絮体老化与调节对回流进水及混凝的影响机制

庾俊杰; 徐慧; 孙鸿燕; 金之源; 王东升

PDF(2147 KB)

中国环境科学 ›› 2022, Vol. 42 ›› Issue (10) : 4612-4620.

水污染与控制

絮体老化与调节对回流进水及混凝的影响机制

庾俊杰^1,2,3, 徐慧^1,3, 孙鸿燕⁴, 金之源^1,2, 王东升^3,5

作者信息 +

Mechanism on the effects of floc aging and pH adjustment on reflux feed water and coagulation

YU Jun-jie^1,2,3, XU Hui^1,3, SUN Hong-yan⁴, JIN Zhi-yuan^1,2, WANG Dong-sheng^3,5

Author information +

文章历史 +

摘要

为探索絮体老化与pH值调节对回流进水颗粒组成及混凝的影响，采用激光粒度仪进行了絮体粒径分析并通过Al （OH）₃胶体（Al-gel）的老化实验探究了老化与pH值调节对絮体形态及性质的内在影响机制.结果表明，原水颗粒物粒径呈现单峰分布，絮体回流进水颗粒物粒径呈现双峰分布，并且回流进水颗粒d₅₀随着絮体老化时间的增加而减小；由于絮体回流提高了颗粒物与混凝剂接触机率和碰撞效率，因此加快了絮体的生长；絮体在pH=5的环境下老化12h后进行回流混凝的絮体粒径生长速率最高（1.16 μm/s）并且生成的絮体具有较大的分形维数（2.35）.Al-gel的老化实验结果表明，絮体老化过程会涉及羟桥反应和结晶反应并导致絮体的表面活性基团数量减少，从而不利于与原水颗粒物的相互作用.pH值调节对絮体产生不同的影响，pH=5的条件下进行老化会加速絮体的羟桥反应和结晶反应，而pH=9的条件下进行老化则会涉及溶解-沉淀-结晶反应.

Abstract

Effects of floc aging and pH adjustment on the particle composition and coagulation of the reflux water were investigated using laser particle size analyzer, and the mechanisms of aging and pH adjustment on floc properties were explored by the aging experiments of Al(OH)₃ gel (Al-gel). The results showed that the particle size of raw water displayed a unimodal distribution, and the particle size of the influent flocs presented a bimodal distribution. Meanwhile, there was a decrease of the particle d₅₀ of reflux water with the increase of aging time. The growth rate of the flocs increased as the reflux flocs that were subjected to reflux coagulation after being aged at pH=5 for 12h had the highest floc d₅₀ growth rate (1.16μm/s) and produced the flocs with a higher fractal dimension (2.35). The results of Al-gel aging experiment demonstrated that hydroxyl-bridging and crystallization reactions occurred during aging, leading to a reduction in the number of reactive groups on the floc surfaces, which was not conducive to the interaction with raw water particles. The pH adjustment had different effects on the flocs. For example, the aging at pH=5accelerated the hydroxyl-bridging and crystallization reactions, while the aging at pH=9 may involve dissolution-precipitation-crystallization interactions.

导出引用

庾俊杰, 徐慧, 孙鸿燕, 金之源, 王东升. 絮体老化与调节对回流进水及混凝的影响机制[J]. 中国环境科学. 2022, 42(10): 4612-4620

YU Jun-jie, XU Hui, SUN Hong-yan, JIN Zhi-yuan, WANG Dong-sheng. Mechanism on the effects of floc aging and pH adjustment on reflux feed water and coagulation[J]. China Environmental Science. 2022, 42(10): 4612-4620

中图分类号： X703

参考文献

[1] Spencer K L, Wheatland J A T, Bushby A J, et al.A structure-function based approach to floc hierarchy and evidence for the non-fractal nature of natural sediment flocs[J].Scientific Reports, 2021,11(1):14012.
[2] 盛雅琼.污泥回流工艺对低浊微污染水的强化处理及絮体分形特性研究[D].广州:广州大学, 2015.Sheng Y Q.Study on low turbidity micro-pollute water by enhanced coagulation of recycling sludge process and the floc dimention characteristics[D].Guangzhou:Guangzhou University, 2015.
[3] Chu W.Dye removal from textile dye wastewater using recycled alum sludge[J].Water Research, 2001,35(13):3147-3152.
[4] 王振平,郝亮亮,白世刚,等.絮凝污泥回流强化混凝的研究及应用[J].能源与环境, 2021,(4):59-69.Wang Z P, Hao L L, Bai S G, et al.Investigation and application of flocculated sludge reflux to enhance coagulation[J].Energy and Environment, 2021,(4):59-69.
[5] 汪俊杰,刘研萍,朱佳,等.不同条件的底泥回流对强化絮凝的影响[J].环境工程, 2020,38(3):82-86.Wang J J, Liu Y P, Zhu J, et al.Effects of sludge reflux under different conditions on flocculation strengthening[J].Environmental Engineering, 2020,38(3):82-86.
[6] 康旭.污泥回流强化混凝及微絮凝过滤处理北方低温低浊水[D].哈尔滨:哈尔滨工业大学, 2011.Kang X.The treatment of low temperature and low turbidity water in north area by sludge-reflux enhanced coagulation and micro-flocculation filtration[D].Harbin:Harbin Institute of Technology, 2011.
[7] 王伟强,李星,杨艳玲,等.污泥回流比对絮体破碎再絮凝及沉后水水质的影响[J].中国给水排水, 2014,30(17):70-72.Wang W Q, Li X, Yang Y L et al.Effect of sludge reflux ratio on breakage and re-growth of flocs and settled water quality[J].China Water & Wastewater, 2014,30(17):
[8] Guan X H, Chen G H, Shang C.Re-use of water treatment works sludge to enhance particulate pollutant removal from sewage[J].Water Research, 2005,39(15):3433-40.
[9] Zhou Z, Yang Y, Li X, et al.The removal characteristics of natural organic matter in the recycling of drinking water treatment sludge:Role of solubilized organics[J].Ultrasonics Sonochemistry, 2016,28:259-268.
[10] Zhou Z, Yang Y, Li X.Effects of ultrasound pretreatment on the characteristic evolutions of drinking water treatment sludge and its impact on coagulation property of sludge recycling process[J].Ultrasonics Sonochemistry, 2015,27:62-71.
[11] Zhou Z, Yang Y, Li X, et al.Characterization of drinking water treatment sludge after ultrasound treatment[J].Ultrasonics Sonochemistry, 2015,24:19-26.
[12] Zhou Z, Yang Y, Li X, et al.Coagulation performance and flocs characteristics of recycling pre-sonicated condensate sludge for low-turbidity surface water treatment[J].Separation and Purification Technology, 2014,123:1-8.
[13] Ebie K, Lee J H, Yoon T H.Activation mechanism and effectiveness in reusing sludge from water purification[J].Water Science Technology, 2000,42(3/4):273-281.
[14] Wu M, Yu W, Qu J, et al.The variation of flocs activity during floc breakage and aging, adsorbing phosphate, humic acid and clay particles[J].Water Research, 2019,155:131-141.
[15] Yu W, Gregory J, Campos L C, et al.Dependence of floc properties on coagulant type, dosing mode and nature of particles[J].Water Research, 2015,68:119-126.
[16] Berkowitz J, Anderson M A, Graham R C.Laboratory investigation of aluminum solubility and solid-phase properties following alum treatment of lake waters[J].Water Research, 2005,39(16):3918-3928.
[17] Berkowitz J, Anderson M A, Amrhein C.Influence of aging on phosphorus sorption to alum floc in lake water[J].Water Research, 2006,40(5):911-916.
[18] Yu W, Graham N, Yang Y, et al.Effect of sludge retention on UF membrane fouling:The significance of sludge crystallization and EPS increase[J].Water Research, 2015,83:319-328.
[19] Yu W, Liu M, Zhang X, et al.Effect of pre-coagulation using different aluminium species on crystallization of cake layer and membrane fouling[J].Clean Water, 2019,2:17.
[20] Wang W, Zhao S, Yue Q, et al.Purification, characterization and application of dual coagulants containing chitosan and different Al species in coagulation and ultrafiltration process[J].Journal of Environmental Sciences, 2017,51:214-221.
[21] Wang W, Yue Q, Li R, et al.Optimization of coagulation pre-treatment for alleviating ultrafiltration membrane fouling:The role of floc properties on Al species[J].Chemosphere, 2018,200:86-92.
[22] Wu Z, Zhang X, Zhou C, et al.Adsorption neutralization model and floc growth kinetics properties of aluminum coagulants based on sips and boltzmann equations[J].Applied Materials & Interfaces, 2017, 9(7):5992-5999.
[23] Xu W, Gao B, Yue Q, et al.Effect of preformed and non-preformed Al13species on evolution of floc size, strength and fractal nature of humic acid flocs in coagulation process[J].Separation and Purification Technology, 2011,78(1):83-90.
[24] Yu W, Xu L, Lei K, et al.Effect of crystallization of settled aluminum hydroxide precipitate on "dissolved Al"[J].Water Research, 2018,143:346-354.
[25] Mossaad C, Tan M C, Starr M, et al.Size-dependent crystalline to amorphous uphill phase transformation of hydroxyapatite nanoparticles[J].Crystal Growth & Design, 2011,11(1):45-52.
[26] Zhang X, Huestis P L, Pearce C I, et al.Boehmite and gibbsite nanoplates for the synthesis of advanced alumina products[J].Applied Nano Materials, 2018,1(12):7115-7128.
[27] Zhang H, Zhang X, Graham T R, et al.Crystallization and phase transformations of aluminum (Oxy)hydroxide polymorphs in caustic aqueous solution[J].Inorganic Chemistry, 2021,60(13):9820-9832.
[28] Zhang X, Graham N, Xu L, et al.The influence of small organic molecules on coagulation from the perspective of hydrolysis competition and crystallization[J].Environmental Science & Technology, 2021,55(11):7456-7465.
[29] Hu J Z, Zhang X, Jaegers N R, et al.Transitions in Al coordination during gibbsite crystallization using high-field 27Al and 23Na MAS NMR spectroscopy[J].The Journal of Physical Chemistry C, 2017,121(49):27555-27562.
[30] Sun H, Jiao R, Xu H, et al.The influence of particle size and concentration combined with pH on coagulation mechanisms[J].Journal of Environmental Sciences, 2019,82:39-46.