.53; pH values of leachate were between 7.91 to 8.92; BOD values were between 1050 and 5780mg/L, COD values were between 2640 and 15200mg/L, NH₃-N values were between 2110~4360 mg/L. The normalized indexes β₁, β₂, and β₃ for solid, liquid and gas phases were introduced to evaluate the degradation stage of the landfill. Among them, β₁ values were between 0.56 and 0.83; β₂ values were between 0.65 and 0.76; β₃ values were between 0.97 and 1.02. β₁ and β₂ could be used as the indicators determining the degradation stage of landfill, but β₃ could only be used to determine whether it is in the stable methane production stage. In addition, the calculation method of leachate production considering the coupling effect of compression and seepage was established. The leachate production rate from waste was around 70%~80%. The landfill gas production was calculated using the two-stage degradation model. As the waste stops landfilling, the landfill gas production rapidly decreased, and it would drop to 3.88% of the peak value by 2025 and would reduce to 0.08% of the peak value by 2040.

导出引用

柯瀚, 徐兴, 胡杰, 张美兰, 兰盛泽, 徐辉, 张晨晟, 肖电坤. 垃圾填埋场生化降解指标测试及液气产量评估[J]. 中国环境科学. 2021, 41(9): 4167-4175

KE Han, XU Xing, HU Jie, ZHANG Mei-Lan, LAN Sheng-Ze, XU Hui, ZHANG Chen-Sheng, XIAO Dian-Kun. Biochemical degradation index test and liquid-gas production evaluation of waste landfill[J]. China Environmental Science. 2021, 41(9): 4167-4175

中图分类号： X705

参考文献

[1] Chen Y-M, Xu W J, Xu X B, et al. Numerical modelling of biochemical, hydraulic and mechanical behaviors for landfills with high-food-waste-content MSW[C]. HongKong:International Conference on Geo-Energy and Geo-Environment, 2015.
[2] Zhan L-T, Xu H, Chen Y-M, et al. Biochemical, hydrological and mechanical behaviors of high-food waste content MSW landfill:Liquid-gas interactions observed from a large-scale experiment[J]. Waste Management, 2017,63:27-40.
[3] Chen Yun-min. A fundamental theory of environmental geotechnics and its application[J]. Chinese Journal of Geotechnical Engineering, 2014,36(1):1-46.
[4] 刘海龙,周家伟,陈云敏,等.城市生活垃圾填埋场稳定化评估[J]. 2016,50(12):2336-2342.Liu Hai-long, Zhou Jia-wei, Chen Yun-min, et al. Evaluation of municipal solid waste landfill stabilization[J]. Journal of Zhejiang University (Engineering Science), 2016,50(12):54-60.
[5] 徐辉.高厨余垃圾生化-水力-力学相互作用大型模型试验及应用[D]. 杭州:浙江大学, 2016.Xu Hui. Large-scale experiment on biochemo-hydro-mechanical behaviors of high-food-waste-content MSW and applications[D]. Hangzhou:Zhejiang University, 2016.
[6] 王静,裴佳钦.生活垃圾简易堆放场的稳定化判别及综合整治[J]. 中国资源综合利用, 2006,24(9):21-24.Wang Jing, Pei Jia-qin. The evaluating method of stabilization of MSW dumping sites and its pollution controlling[J]. China Resources Comprehensive Utilization, 2006,24(9):21-24.
[7] 王里奥,袁辉,崔志强,等.三峡库区垃圾堆放场稳定化指标体系[J]. 重庆大学学报, 2003,26(4):125-129.Wang Li-ao, Yuan Hui, Cui Zhi-qiang, et al. Stabilization Index System of Simple Landfill[J]. Journal of Chongqing University, 2003, 26(4):125-129.
[8] 王罗春,赵由才,陆雍森.大型垃圾填埋场垃圾稳定化研究[J]. 环境工程学报, 2001,2(4):15-17.Wang Luo-chun, Zhao You-cai, Lu Yong-sen. The study on stabilization of refuse in large-scale landfills[J]. Techniques and Equipment for Environmental Pollution Control, 2001,2(4):15-17.
[9] 王罗春,赵由才,陆雍森.垃圾填埋场稳定化及其研究现状[J]. 城市环境与城市生态, 2000,(5):36-39.Wang Luo-chun, Zhao You-cai, Lu Yong-sen. Overview on stabilization of refuse landfills[J]. Urban Environment and Urban Ecology, 2000,13(5):36-39.
[10] Barlaz M A, Rooker A P, Kjeldsen P, et al. Critical evaluation of factors required to terminate the postclosure monitoring period at solid waste landfills[J]. Environmental Science & Technology 2002, 36(16):3457-3464.
[11] 蒋建国,张唱,黄云峰,等.垃圾填埋场稳定化评价参数的中试实验研究[J]. 中国环境科学, 2008,28(1):58-62.Jiang Jian-guo, Zhang Chang, Huang Yun-feng, et al. Pilot experiment on evaluation parameters of land-fill stabilization process[J]. China Environmental Science, 2008,28(1):58-62.
[12] 林建伟,王里奥,陈玲,等.三峡库区小型垃圾堆放场生活垃圾的稳定化分析[J]. 环境科学与技术, 2005,28(3):46-47.Lin Jian-wei, Wang Li-ao, Chen Ling, et al. Stabilization analysis of household waste in small dumping sites in Three Gorges Area[J]. Environmental Science and Technology, 2005,28(3):46-47.
[13] 刘娟.垃圾填埋场稳定化进程核心表征指标研究[D]. 北京:清华大学, 2011.Liu Juan. Key indicators for municipal solid waste landfill stabilization process[D]. Beijing:Tsinghua University, 2011.
[14] 刘晓成.填埋生活垃圾稳定化特征及开采可行性研究[D]. 杭州:浙江大学, 2018.Liu Xiao-cheng. Study of stabilization characteristics and exploitability of landfilled municipal solid wastes[D]. Hangzhou:Zhejiang University, 2018.
[15] 陈晓哲.城市固体废弃物渗流-压缩-降解过程的模拟研究[D]. 杭州:浙江大学, 2013.Chen Xiao-zhe. Study on the flow-compresion-degration process of MSW[D]. Hangzhou:Zhejiang university, 2018.
[16] 郭汝阳.高食物含量垃圾生化与力学行为的研究[D]. 杭州:浙江大学, 2017.Guo Ru-yang. Research on the Biochemical and Mechanical Behaviors of High Food Content MSW[D]. Hangzhou:Zhejiang University, 2017.
[17] Barlaz M A. Forest products decomposition in municipal solid waste landfills[J]. Waste Management (Elmsford), 2006,26(4):321-333.
[18] 瞿贤,何品晶,邵立明,等.生物质组成差异对生活垃圾厌氧产甲烷化的影响[J]. 中国环境科学, 2008,(8):730-735.Qu Xian, He Pin-jin, Shao Li-min, et al. Effect of waste composition On anaerobic methanization of municipal solid waste[J]. China Environmental Science, 2008,(8):730-735.
[19] Alvarez-Vazquez H, Jefferson B, Judd S J. Membrane bioreactors vs conventional biological treatment of landfill leachate:a brief review[J]. Journal of Chemical Technology and Biotechnology, 2004,79(10):1043-1049.
[20] 陈云敏,刘晓成,徐文杰,等.填埋生活垃圾稳定化特征与可开采性分析:以我国第一代卫生填埋场为例[J]. 中国科学(技术科学), 2019, 49(2):199-211.Chen Y M, Liu X C, Xu W J, et al. Analysis on stabilization characteristics and exploitability of landfilled municipal solid waste:Case of a typical landfill in China[J]. Scientia Sinica (Technologica), 2019,49(2):199-211.
[21] CJJ176-2012生活垃圾卫生填埋场岩土工程技术规范[S].CJJ176-2012 Technical code for geotechnical engineering of municipal solid waste sanitary landfill[S].
[22] 马小飞.垃圾填埋场抽气试验及填埋气收集量评估方法[D]. 杭州:浙江大学, 2013.Ma Xiao-fei. Extraction test and evaluation method of landfill gas for municipal solid waste landfills[D]. Hangzhou:Zhejiang University, 2013.
[23] 李蕾,彭垚,谭涵月,等.填埋场原位好氧稳定化技术的应用现状及研究进展[J]. 中国环境科学, 2021,41(6):2725-2736.Li Lei, Peng Yao, Tan Han-yue, et al. Application status and research progress of in-situ landfill aeration[J]. China Environmental Sciencece, 2021,41(6):2725-2736.
[24] 刘娟,刘建国,李睿,等.表面沉降对填埋场加速稳定化进程的宏观表征[J]. 中国环境科学, 2011,31(10):1738-1742.Liu Juan, Liu Jian-guo, Li Rui, et al. Macroscopic indication of surface settlement to landfill stabilization-accelerated process[J]. China Environmental Science, 2011,31(10):1738-1742.