Study on two-stage PNDPR coupled with Anammox for nitrogen and phosphorus removal
XU Gui-da1, LI Dong1, LIU Zhi-cheng1, TAO Bo1, ZHANG Jie1,2
1. Key Laboratory of Beijing Water Quality Science and Water Environment Recovery Engineering, Beijing University of Technology, Beijing 100124; 2. State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin 150090, China
Abstract:Considering that the influent of Anammox process must contain two substrates, NO2--N and NH4+-N, and it could only be denitrified. In order to further realize phosphorus removal on this basis, this study proposed to combine phosphorus removal and nitrogen removal with partial nitrification technology, namely partial nitrification and denitrifying phosphorus removal tandem Anammox process:the partial nitrification and denitrification phosphorus removal unit was the first to pass into domestic sewage to convert NH4+-N to NO2--N and remove part of COD. Part of the effluent was mixed with domestic sewage and enters the anaerobic ammonium oxidation unit. At the same time, the partial nitrification and denitrification phosphorus removal unit was denitrified and absorbed phosphorus under the hypoxia state, and the effluent of the two treatment units was mixed and discharged after the end of the reaction. The experimental results showed that controlling the influent mixing ratio to be 4.2 could ensure that the values of C/N and NO2-N/NH4+-N in the Anammox unit were 2 and 1.5, respectively, the average △NO2--N/△NH4+-N=1.41, △NO3--N/△NH4+-N=0.12, Anammox nitrogen 85.2% on average, denitrification and Anammox coupling reaction was good. After stable operation of the whole system, the effluent COD, P, NH4+-N, NO2--N and NO3--N concentrations were 15.2, 0.85, 0.59, 5.56 and 3.33mg/L, respectively, and the TN removal rate was 89.4%. The PNDPR-Anammox coupling new process successfully realized the efficient treatment of simulated domestic sewage.
徐贵达, 李冬, 刘志诚, 陶博, 张杰. 两级PNDPR耦合Anammox脱氮除磷工艺研究[J]. 中国环境科学, 2021, 41(11): 5133-5141.
XU Gui-da, LI Dong, LIU Zhi-cheng, TAO Bo, ZHANG Jie. Study on two-stage PNDPR coupled with Anammox for nitrogen and phosphorus removal. CHINA ENVIRONMENTAL SCIENCECE, 2021, 41(11): 5133-5141.
Hu J Y, Ong S L, Ng W J, et al. A new method for characterizing denitrifying phosphorus removal bacteria by using three different types of electron acceptors[J]. Water Res., 2003,37(14):3463-3471.
[2]
韦佳敏,刘文如,程洁红,等.反硝化除磷的影响因素及PAOs与GAOs耦合新工艺的研究进展[J]. 化工进展, 2020:1-13.Wei J M, Liu W R, Cheng J H, et al. Influencing factors of denitrifying phosphorus removal and advance research on novel process of coupling PAOs and GAOs[J]. Chemical Industry And Engineering Progress, 2020:1-13.
[3]
Zhao J, Wang X, Li X, et al. Advanced nutrient removal from ammonia and domestic wastewaters by a novel process based on simultaneous partial nitrification-anammox and modified denitrifying phosphorus removal[J]. Chem Eng J, 2018,354:589-598.
[4]
Xu X, Qiu L, Wang C, et al. Achieving mainstream nitrogen and phosphorus removal through simultaneous partial nitrification, anammox, denitrification, and denitrifying phosphorus removal (SNADPR) process in a single-tank integrative reactor[J]. Bioresource Technol., 2019,284:80-89.
[5]
Ji J, Peng Y, Wang B, et al. A novel SNPR process for advanced nitrogen and phosphorus removal from mainstream wastewater based on anammox, endogenous partial-denitrification and denitrifying dephosphatation[J]. Water Res., 2020,170:115363.
[6]
Wen X, Zhou J, Li Y, et al. A novel process combining simultaneous partial nitrification, anammox and denitrification (SNAD) with denitrifying phosphorus removal (DPR) to treat sewage[J]. Bioresource Technol., 2016,222:309-316.
[7]
Wang X, Zhao J, Yu D, et al. Evaluating the potential for sustaining mainstream anammox by endogenous partial denitrification and phosphorus removal for energy-efficient wastewater treatment[J]. Bioresource Technol., 2019,284:302-314.
[8]
Li J, Qiang Z, Yu D, et al. Performance and microbial community of simultaneous anammox and denitrification (SAD) process in a sequencing batch reactor[J]. Bioresource Technol., 2016,218:1064-1072.
[9]
Du R, Peng Y, Cao S, et al. Advanced nitrogen removal with simultaneous Anammox and denitrification in sequencing batch reactor[J]. Bioresource Technol., 2014,162:316-322.
[10]
Peng S, Xu J, Ruan W, et al. PPAR-γ activation prevents septic cardiac dysfunction via inhibition of apoptosis and necroptosis[J]. Oxid. Med. Cell Longev., 2017,2017:1-11.
[11]
Strous M, Van Gerven E, Zheng P, et al. Ammonium removal from concentrated waste streams with the anaerobic ammonium oxidation (Anammox) process in different reactor configurations[J]. Water Res., 1997,31(8):1955-1962.
[12]
马斌,张树军,王俊敏,等.A/O工艺实现城市污水半亚硝化与生物除磷[J]. 哈尔滨工业大学学报, 2012,44(2):70-74.Ma B, Zhang S J, Wang J M, et al. Partial nitritation and biological phosphorus removal in A/O process treating municipal wastewater[J]. Journal of Harbin Institute of Technology, 2012,44(2):70-74.
[13]
Sheng S, Liu B, Hou X, et al. Effects of different carbon sources and C/N ratios on the simultaneous anammox and denitrification process[J]. Int Biodeter Biodegr, 2018,127:26-34.
[14]
李冬,杨巧云,曾辉平,等.SAD工艺在厌氧氨氧化不同运行阶段的启动[J]. 中国环境科学, 2017,37(5):1775-1782.Li D, Yang Q Y, Zeng H P, et al. The startup of simultaneous anammox and denitrification process at different operational phases of anammox.[J]. China Environmental Science, 2017,37(5):1775-1782.
[15]
Kumar M, Lin J. Co-existence of anammox and denitrification for simultaneous nitrogen and carbon removal-Strategies and issues[J]. J Hazard Mater, 2010,178(1-3):1-9.
[16]
林皓.厌氧氨氧化-反硝化耦合处理合成革废水研究[J]. 水处理技术, 2020,46(2):98-103.Lin H. Study on anammox-denitrification coupled process for synthetic leather wastewater treatment[J]. Technology of Water Treatment, 2020,46(2):98-103.
[17]
Li J, Qi P, Li R, et al. Carbon and nitrogen removal through "Candidatus Brocadia sinica"-dominated simultaneous anammox and denitrification (SAD) process treating saline wastewater[J]. Biochem. Eng. J., 2018,140:72-76.
[18]
Tang C, Zheng P, Chai L, et al. Thermodynamic and kinetic investigation of anaerobic bioprocesses on ANAMMOX under high organic conditions[J]. Chem Eng J, 2013,230:149-157.
[19]
Takekawa M, Park G, Soda S, et al. Simultaneous anammox and denitrification (SAD) process in sequencing batch reactors[J]. Bioresource Technol, 2014,174:159-166.
[20]
Ge C, Sun N, Kang Q, et al. Bacterial community evolutions driven by organic matter and powder activated carbon in simultaneous anammox and denitrification (SAD) process[J]. Bioresource Technol., 2018, 251:13-21.
[21]
Henriques I D S, Love N G. The role of extracellular polymeric substances in the toxicity response of activated sludge bacteria to chemical toxins[J]. Water Res., 2007,41(18):4177-4185.
[22]
Duan X, Zhou J, Qiao S, et al. Application of low intensity ultrasound to enhance the activity of anammox microbial consortium for nitrogen removal[J]. Bioresource Technol., 2011,102(5):4290-4293.
[23]
Wang D, Wang G, Zhang G, et al. Using graphene oxide to enhance the activity of anammox bacteria for nitrogen removal[J]. Bioresource Technol., 2013,131:527-530.
[24]
Miao L, Zhang Q, Wang S, et al. Characterization of EPS compositions and microbial community in an Anammox SBBR system treating landfill leachate[J]. Bioresource Technol., 2018,249:108-116.
[25]
Li J, Qiang Z, Yu D, et al. Performance and microbial community of simultaneous anammox and denitrification (SAD) process in a sequencing batch reactor[J]. Bioresource Technol., 2016,218:1064-1072.
[26]
Heylen K, Vanparys B, Wittebolle L, et al. Cultivation of denitrifying Bacteria:Optimization of isolation conditions and diversity study[J]. Appl. Environ. Microb., 2006,72(4):2637-2643.
[27]
Steele D J, Franklin D J, Underwood G J C. Protection of cells from salinity stress by extracellular polymeric substances in diatom biofilms[J]. Biofouling, 2014,30(8):987-998.