提高SBR好氧颗粒污泥脱氮除磷性能的策略调控

李冬; 李悦; 杨敬畏; 李雨朦; 张杰

PDF(455 KB)

中国环境科学 ›› 2022, Vol. 42 ›› Issue (10) : 4581-4587.

水污染与控制

提高SBR好氧颗粒污泥脱氮除磷性能的策略调控

李冬¹, 李悦¹, 杨敬畏³, 李雨朦¹, 张杰^1,2

作者信息 +

Strategy regulation to improve the nitrogen and phosphorus removal performance of SBR aerobic granular sludge

LI Dong¹, LI Yue¹, YANG Jing-wei³, LI Yu-meng¹, ZHANG Jie^1,2

Author information +

文章历史 +

摘要

室温下接种成熟好氧颗粒污泥于SBR反应器中，以实际生活污水为进水基质，采用梯度进水联合优化A/O/A时间配比策略以期提高污泥的脱氮除磷效果.结果表明，缺氧时间由0.5h延长至1.5h时，能同时保证脱氮除磷高效进行.此时A/O/A时间比为1：1.6：1，平均TN去除率提高至81.27%，平均TP去除率保持90%以上，平均COD去除率保持在85%以上.同时，同步硝化反硝化（SND）率降低至25.24%，缺氧吸磷比例由0.43%上升至2.81%，进而说明此A/O/A时间比下反硝化糖菌（DGAOs）的反硝化作用对脱氮的贡献增加.缺氧时间延长至2h，A/O/A时间比为3：5：4时，过度缺氧导致微生物内源呼吸和丝状菌繁殖，平均TN、TP去除率降低至51.48%、72.46%.缺氧时间为1.5h时，MLSS为3501mg/L较低，但MLVSS/MLSS （f）升高至0.95，说明淘洗掉了非功能菌，使脱氮除磷功能菌大量生长.随缺氧时间延长至1.5h，即A/O/A时间比为1：1.6：1，PN/PS增加至6.89，故颗粒稳定性不断增强，在1h以内缺氧时间延长对LB-EPS影响更大且对EPS含量影响不大，超过1h则对TB-EPS影响更大且EPS增加至126.16mg/g，继续延长缺氧时间至2h时，由于微生物内源呼吸大量死亡释放出PN、PS，故EPS含量增加至479.92mg/g.

Abstract

Mature aerobic granular sludge was inoculated into the SBR reactor at room temperature, and the actual domestic sewage was used as the influent matrix, and the A/O/A time ratio strategy was combined with gradient feeding to improve the denitrification and phosphorus removal effect of the sludge. When the anoxic time was extended from 0.5h to 1.5h, the efficient denitrification and phosphorus removal can be ensured at the same time. At this time, the A/O/A time ratio was 1:1.6:1 which made the average TN increase to 81.27%, the average TP removal rate to above 90%, and the average COD removal rate to above 85%. Meanwhile, the simultaneous nitrification and denitrification (SND) rate decreased to 25.24%, and the ratio of anoxic and phosphorus uptake increased from 0.43% to 2.81%, which further indicated that the denitrification contribution of denitrifying sugar bacteria (DGAOs) to denitrification increased at this A/O/A time ratio. When the anoxic time was extended to 2h and the A/O/A time ratio was 3:5:4, excessive hypoxia led to the endogenous respiration of microorganisms and the reproduction of filamentous bacteria. The average removal rates of TN and TP decreased to 51.48% and 72.46%, respectively. When the anoxic time was 1.5h, the MLSS was 3501mg/L which was lower but the MLVSS/MLSS(f) increased to 0.95, indicating that the non-functional bacteria were washed away. The bacteria with nitrogen and phosphorus removal functions can grow in large quantities. With an extension of the anoxic time to 1.5h (or the A/O/A time ratio is 1:1.6:1), the PN/PS increases to 6.89, so the stability of the particles was continuously enhanced. The extension of the hypoxia time to within 1h had a greater impact on LB-EPS and EPS but little effect on TB-EPS. The hypoxia time more than 1h had a greater effect on TB-EPS and can make EPS increase to 126.16mg/g. When the hypoxia time was extended to 2h, the EPS content increased to 479.92mg/g due to the massive death of microbes that intake PN and PS released from endogenous respiration of microorganisms.

导出引用

李冬, 李悦, 杨敬畏, 李雨朦, 张杰. 提高SBR好氧颗粒污泥脱氮除磷性能的策略调控[J]. 中国环境科学. 2022, 42(10): 4581-4587

LI Dong, LI Yue, YANG Jing-wei, LI Yu-meng, ZHANG Jie. Strategy regulation to improve the nitrogen and phosphorus removal performance of SBR aerobic granular sludge[J]. China Environmental Science. 2022, 42(10): 4581-4587

中图分类号： X703

参考文献

[1] Baeza J A, Gabriel D, Lafuente J.Effect of internal recycle on the nitrogen removal efficiency of an anaerobic/anoxic/oxic (A²/O) wastewater treatment plant(WWTP)[J].Process Biochemistry, 2004, 39(11):1615-1624.
[2] 李洪静,陈银广,顾国维.丙酸的加入对厌氧-低氧同时生物除磷脱氮系统的影响[J].环境科学, 2007,28(8):1681-1686.Li H J, Chen Y G, Gu G W.Addition of propionic acid on simultaneous biological phosphorus and nitrogen removal in anaerobic-low dissolved oxygen system[J].Environmental Science, 2007,28(8):1681-1686.
[3] 李冬,李悦,李雨朦,等.梯度进水下好氧颗粒污泥同步硝化内源反硝化脱氮除磷研究[J].中国环境科学, 2022,42(3):1113-1119.Li D, Li Y, Li Y M, et al.Study on simultaneous nitrification and endogenous denitrification for nitrogen and phosphorus removal by aerobic granular sludge under gradient feeding[J].China Environmental Science, 2022,42(3):1113-1119.
[4] Pijuan M, Saunder A M.Enhanced biological phosphorus removal in a sequencing batch reactor using propionate as the sole carbon source[J].Biotechnology and Bioengineering, 2004,(85):56-67.
[5] Oehmen A, Saunders A M, Vives M T, et al.Competition between polyphosphate and glycogen accumulating organisms in enhanced biological phosphorus removal systems with acetate and propionate as carbon sources[J].Journal of Biotechnology, 2006,123(1):22-32.
[6] Straka M K W A.New directions in biological nitrogen removal and recovery from wastewater[J].Environmental Biotechnology, 2018,57:50-55.
[7] Wang X, Zeng R J, Dai Y, et al.The denitrification capability of cluster 1defluviicoccus vanus-related glycogen-accumulating organisms[J].Biotechnology and Bioengineering, 2008,99(6):1329-1336.
[8] 张可方,张朝升,罗思音,等.SBR短程同步硝化反硝化耦合除磷的研究[J].中国给水排水, 2010,26(7):65-67.Zhang K F, Zhang C S, Luo S Y, et al.Coupling of short-cut simultaneous nitrification and denitrification with denitrifying phosphorus removal in SBR[J].China Water & Wastewater, 2010, 26(7):65-67.
[9] Zhang X, Sun Y, Ma F, et al.In-situ utilization of soluble microbial product (SMP) cooperated with enhancing SMP-dependent denitrification in aerobic-anoxic sequencing batch reactor[J].Science of the Total Environment, 2019,693:133558.
[10] Zhao W, Huang Y, Wang M, et al.Post-endogenous denitrification and phosphorus removal in an alternating anaerobic/oxic/anoxic (AOA) system treating low carbon/nitrogen (C/N) domestic wastewater[J].Chemical Engineering Journal, 2018,339:450-458.
[11] Brown P, Ong S K, Lee Y.Influence of anoxic and anaerobic hydraulic retention time on biological nitrogen and phosphorus removal in a membrane bioreactor[J].Desalination, 2011,270(1-3):227-232.
[12] 季强.水质检测与分析[M].北京:中国建筑工业出版社, 2015.Ji Q.Water quality testing and analysis[M].Beijing:China Architecture & Building Press, 2015.
[13] Li X Y, Yang S F.Influence of loosely bound extracellular polymeric substances (EPS) on the flocculation, sedimentation and dewaterability of activated sludge[J].Water Research, 2007,41(5):1022-1030.
[14] Frolund B, Griebe T, Nielsen P H.Enzymatic activity in the activated-sludge floc matrix[J].Applied Microbiology And Biotechnology, 1995,43(4):755-761.
[15] Loewus F A.Improvement in anthrone method for determination of carbohydrates[J].Analytical Chemistry, 1952,24(1):219.
[16] 于德爽,袁梦飞,王晓霞,等.厌氧/好氧SPNDPR系统实现低C/N城市污水同步脱氮除磷的优化运行[J].环境科学, 2018,39(11):5065-5073.Yu D S, Yuan M F, Wang X X, et al.Simultaneous nitrogen and phosphorus removal characteristics of an anaerobic/aerobic operated SPNDPR system treating low C/N urban sewage[J].Environment Sience, 2018,9(11):065-5073.
[17] Wang X, Wang S, Xue T, et al.Treating low carbon/nitrogen (C/N) wastewater in simultaneous nitrification-endogenous denitrification and phosphorous removal (SNDPR) systems by strengthening anaerobic intracellular carbon storage[J].Water Research, 2015,77:191-200.
[18] 张玉君,李冬,王歆鑫,等.间歇梯度曝气下首段延时厌氧强化好氧颗粒污泥脱氮除磷[J].环境科学, 2021,42(7):3405-3412.Zhang Y J, Li D, Wang X X, et al.First Extended Anaerobic Phase Enhanced Nitrogen and Phosphorus Removal by Aerobic Granular Sludge Under Intermittent Gradient Aeration[J].Environment Sience, 2021,42(7):3405-3412.
[19] 李冬,刘博,王文琪,等.除磷颗粒诱导的同步短程硝化反硝化除磷颗粒污泥工艺[J].环境科学, 2020,41(2):867-875.Li D, Liu B, Wang W Q, et al.Simultaneous short-cut nitrification-denitrification phosphorus removal granules Induced by phosphorus removal granules[J].Environment Sience, 2020,41(2):867-875.
[20] 戴娴,彭永臻,王晓霞,等.不同厌氧时间对富集聚磷菌的SNDPR系统处理性能的影响[J].中国环境科学, 2016,36(1):92-99.Peng Y Z, Wang X X, Wang S Y.Effect of different anaerobic time on the nutrient removal in simultaneous nitrification-denitrification and phosphorus removal (SNDPR) systems enriched with phosphorus accumulating organisms[J].China Environmental Science, 2016,36(1):92-99.
[21] 彭赵旭,左金龙,彭永臻.同步硝化反硝化的影响因素研究[J].给水排水, 2009,5(35):167-171.Peng Z X, Peng Y Z, Zuo J L.Study of influence factors on simultaneous nitrification and denitrification[J].Water & Wastewater Engineering, 2009,5(35):167-171.
[22] 张建华,王淑莹,张淼,等.不同反应时间内碳源转化对反硝化除磷的影响[J].中国环境科学, 2017,37(3):989-997.Zhang J H, Wang S Y, Zhang M, et al.Effect of conversion of internal carbon source on denitrifying phosphorus removal under different reaction time[J].China Environmental Science, 2017,37(3):989-997.
[23] Layera M, Villodresa M G, Hernandez A, et al.Limited simultaneous nitrification-denitrification (SND) in aerobic granular sludge systems treating municipal wastewater:Mechanisms and practical implications[J].Water Research X, 2020, https://doi.org/10.1016/j.wroa.2020.100048.
[24] Liu G, Xu X Y, Zhu L, et al.Biological nutrient removal in a continuous anaerobic-aerobic-anoxic process treating synthetic domestic wastewater[J].Chemical Engineering Journal, 2013,22(1):223-229.
[25] Zhang M, Peng Y Z, Wang C, et al.Optimization denitrifying phosphorus removal at different hydraulic retention times in a novel anaerobic anoxic oxic-biological contact oxidation process[J].Biochemical Engineering Journal, 2016,106(15):26-36.
[26] Brown P, Ong S K, Lee Y W.Influence of anoxic and anaerobic hydraulic retention time on biological nitrogen and phosphorus removal in a membrane bioreactor[J].Desalination, 2011,270(1-3):227-232.
[27] 刘小英,赵红梅,彭党聪,等.SBR中生物除磷颗粒污泥的反硝化聚磷研究[J].环境科学, 2008,29(8):2254-2259.Liu X Y, Zhao H M, Peng D C, et al.Denitrifying phosphate uptake of biological phosphorous removal granular sludgein SBR[J].Environmental Science, 2008,29(8):2254-2259.
[28] 胡德秀,张艳,朱玲,等.污泥厌氧过程中磷释放与SMP特性研究[J].中国环境科学, 2018,38(8):2974-2980.Zhang Y, Zhu L, Xiong J L, et al.Characteristics of phosphorus released and soluble microbial products in anaerobic conditions of sludge[J].China Environmental Science, 2018,38(8):2974-2980.
[29] 罗曦,雷中方,张振亚,等.好氧/厌氧污泥胞外聚合物(EPS)的提取方法研究[J].环境科学学报, 2005,25(12):52-57.Luo X, Lei Z F, Zhang Z Y, et al.Study on the extraction of extracellular polymeric substances (EPS) from aerobic/anaerobic sludges[J].Acta Scientiae Circumstantiae, 2005,25(12):52-57.
[30] Zhu L, Lv M, Dai X, et al.Role and significance of extracellular polymeric substances on the property of aerobic granule[J].Bioresource Technology, 2012,107:46-54.
[31] Li D, Lv Y, Zeng H, et al.Startup and long term operation of enhanced biological phosphorus removal in continuous-flow reactor with granules[J].Bioresource Technology, 2016,212:92-99.