Parameter optimization of CANON granular-flocculate composite system with side-flow FNA suppression
REN Zhi-qiang1, LI Dong1, WANG Wen-qiang1, ZHANG Jie1,2
1. Key Laboratory of Beijing Water Quality Science and Water Environment Recovery Engineering, Beijing University of Technology, Beijing 100124, China; 2. State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin 150090, China
Abstract：In order to explore the best combination of process parameters related to the strategy of inhibiting nitrite oxidizing bacteria (NOB) by side flow free nitrous acid (FNA) treatment, in the completely autotrophic nitrogen removal over nitrite (CANON) process of granular-flocculate composite system, batch test was used to explore the effects of sludge sedimentation time, FNA treatment concentration and FNA processing and processing time to the related functional bacteria activity influence. The NOB activity was targeted inhibition and treatment time on the activity of relevant functional bacteria, so as to inhibit the activity of NOB and reduce the effect of FNA on the activity of functional bacteria. The result showed that the settling time affected the activity of functional bacteria in the treated sludge. With the prolongation of the settling time, the activity of anaerobic ammonium oxidizing bacteria (AnAOB) in the discharged sludge gradually decreased. After settling for 1min, most of the discharged sludge was NOB, and retained as much AnAOB as possible in the reactor. At this time, the relative activities of AnAOB, ammonia oxidizing bacteria (AOB) and NOB were 15.79%, 54.55% and 68.63%, respectively. Considering the effect of FNA on the activity of NOB and AOB, the activity of AOB was 38.71%, while the NOB activity was only 12.5% after inhibition with 0.6mg/L FNA for 12h. The results of response surface analysis showed that the treatment time and treatment concentration of FNA were the key factors affecting the activity of NOB and AOB.
Ma B, Wang S Y, Cao S B, et al. Biological nitrogen removal from sewage via anammox:recent advances[J]. Bioresource Technology, 2016,200(1):981-990.
[2]
Heng Wang, Bolin Li, Ye Li, et al. Sludge ratio affects the start-up performance and functional bacteria distribution of a hybrid CANON system[J]. Chemosphere, 2021,264(Pt2):12476.
[3]
Yang Y, Zhang L, Cheng J, et al. Microbial community evolution in partial nitritation/anammox process:from sidestream to mainstream[J]. Bioresource Technology, 2018,251(3):327-333.
[4]
李柏林,赵婉情,王恒,等.污泥比例强化CANON系统抵御快速降温效能及机理[J]. 中国环境科学, 2021,41(6):2622-2630. Li B L, Zhao W Q, Wang H, et al. Mechanism and efficiency of the CANON system against rapid cooling enhanced by flocculent sludge ratiosv[J]. China Environmental Science, 2021,41(6):2622-2630.
[5]
Yang D H, Chen W J, Liu W R,et al. High-throughput sequencing-based microbial characterization of size fractionated biomass in an anoxic anammox reactor for low-strength wastewater at low temperatures[J]. Bioresource Technology, 2017,231(5):45-52.
[6]
Zheng M, Wang Z Y, Meng J, et al. Inactivation kinetics of nitrite-oxidizing bacteria by free nitrous acid[J]. Science of the Total Environment, 2021,752:141876.
[7]
Jiang C, Xu S, Wang R, et al. Achieving efficient nitrogen removal from real sewage via nitrite pathway in a continuous nitrogen removal process by combining free nitrous acid sludge treatment and DO control[J]. Water Research, 2019,161(9):590-600.
[8]
Miao J, Yin Q, Hori T, et al. Nitrifiers activity and community characteristics under stress conditions in partial nitrification systems treating ammonium-rich wastewater[J]. Journal of Environmental Science, 2018,73:1-8.
[9]
Wang Q, Ye L, Jiang G, et al. Side-stream sludge treatment using free nitrous acid selectively eliminates nitrite oxidizing bacteria and achieves the nitrite pathway[J]. Water Research, 2014,55(5):245-255.
Ren Z Q, Li D, Zhang J, et al. Start-up of granular-flocculate sludge CANON process based on side-flow FNA treatment[J]. China Environmental Science, 2022,42(9):4129-4136.
[12]
Dapena-Mora A, Fernández I, Campos J L, et al. Evaluation of activity and inhibition effects on anammox process by batch tests based on the nitrogen gas production[J]. Enzyme Microbial Technology, 2006,40(4):859-865.
[13]
张宇坤,王淑莹,董怡君,等.游离氨和游离亚硝酸对亚硝态氮氧化菌活性的影响[J]. 中国环境科学, 2014,34(5):1242-1247. Zhang Y K, Wang S Y, Dong Y J, et al. Effect of FA and FNA on activity of nitrite-oxidising bacteria[J]. China Environmental Science, 2014,34(5):1242-1247.
[14]
郑照明,李军,侯爱月,等.城市生活污水SNAD生物膜脱氮特性[J]. 中国环境科学, 2017,37(4):1322-1330. Zheng Z M, Li J, Hou A Y, et al. Nitrogen removal performance of SNAD biofilm cultured by domestic wastewater[J]. China Environmental Science, 2017,37(4):1322-1330.
[15]
祁明镒.沉降技术的粒度分析[J]. 武汉钢铁学院学报, 1983,2:12-26. Qi M Y. Ore grain sizing by sedimentation technique[J]. Journal of Wuhan Institute of Iron and Steel, 1983,2:12-26.
[16]
李冬,刘名扬,张杰,等.厌氧氨氧化颗粒污泥的长期保藏及快速活性恢复[J]. 环境科学, 2021,42(6):2957-2965. Li D, Liu M Y, Zhang J, et al. Long-term storage and rapid activity recovery of anammox granular sludge[J]. Environmental Science, 2021,42(6):2957-2965.
[17]
Chu Z R, Wang K, Li X K, et al. Microbial characterization of aggregates within a one-stage nitritation-anammox system using high-throughput amplicon sequencing[J]. Chemical Engineering, 2015,262(2):41-48.
[18]
李冬,刘名扬,张杰,等.水力筛分间歇饥饿CANON工艺参数调控及稳定运行[J]. 哈尔滨工业大学学报, 2022,54(2):1-7. Li D, Liu M Y, Zhang J, et al. Optimization and stable operation of CANON process of intermittent starvation based on hydraulic screening[J]. Journal of Harbin Institute of Technology, 2022,54(2):1-7.
[19]
Li B, Wang Y, Li X, et al. Comparing the nitrogen removal performance and microbial communities of flocs-granules hybrid and granule-based CANON systems[J]. Science of Total Environment, 2020,703(2):134949.
[20]
Vlaeminck S E, Terada A, Smets B F, et al. Aggregate size and architecture determine microbial activity balance for one-stage partial nitritation and anammox[J]. Applied and Environmental Microbiology, 2010,76(3):900-909.
[21]
吕心涛.游离氨(FA)和游离亚硝酸(FNA)对亚硝酸盐氧化菌(NOB)活性的影响试验研究[D]. 兰州:兰州交通大学, 2017. Lv X T. Research on the effect of free ammonia(FA) and free nitrous acid(FNA) on the nitrite-oxidizing bacteria(NOB) acticity[D]. Lanzhou:Lanzhou Jiaotong University, 2017.
[22]
Yan Z, Ganda L, Lim M, et al. Free nitrous acid (FNA) inhibition on denitrifying poly-phosphate accumulating organisms (DPAOs)[J]. Applied Microbiology and Biotechnology, 2010,88(1):359-369.
[23]
吕心涛,蒋勇,孟春霖,等.好氧和缺氧条件下游离亚硝酸对氨氧化菌和亚硝酸盐氧化菌的选择性抑制[J]. 微生物学通报, 2019,46(8):1927-1935. Lv X T, Jiang Y, Meng C L, et al. Inhibitory of FNA on the activity of AOB and NOB under aerobic and anoxic conditions[J]. Microbiol. China, 2019,46(8):1927-1935.
[24]
Baumann B, Meer J, Snozzi M, et al. Inhibition of denitrification activity but not of mRNA induction in paracoccus denitrificans by nitrite at a suboptimal pH[J]. Antonie Van Leeuwenhoek, 1997,72(3):183-189.
[25]
吴军,张悦,徐婷,等.AOB溶解氧亲和力低于NOB条件下序批反应器中NOB淘汰的实现机制[J]. 中国环境科学, 2016,36(12):3583-3590. Wu J, Zhang Y, Xu T, et al. Mechanisms of partial nitrification in sequencing batch reactor under the condition of AOB oxygen affinity lower than NOB[J]. China Environmental Science, 2016,36(12):3583-3590.
[26]
Tokutomi T. Operation of a nitrite-type airlift reactor at low DO concentration[J]. Water Science and Technology, 2004,49(5/6):81-88.
[27]
TONG J, CHEN Y G. Recovery of nitrogen and phosphorus from alkaline fermentation liquid of waste activated sludge and application of the fermentation liquid to promote biological municipal wastewater treatment[J]. Water Research, 2009,43(12):2969-2976.
[28]
付雪.生物膜填料系统SBBR处理生活污水脱氮性能试验研究[D]. 兰州:兰州交通大学, 2021. Fu X. Experimental study on the denitrification performance of SBBR biofilm packing system treating domestic sewage[D]. Lanzhou:Lanzhou Jiaotong University, 2021.
[29]
Ma J X, Wang Z W, Wu Z C, et al. Aqueous nitrate removal by D417 resin:thermodynamic, kinetic and response surface methodology studies[J]. Asia-Pacific Journal of Chemical Engineering, 2012,7(6):856-867.
[30]
Michaelis M, Leopold C S. A measurement system analysis with design of experiments:Investigation of the adhesion performance of a pressure sensitive adhesive with the probe tack test[J]. International Journal of Pharmaceutics, 2015,496(2):448-456.
