Effect of nanoscale zero-valent iron on the denitrification performance of anaerobic ammonia oxidation
MA Jiao1,2,3, ZENG Tian-xu1,2,3, SONG Jun4, DANG Hong-zhong1,2,3, LI Wei-wei1,2,3,5, CHEN Yong-zhi1,2,3
1. Key Laboratory of Yellow River Water Environment in Gansu Province, Lanzhou Jiaotong University, Lanzhou 730070, China; 2. School of Environmental and Municipal Engineering, Lanzhou Jiaotong University, Lanzhou 730070, China; 3. Technical Center of Sewage Treatment Industry in Gansu Province, Lanzhou 730070, China; 4. Development and Reform Ministry of China State Railway Group Co., Ltd, Beijing 100844, China; 5. Gansu Research Institute of Light Industry Co., Ltd, Lanzhou 730070, China
Abstract：The effect of nanoscale zero-valent iron (nZVI) powder on the denitrification performance of anaerobic ammonia oxidation (ANAMMOX) reaction was investigated by adding nZVI into ASBR. When the concentrations of nZVI were 0, 10, 50, 100, 200, 500, and 1000mg/L at the temperatures of (25±0.5)℃, and the pH value of 7.5±0.5, the total nitrogen removal efficiencies (NRE) were 70.27%, 74.25%, 83.45%, 90.16%, 68.59%, 57.18%, and 50.93% under the influent NH4+-N and NO2--N concentrations of 30.35mg/L and 37.89mg/L, respectively. The kinetic analysis was carried out by the modified Boltzmann, Gompertz, and Logistic models,the R2 values were 0.9963, 0.9944, and 0.9851, respectively. The mean square errors of the effluent concentration of total nitrogen (TN) and NRE compared with the actual values were 2.13, 6.31, 8.48, and 6.93, 7.47, 10.95, respectively.Keywords:nZVI;ANAMMOX;nitrogen removal efficiency;kineticmodels
马娇, 曾天续, 宋珺, 党鸿钟, 李维维, 陈永志. 纳米单质铁对厌氧氨氧化脱氮性能的影响[J]. 中国环境科学, 2022, 42(6): 2619-2627.
MA Jiao, ZENG Tian-xu, SONG Jun, DANG Hong-zhong, LI Wei-wei, CHEN Yong-zhi. Effect of nanoscale zero-valent iron on the denitrification performance of anaerobic ammonia oxidation. CHINA ENVIRONMENTAL SCIENCECE, 2022, 42(6): 2619-2627.
吕恺,王康舟,姚雪薇,等.基于氨氮,硝氮及乙酸条件下Anammox菌的培养[J].中国环境科学, 2020,40(10):4348-4353.Lv K, Wang K Z, Yao X W, et al. Enrichment of Anammox under conditions of ammonium, nitrate and acetic acid as substrates[J]. China Environmental Science, 2020,40(10):4348-4353.
[2]
Erdim E, YücesoyÖ Z,Kurt H, et al. Overcoming challenges in mainstream Anammox applications:Utilization of nanoscale zero valent iron (nZVI)[J]. The Science of the total environment, 2019, 651(2):3023-3033.
[3]
Zhang Y, An X, Quan X. Enhancement of sludge granulation in a zero valence iron packed anaerobic reactor with a hydraulic circulation[J]. Process Biochemistry, 2011,46(2):471-476.
[4]
Christina F, Simon L H, Frauke B M, et al. Iron assimilation and utilization in anaerobic ammonium oxidizing bacteria[J]. Current Opinion in Chemical Biology, 2017,37(5):129-136.
[5]
董子阳,胡宝兰,韩佳慧.厌氧氨氧化细菌Candidatus Kuenenia stuttgartiensis铁的吸收利用研究进展[J].微生物学通报, 2021, 48(5):1780-1787.Dong Z Y, Hu B L, Han J H. Research progress in the uptake and utilization of iron by the anaerobic ammonium-oxidizing bacterium Candidatus Kuenenia stuttgartiensis[J]. Microbiology China, 2021, 48(5):1780-1787.
[6]
Peng D, Zhang J J. Research progress on treatment of low ammonia nitrogen wastewater by anaerobic ammonia oxidation process[J]. International Core Journal of Engineering, 2021,7(5):460-469.
[7]
雷欣,闫荣,慕玉洁,等.铁元素对厌氧氨氧化菌脱氮效能的影响[J].化工进展, 2021,40(5):2730-2738.Lei X, Yan R, Mu Y J, et al. Effect of iron on nitrogen removal efficiency of anaerobic ammonium oxidation bacteria[J]. Chemical Industry and Engineering Progress, 2021,40(5):2730-2738.
[8]
Ren L F, Ni S Q, Liu C,et al. Effect of zero-valent iron on the start-up performance of anaerobic ammonium oxidation (anammox) process[J]. Environment Science and Pollution Research International, 2015, 22(4):2925-3400.
[9]
Zhang Z Z, Xu J J, Shi Z J, et al. Unraveling the impact of nanoscale zero-valent iron on the nitrogen removal performance and microbial community of anammox sludge[J]. Bioresource Technology, 2017, 243:883-892.
[10]
Xu J J, Zhang Z Z, Ji Z Q, et al. Short-term effects of nanoscale Zero-Valent Iron (nZVI) and hydraulic shock during high-rate anammox wastewater treatment[J]. Journal of Environmental Management, 2018,215:248-257.
[11]
毛佩玥.短程反硝化耦合厌氧氨氧化处理生活污水试验研究[D].兰州:兰州交通大学, 2021.Mao P Y. Study on partial denitrification coupled with anaerobic ammonia oxidation to treat domestic sewage[D]. Lanzhou:Lanzhou Jiaotong University, 2021.
[12]
Guo B B, Chen Y H, Lv L, et al. Transformation of the zero valent iron dosage effect on anammox after long-term culture:From inhibition to promotion[J]. Process Biochemistry, 2019,78:132-139.
[13]
国家环境保护总局.水和废水监测分析方法[M]. 4版.北京:中国环境科学出版社, 2002.
[14]
Feng L, Li J, Ma H R, et al. Effect of Fe (II) on simultaneous marine anammox and Feammox treating nitrogen-laden saline wastewater under low temperature:Enhanced performance and kinetics[J]. Desalination, 2020,478(C):114287-114297.
[15]
Wang B, Sun B, Liu Y L, et al. Start-up of Anammox and Effect of Fe on Nitrogen Removal Rate[J]. IOP Conference Series:Earth and Environmental Science, 2021,787(1).
[16]
Bi Z, Zhang W J, Song G, et al. Iron-dependent nitrate reduction by anammox consortia in continuous-flow reactors:A novel prospective scheme for autotrophic nitrogen removal[J]. Science of the Total Environment, 2019,692(C):582-588.
[17]
Dong L W, Yan H S, A Q D, et al. Effects of nanoscale zero-valent iron particles on biological nitrogen and phosphorus removal and microorganisms in activated sludge[J]. Journal of Hazardous Materials, 2013,262:649-655.
[18]
Ni S Q, Sun N, Yang H L, et al. Distribution of extracellular polymeric substances in anammox granules and their important roles during anammox granulation[J]. Biochemical Engineering Journal, 2015,101:126-133.
[19]
Lefevre E, Bossa N, Wiesner M R, Gunsch C K, et al. A review of the environmental implications of in situ remediation by nanoscale zero valent iron (nZVI):Behavior, transport and impacts on microbial communities[J]. Science of the Total Environment, 2016,565:889-901.
[20]
谢丽,何莹莹,陆熙,等.铁对厌氧氨氧化过程及其微生物群落的影响[J].同济大学学报(自然科学版), 2020,48(8):1169-1178.Xie L, He Y Y, Lu X, et al. Effect of Iron on ANAMMOX Process and Microbial Community[J]. Journal of Tongji University (Natural Science), 2020,48(8):1169-1178.
[21]
Yan Y, Wang Y Y, Wang W G, et al. Comparison of short-term dosing ferrous ion and nanoscale zero-valent iron for rapid recovery of anammox activity from dissolved oxygen inhibition[J]. Water Research, 2019,153:284-294.
[22]
Mak C Y, Lin J G, Chen W H, et al. The short-and long-term inhibitory effects of Fe (II) on anaerobic ammonium oxidizing (anammox) process[J]. Water Science& Technology, 2019,79(10):1860-1867.
[23]
Gao F, Zhang H M,Yang F L, et al. The effects of zero-valent iron (ZVI) and ferro ferric oxide (Fe3O4) on anammox activity and granulation in anaerobic continuously stirred tank reactors (CSTR)[J]. Process Biochemistry, 2014,49(11):1970-1978.
[24]
Zhang S Q, Zhang L Q, Yao H N, et al. Responses of anammox process to elevated Fe (III) stress:reactor performance, microbial community and functional genes[J]. Journal of Hazardous Materials, 2021,414.
[25]
Liu S T, Horn H. Effects of Fe (II) and Fe (III) on the single-stage deammonification process treating high-strength reject water from sludge dewatering[J]. Bioresource Technology, 2012,114:12-19.
[26]
黄硕,于德爽,陈光辉,等.氧化石墨烯强化Anammox菌的脱氮性能[J].中国环境科学, 2019,39(5):1945-1953.Huang S, Yu D S, Chen G H, et al. Improvement of the activity of ANAMMOX bacteria using graphene oxide[J]. China Environmental Science, 2019,39(5):1945-1953.
[27]
李伟刚,于德爽,李津.ASBR反应器厌氧氨氧化脱氮Ⅱ:反应动力学[J].中国环境科学, 2013,33(12):2191-2200.Li W G, Yu D S, Li J. Nitrogen removal in the Anammox sequencing batch reactor II:Kinetics characteristics[J]. China Environmental Science, 2013,33(12):2191-2200.
[28]
唐佳佳,于德爽,王晓霞,等.盐度对中试厌氧氨氧化脱氮特性的影响及其恢复动力学[J].环境科学, 2018,39(11):5081-5089.Tang J J, Yu D S, Wang X X, et al. Effect of salinity on nitrogen removal performance of a pilot-scale anaerobic ammonia oxidation process and its recovery kinetics[J]. Environmental Science, 2018,39(11):5081-5089.
