1. National Engineering Laboratory for Advanced Municipal Wastewater Treatment and Reuse Technology, Beijing University of Technology, Beijing 100124, China; 2. Research and Development Center of Beijing Drainage Group Corporation, Beijing 100022, China
Abstract:In this study, a sequencing batch reactor (SBR) treatment system operating in anoxic/aerobic (A/O) mode was established, and the optimization of hydroxylamine dosing point on partial nitrification of municipal wastewater was explored. Results of batch experiments showed that the presence of dissolved oxygen could reduce the inhibitory effect of hydroxylamine on NOB by (20±0.5)%. In addition, compared with the treatment without anoxic condition and extended anoxic duration (>15min), the activity inhibited ratio of NOB increased by 13%~25% with anoxic duration of 1~5min. The long-term experiments showed that the NO2--N accumulation rate of the partial nitrification system with hydroxylamine addition at the end of anoxic stage maintained above 92%, while it decreased gradually with hydroxylamine at aerobic stage. QPCR analysis showed that the inhibition on ammonia oxidizing bacteria (AOB) could be reduced with sufficient inhibition on NOB when the hydroxylamine was added at the end of anoxic period, facilitating the dominance of AOB in microbial community structure. This study provides a theoretical basis for optimizing hydroxylamine dosing point and maintaining stable partial nitrification process.
徐昊天, 张树军, 杜睿, 彭永臻. 利用羟胺实现城市污水短程硝化最优投加点选择[J]. 中国环境科学, 2021, 41(8): 3576-3583.
XU Hao-tian, ZHANG Shu-jun, DURui, PENG Yong-zhen. Selection of optimal dosing point for partial nitrification of municipal wastewater by hydroxylamine. CHINA ENVIRONMENTAL SCIENCECE, 2021, 41(8): 3576-3583.
Gong L X, Huo M X, Yang Q, et al. Performance of heterotrophic partial denitrification under feast-famine condition of electron donor:a case study using acetate as external carbon source[J]. Bioresource Technology, 2013,133:263-269.
[2]
LI W, LI L, QIU G. Energy consumption and economic cost of typical wastewater treatment systems in Shenzhen, China[J]. Journal of Cleaner Production, 2017,163:374-378.
[3]
Zessner M, Lampert C, Kroiss H, et al. Cost comparison of wastewater treatment in Danubian countries[J]. Water Science and Technology, 2010,62(2):223-230.
[4]
黄奕亮,张立秋,李淑更,等.短程硝化厌氧氨氧化联合处理实际垃圾渗滤液[J]. 工业水处理, 2018,38(3):37-41. Huang Y L, Zhang L Q, Li S G, et al. Combined treatment of real landfill leachate by short-cut nitrification and anammox[J]. Industrial water treatment, 2018,38(3):37-41.
[5]
周呈,黄勇,李祥.部分亚硝化-厌氧氨氧化联合工艺处理高氨氮废水研究进展[J]. 水处理技术, 2014,40(4):11-15. Zhou C, Huang Y, Li X. Research progress of partial nitrosation-anammox combined process for the treatment of high ammonia nitrogen wastewater[J]. Water Treatment Technology, 2014,40(4):11-15.
[6]
Liu Y W, Ngo H H, Guo W S, et al. The roles of free ammonia(FA) in biological wastewater treatment processes:A review[J]. Environment International, 2019,123:10-19.
[7]
祝贵兵,彭永臻,郭建华.短程硝化反硝化生物脱氮技术[J]. 哈尔滨工业大学学报, 2008,40(10):1552-1557. Zhu G B, Peng Y Z, Guo J H. Nitrogen removal by short-cut nitrification and denitrification[J]. Journal of Harbin Institute of Technology, 2008,40(10):1552-1557.
[8]
Hellinga C, Schellen A A J C, Mulder J W, et al. The sharon process:an innovative method for nitrogen removal from ammonium-rich waste water[J]. Water Science and Technology, 1998,37(9):135-142.
[9]
Blackburne R, Yuan Z G, Keller J. Partial nitrification to nitrite using low dissolved oxygen concentration as the main selection factor[J]. Biodegradation, 2008,19(2):303-312.
[10]
姜超,隋倩雯,陈梅雪,等.实时控制序批式膜生物反应器处理养猪废水的短程硝化[J]. 环境工程学报, 2017,11(11):5868-5876. Jiang C, Sui Q W, Chen M X, et al. Treatment of pig wastewater by short-cut nitrification using a sequencing batch membrane bioreactor[J]. Chinese Journal of Environmental Engineering, 2017,11(11):5868-5876.
[11]
Wang Q, Duan H, Wei W, et al. Achieving stable mainstream nitrogen removal via the nitrite pathway by sludge treatment using free ammonia[J]. Environmental Science and Technology, 2017,51(17):9800-9807.
[12]
Duan H, Ye L, Lu X, et al. Overcoming nitrite oxidizing bacteriaadaptation through alternating sludge treatment with free nitrous acid and free ammonia[J]. Environmental Science and Technology, 2019,53(4):1937-1946
[13]
Ge S J, Wang S Y, Yang X, et al. Detection of nitrifiers and evaluation of partial nitrification for wastewater treatment:a review[J]. Chemosphere, 2015,140:85-98.
[14]
Ma Y, Peng Y, Wang S, et al. Achieving nitrogen removal via nitrite in a pilot-scale continuous pre-denitrification plant[J]. Water Research, 2009,43(3):563-572.
[15]
郭建华,王淑莹,郑雅楠,等.实时控制实现短程硝化过程中种群结构的演变[J]. 哈尔滨工业大学学报, 2010,(8):88-92. Guo J H, Wang S Y, Zheng Y N, et al. The evolution of population structure in the process of short-cut nitrification under real-time control[J]. Journal of Harbin Institute of Technology, 2010,(8):88-92.
[16]
Jia Li, Qiong Zhang, Yongzhen Peng. Rapid start-up and stable maintenance of domestic wastewater nitritation through short-term hydroxylamine addition[J]. Bioresource Technology, 2019,278:468-472.
[17]
Okabe S, Oshiki M, Takahashi Y, et al. Development of long-term stable partial nitrification and subsequent anammox process[J]. Bioresource Technology, 2011,102(13):6801-6807.
[18]
Xu G J, Xu X C, Yang F L, et al. Partial nitrification adjusted by hydroxylamine in aerobic granules under high DO and ambient temperature and subsequent anammox for low C/N[J]. Chemical Engineering Journal, 2012,213:338-345.
[19]
陈佼,张建强,文海燕,等.羟胺抑制协同pH调控对人工快渗系统短程硝化的影响[J]. 环境科学学报, 2016,36(10):3728-3735. Chen J, Zhang J Q, Wen H Y, et al. Effect of pH on nitrification in artificial fast infiltration system[J]. Chinese Journal of Environmental Sciences, 2016,36(10):3728-3735.
[20]
Smith Michael B, March Jerry. March's advanvanced organic chemistry:Reactions, mechanisms, and structure[M]. New York:Wiley-Interscience, 2001:15-54.
[21]
Wei C Y, Saraf S R, Rogers W J, et al. Thermal runaway reaction hazards and mechanisms of hydroxylamine with acid/base contaminants[J]. Thermochimica Acta, 2004,421:1-9.
[22]
Wang Qingsheng, Wei Chunyang, Pėrez Lisa M, et al. Thermal decomposition pathways of hydroxylamine:Theoretical investigation on the initial steps[J]. J. Phys. Chem.(A), 2010,114(34):9262-9269.
[23]
李佳,李夕耀,张琼,等.投加羟胺原位恢复城市污水短程硝化-厌氧氨氧化工艺[J]. 中国环境科学, 2019,39(7):2789-2795. Li J, Li X Y, Zhang Q, et al. In situ nitrification and anaerobic ammonium oxidation of municipal wastewater by adding hydroxylamine[J]. China Environmental Science, 2019,39(7):2789-2795.
[24]
Wang Z, Zhang L, Zhang F Z, et al. Nitrite accumulation in comammox-dominated nitrification-denitrification reactors:Effects of DO concentration and hydroxylamine addition[J]. Journal of Hazardous Materials, 2020,384:121-375.
[25]
Sui Q W, Wang Y Y, Wang H Y, et al. Roles of hydroxylamine and hydrazine in the in-situ recovery of one-stage partial nitritation-anammox process:characteristics and mechanisms[J]. Science of the Total Environment, 2020,707:135-648.
[26]
Cisneros L O, Rogers W J, Mannan M S. Adiabatic calorimetric decomposition studies of 50wt.% hydroxylamine/water[J]. Journal of Hazardous Materials, 2001,82(1):13-24.
[27]
Cisneros L O, Rogers W J, Mannan M S. Effect of air in the thermal decomposition of 50mass% hydroxylamine/water[J]. Journal of Hazardous Materials, 2002,95(1/2):13-25.
[28]
Iwate Y, K Hiroshi. Decomposition of hydroxylamine/water solution with added iron ion[J]. Journal of Hazardous Materials, 2003,104(1/2):39-49.
[29]
Cisneros L O, Rogers W J, Mannan M S. Effect of iron ion in the thermal decomposition of 50mass% hydroxylamine/water solution[J]. Journal of Chemical and Engineering Data, 2003,48(5):1164-1169.
[30]
Li J, Zhang L, Liu J, et al. Hydroxylamine addition and real-time aeration control in sewage nitritation system for reduced start-up period and improved process stability[J]. Bioresource Technology, 2019,294:122-183.
[31]
马博言,刘缨,刘志培.短程硝化活性污泥微生物群落结构及羟胺代谢对短程硝化的影响[J]. 微生物学通报, 2019,46(8):1982-1987. Ma B Y, Liu Y, Liu Z P. Effect of nitrification on the microbial community structure and hydroxylamine metabolism of activated sludge[J]. Microbiology Bulletin, 2019,46(8):1982-1987.
[32]
Kim D J, Chang J S, Lee D I, et al. Nitrification of high strength ammonia wastewater and nitrite accumula-tion characteristics[J]. Water Sci Technol, 2003,47(11):45-51.
[33]
Fernandez B, Vilar A, Ben M, et al. Partial ni-trification of wastewater from an aminoplastic resin pro-ducing factory[J]. Water Sci Technol, 2005,52(10/11):517-524.
[34]
Schramm A, de Beer D, vanden Heuvel J C, et al. Microscaledistribution of populations and activities of Nitrosospira and Nitrospira spp. Along a macroscale gradient in a nitrifying bioreactor:quantification by In situ hybridization and the use of microsensors[J]. Applied and Environmental Microbiology, 1999, 65(8):3690-3696.
[35]
Wagner M, Loy A, Nogueira R, et al. Microbial community composition and function in wastewater treatment plants[J]. Antonie van Leeuwenhoek, 2002,81(1-4):665-680.
[36]
沈琛,张树军,彭永臻.游离羟胺对两种典型亚硝态氮氧化菌活性的影响[J]. 环境科学, 2020,41(6):2805-2811. Shen C, Zhang S J, Peng Y Z. Effects of free hydroxylamine on the activity of two typical nitrite oxidizing bacteria[J]. Environmental Science, 2020,41(6):2805-2811.
[37]
Wan X Y, Xiao P Y, Zhang D J, et al. The kinetics for ammonium and nitrite oxidation under the effect of hydroxylamine[J]. Water Science & Technology, 2015,73(5):1067-1073.
[38]
Gao D W, Peng Y Z, Li B K, et al. Shortcut nitrification-denitrification by real-time control strategies[J]. Bioresource Technology, 2009,100:2298-2300.
[39]
Qian W T, Peng Y Z, Li X Y, et al. The inhibitory effects of free ammonia on ammonia oxidizing bacteria and nitrite oxidizing bacteria under anaerobic condition[J]. Bioresource Technology, 2017,243:1247-1250.
[40]
Harper W F Jr, Terada A, Poly F, et al. The effect of hydroxylamine on the activity and aggregate structure of autotrophic nitrifying bioreactor cultures[J]. Biotechnology and Bioengineering, 2009,102(3):714-724.
[41]
乔昕,王博,彭永臻.羟胺对氨氧化菌和亚硝酸盐氧化菌的竞争性选择[J]. 环境科学, 2020,41(8):3765-3772. Qiao X, Wang B, Peng Y Z. Competitive selection of hydroxylamine for ammonia-oxidizing bacteria and nitrite oxidizing bacteria[J]. Environmental Science, 2020,41(8):3765-3772.