Sensitizer characteristics and its enhancement performance to sludge decomposition associated with microwave
WANG Zi-wen1, ZHANG Zheng-hao1, WANG Yan1, YANG Xu-jun2, YANG Han-wen2, LI Chong2, WANG Rui2, CHEN An-yi2, WANG Shuo1,3, LI Ji1,3
1. School of Environment and Civil Engineering, Jiangsu Key Laboratory of Anaerobic Biotechnology, Jiangnan University, Wuxi 214122, China;
2. Guolian Environment and Energy Group, Wuxi 214122, China;
3. Collaborative Innovation Center of Water Treatment Technology and Material of Jiangsu Colleges, Suzhou 215009, China
Sludge activated carbon (SAC), TiO2/SAC and Fe3O4/SAC were used as the sensitizers to enhance the decomposition of excess sludge associated with microwave. Based on the analysis of chemical oxygen demand (COD), DNA, nitrogen, phosphorus and organic matters from the filtrate, the optimal conditions were investigated. After loading TiO2 and Fe3O4 on SAC, the dielectric loss and hysteresis loss of electromagnetic wave were enhanced. When the dosage of TiO2/SAC was 0.25g/gSS, the filtrate COD concentration was 1900mg/L, which increased by factors of 4.52 and 1.86 to the excess sludge and sludge treated by microwave, however, the addition of Fe3O4 is more conducive to the decomposition of excess sludge, the filtrate COD content was up to 2540mg/L, which was 6.05 times and 2.45 times higher than that of excess sludge and sludge treated by microwave. In addition, the filtrate total phosphorus (TP), total nitrogen (TN), protein and polysaccharides concentrations increased by factors of 7.7, 16, 7.49 and 71.69, indicating that a large amount of intracellular and extracellular polymeric substances released to filtrate and further greatly increased the soluble content of organic matters. The pretreatment method of microwave + sensitizer is beneficial to resource utilization and recovery of nitrogen, phosphorus and organic matters in excess sludge.
王子文, 张正豪, 王燕, 杨叙军, 杨汉文, 李冲, 王瑞, 陈安怡, 王硕, 李激. 敏化剂特性及其耦合微波强化污泥破解研究[J]. 中国环境科学, 2020, 40(4): 1586-1593.
WANG Zi-wen, ZHANG Zheng-hao, WANG Yan, YANG Xu-jun, YANG Han-wen, LI Chong, WANG Rui, CHEN An-yi, WANG Shuo, LI Ji. Sensitizer characteristics and its enhancement performance to sludge decomposition associated with microwave. CHINA ENVIRONMENTAL SCIENCECE, 2020, 40(4): 1586-1593.
Sándor B, Zsuzsanna L, Zsuzsanna H H, et al. Comparison of the effects of microwave irradiation with different intensities on the biodegradability of sludge from the dairy- and meat-industry[J]. Bioresource Technology, 2011,102(2):814-821.
[2]
Bing T, Lin F Y, Shao S H, et al. Energy efficiency of pre-treating excess sewage sludge with microwave irradiation[J]. Bioresource Technology, 2010,101(14):5092-5097.
[3]
Tai HS, Jou CJG. Application of granular activated carbon packed-bed reactor in microwave radiation field to treat phenol[J]. Chemosphere, 1999,38(11):2667-2680.
[4]
吴慧英.微波辐射联用活性炭强化有毒物质去除及再生活性炭研究[D]. 湖南:湖南大学, 2011. Wu H Y. The study on microwave radiation combined with activated carbon to strengthen the removal of poisonous substance and regenerate activated carbon[D]. Hunan:Hunan University, 2011.
[5]
吴艳凤.二氧化钛基复合纤维的力学性能与吸波性能[D]. 哈尔滨:哈尔滨工业大学, 2018. Wu Y F. Mechanical and microwave absorbing properties of titania-based composite fibers[D]. Harbin:Harbin Institute of Technology, 2018.
[6]
Liu P, Yao Z, Ng V M H, et al. Facile synthesis of ultrasmall Fe3O4 nanoparticles on mxenes for high microwave absorption performance[J]. Composites Part A:Applied Science and Manufacturing, 2018, 115:371-382.
[7]
Cheng Y, Zhao H, Yang Z, et al. An unusual route to grow carbon shell on Fe3O4 microspheres with enhanced microwave absorption[J]. Journal of Alloys and Compounds, 2018,762:463-472.
[8]
Guan B Y, Yu L, Li J, et al. A universal cooperative assembly-directed method for coating of mesoporous TiO2 nanoshells with enhanced lithium storage properties[J]. Science Advances, 2016,2(3):e1501554.
[9]
马放,周家晖,郭海娟,等.磁性活性炭的制备及其吸附性能[J]. 哈尔滨工业大学学报, 2016,48(2):50-56. Ma F, Zhou J H, Guo H J, et al. Study on preparation and adsorption properties of magnetic activated carbon[J]. Journal of Harbin Institute of Technology, 2016,48(2):50-56.
[10]
Qiang Y, Heng Y L, Zhong L, et al. Physical and chemical properties of waste-activated sludge after microwave treatment[J]. Water Research, 2010,44(9):2841-2849.
[11]
国家环境保护总局.水和废水监测分析方法[M]. 4版.北京:中国环境科学出版社, 2002:120-246. State Environmental Protection Administration. Water and wastewater monitoring and analysis methods (Fourth Edition)[M]. Beijing:China Environmental Science Press, 2002:120-246.
[12]
Tarayre, Cédric, Clercq L D, et al. New perspectives for the design of sustainable bioprocesses for phosphorus recovery from waste[J]. Bioresource Technology, 2016,206:264-274.
[13]
党琦,于涌杰,程谊,等.过硫酸钾氧化法测定溶解性有机氮含量和15N丰度方法研究[J]. 土壤, 2013,45(6):999-1002. Dang Q, Yu Y J, Cheng Y, et al. Persulfate digestion method for analyzing dissolved organic nitrogen concentration and 15N excess in soils extracts[J]. Soils, 2013,45(6):999-1002.
[14]
Chen W, Westerhoff P, Leenheer J A, et al. Fluorescence excitation-Emission matrix regional integration to quantify spectra for dissolved organic matter[J]. Environmental Science & Technology, 2003,37(24):5701-5710.
[15]
Liu Y, Liu Z, Zhang A, et al. The role of EPS concentration on membrane fouling control:Comparison analysis of hybrid membrane bioreactor and conventional membrane bioreactor[J]. Desalination, 2012,305(5):38-43.
[16]
Saini P. Intrinsically conducting polymer-based blends and composites for electromagnetic interference shielding:Theoretical and experimental aspects[M]//Fundamentals of conjugated polymer blends, copolymers and composites:synthesis, properties and applications. John Wiley & Sons, Inc, 2015:449-518.
[17]
Peng S, Zhan C G. Preparation of steel slag porous sound-absorbing material using coal powder as pore former[J]. Journal of Environmental Sciences, 2015,36(10):67-75.
[18]
张刚.活性炭负载二氧化钛去除水中锑(Sb)的研究[D]. 昆明:昆明理工大学, 2017. Zhang G. Removal of antimony from raw water by activated carbon supported titanium dioxide[D]. Kuming:Kunming University of Science And Technology, 2017.
[19]
Zhang Y, Xiong X, Han Y, et al. Application of titanium dioxide-loaded activated carbon fiber in a pulsed discharge reactor for degradation of methyl orange[J]. Chemical Engineering Journal, 2010, 162(3):1045-1049.
[20]
Wang L, Li J, Wang Y, et al. Preparation of nanocrystalline Fe3O4 ferrite and their adsorption capability for Congo red[J]. Journal of Hazardous Materials, 2011,196:342-349.
[21]
Zhang Y, Nan Z. Preparation of magnetic ZnLa0.02Fe1.98O4/MWCNTs composites and investigation on its adsorption of methyl orange from aqueous solution[J]. Materials Research Bulletin, 2015,66:176-185.
[22]
李妤婕.生物模板法制备竹炭(BC)基复合材料及吸波性能研究[D]. 西安:西安建筑科技大学, 2018. Li J Y. Study on bamboo charcoal(BC)-based composites prepared by biological template method and their wave absorbing properties[D]. Xi'an:Xi'an University of Architecture and Technology, 2018.
[23]
Lew A, Krutzik P O, Hart M E, et al. Increasing rates of reaction:Microwave-assisted organic synthesis for combinatorial chemistry. Journal of Combinatorial Chemistry[J]. 2002,4(2):95-105.
[24]
Xu D C, Zhong C Q, Yin K H, et al. Alkaline solubilization of excess mixed sludge and the recovery of released phosphorus as magnesium ammonium phosphate[J]. Bioresource Technology, 2018,249:783-790.
[25]
Fatma S, Susana G L, Daniel S, et al. Microwave characterization of activated carbons[J]. Journal of Computer and Communications, 2018,6(1):112-123.
[26]
Shao Y D, Bin Q, et al. Comparison of pretreatment methods for phosphorus release from waste activated sludge[J]. Chemical Engineering Journal, 2019,368:754-763.
[27]
Yun F X, Fei Y, Liang Z, et al. Migration and transformation of phosphorus in municipal sludge by the hydrothermal treatment and its directional adjustment[J]. Waste Management, 2018,81:196-201.
[28]
Zhuang X, Huang Y, Song Y, et al. The transformation pathways of nitrogen in sewage sludge during hydrothermal treatment[J]. Bioresource Technology, 2017,245:463-470.
[29]
Dhar B R, Nakhla G, Ray M B. Techno-economic evaluation of ultrasound and thermal pretreatments for enhanced anaerobic digestion of municipal waste activated sludge[J]. Waste Management, 2012, 32(3):542-549.
[30]
王治军,王伟.剩余污泥的热水解试验[J]. 中国环境科学, 2005,25(S):56-60. Wang Z J, Wang W. Thermal hydrolysis test of surplus sludge[J]. China Environmental Science, 2005,25(S):56-60.
[31]
Ke K X, Yun C, Xie J, et al. Comparison of different treatment methods for protein solubilisation from waste activated sludge[J]. Water Research, 2017,122:492-502.